Engine - Coolant Loss/Milky Engine Oil

File In Section: 06 - Engine/Propulsion System

Bulletin No.: 03-06-01-016

Date: May, 2003

TECHNICAL

Subject:
Loss of Coolant, Milky Colored Oil
(Replace Intermediate Intake Gasket)

Models:
2000-2003 Buick LeSabre, Park Avenue, Regal
2000-2003 Chevrolet Impala, Monte Carlo
2000-2003 Pontiac Bonneville
2000-2003 Pontiac Grand Prix
with 3.8L V6 Engine (VIN K - RPO L36)





Built Prior to the VIN Breakpoints shown.

Condition

Some owners may comment on a loss of coolant, coolant odor, having to add coolant or a milky substance on either the oil dipstick or oil fill cap. Additionally, owners may indicate that there are signs of coolant loss left on the ground where the vehicle is normally parked.

Cause

Condition may be due to coolant leaking past intermediate intake or throttle body gaskets.

Correction

Important:
The upper intake manifold should not be replaced for a coolant leak condition, unless a rare instance of physical damage is found. Even if the throttle body surface shows a slight warpage, the upper intake should not be replaced unless a drivability concern is noted or a relevant engine DTC, such as a code for an unmetered air leak, is set and the upper intake manifold can clearly be shown as the cause of the concern.

Thoroughly check for any external leaks. If no external leaks are found, then replace the intermediate intake manifold gasket and the throttle body gasket. When changing the throttle body gasket, the nuts that retain the throttle body should be replaced with a new design that improves torque retention. Medium strength thread locker should be applied to the studs before installing the new nuts.





Parts Information

Parts are currently available from GMSPO.

Warranty Information





For vehicles repaired under warranty use the table.





Disclaimer