Body - Popping/Snapping Noises On Rough Roads
TECHNICALBulletin No.: 08-08-64-010A
Date: February 12, 2009
Subject: Popping, Snapping or Itching Type Noise When Driving Over Rough Roads (Replace Door Striker)
Models:
2006-2009 Pontiac Solstice
2006-2009 Saturn SKY
2007-2009 Opel GT
2007-2009 Daewoo G2X
Supercede:
This bulletin is being revised to add the 2009 model year. Please discard Corporate Bulletin Number 08-08-64-010 (Section 08 - Body and Accessories).
Condition
Some customers may comment of a popping, snapping or itching type noise when driving over rough roads. They may also comment that the noise appears to be coming from the convertible top because the noise is at ear level.
Cause
This condition may be caused by a loose pin in the door striker.
Correction
Use a large screw driver and apply slight pressure across the door striker pin. If a popping or snapping noise is heard, replace the door striker.
1. Using a soft marker or masking tape, outline the position of the striker.
2. Remove the upper retaining screw and loosen the bottom one.
3. Rotate the striker downward.
4. With a small screw driver, align the anchor plate and install the screw.
5. Remove the lower screw and discard the striker.
6. Install the new striker and the lower screw.
7. Remove the upper screw and rotate the striker back in place.
8. With a small screw driver, align the anchor plate and install the screw.
Tighten
Tighten the screw to 20 Nm (15 lb ft).
9. Check the alignment of the door to the door striker. Refer to Door Lock Striker Adjustment in SI.
Parts Information
Warranty Information
Disclaimer