Repair and Diagnosis: Technical Service Bulletins
- How to Find Technical Service Bulletins by Category/Symptom
- Recalls
- Generals
- Campaign - Seat Edge Trim Cap Replacement
- Campaign - False 'Check Engine' Light ON
- Campaign - Headlamp Modification for Condensation
- Campaign - Incorrect Steering Wheel Installed
- Campaign - W522 PCM2 Update/Navigation CD Update
- Campaign - Console Selector Lever Screw Replacement
- Campaign - A/C Regulator Assembly Replacement
- Campaign - Towbar Control System Control Unit Update
- Campaign W561 - Tire Compressor Hose Adapter
- Campaign W575 - External Spare Tire Carrier Limit Switch
- Safety
- Generals
- Customer Interest
- Drivetrain - All Wheel Drive Defective Message Displayed
- Instruments - Wrong Time Indication in PCM2
- Brakes (Rear Axle) - Squeaking Noise
- Steering - Steering Wheel Shaking
- Steering - Steering Wheel Shakes While Driving
- Steering - Steering Wheel Grinding Noise
- Engine Controls - 'Kickdown' Adaptation Faulty
- A/T, Engine Controls - Hard 1-2 Shifting
- Engine Controls - PSM Warning Lamp ON
- Steering Rattling Noise in Footwell Area
- Lighting - Headlamps Misting Up On The Inside
- Lighting - Headlamp Shaking While Driving
- Electrical - Multiple Malfunctions
- Drivetrain - '4WD' System Faulty Message/DTC 2039
- SRS - Air Bag Lamp ON/DTC's 1217/1218 Stored
- Washers/Wipers - Rear Washer Nozzle Drips/Leaks
- Interior - Center Console Lid Can't be Opened
- Antitheft/Keyless Entry - Remote Inoperative
- A/C - Erratic/Inoperative Auxiliary Heater Operation
- Wheels/Tires - Steering Wheel Shaking at 50-75 MPH
- Keyless Entry System - Multiple Malfunctions
- Body - Multiple Malfunctions of The Locking System
- Navigation System - Destination Input Not Possible
- Navigation System - Start Screen Visible Too Long
- Air Suspension - Fault Code 0003/Warning Lamp ON
- Audio System - Sporadic Sound Failure
- Body - Front Door Window Wind Noise
- Air Bag System - Warning Lamp ON/Codes 1217/1218
- Engine Controls - Poor Engine Performance/Hard Start
- Electrical System - Malfunctions Due To Water Leaks
- Drivetrain Controls - Transfer Case Noises
- Body - Front Doors Do Not Close Properly
- Engine Controls - Engine Slow To Respond
- PCM 2.0 - Control Knob Replacement
- Auxiliary Heating System - Ticking Sound
- Engine Controls - Rough Idle/Jerking While Driving
- Engine - Oil Leaks From Turbocharger Pressure Hose
- Cooling System - Plastic Coolant Pipes Leaking
- Engine Controls - Reduced Throttle Response
- A/T - Fluid Leak From The Torque Converter Area
- Recommended Repairs
- Superceded Bulletins
- 37/03 - 12/18/03
- 20/07 - 12/21/07
- 66/04 - 06/23/06
- 611/03 - 08/22/03
- 91/05 - 07/28/05
- 26/03 - 05/01/06
- 09/03 - 05/01/06
- 405/01 - 09/30/05
- 418/04 - 01/27/05
- 46/03 - 12/18/03
- 20401 - 11/08/04
- 31/04 - 08/10/04
- 34/03 - 09/12/03
- 3/02 - 02/28/03
- 23/02 - 03/07/03
- 2/02 - 02/27/03
- Body - Rocker Guard Installation Instructions
- Body - Body Side Logo Installation Instructions
- Body - Running Board Installation Instructions
- Trailer Hitch - Installation Instructions
- Accessories - Homelink(R) Garage Door Opener Retrofit
- Keyless Entry - Various Operational Problems
- SRS - Warning Lamp ON/DTC's 1218/1217 Set
- SRS - Warning Lamp ON/DTC's 1217/1218 Set
- Battery - Care & Maintenance/Power Supply
- Battery - Maintenance and Charging
- Battery - Charging Requirements/Procedure
- A/T - Hard Cold Shifting
- Ignition System - Ignition Coil Replacement
- Engine - Apparent Turbocharger Pressure Hose Oil Leaks
- Engine Controls - Battery Charging During Diagnostics
- DME - Programming Restart After Aborted Attempt
- Engine - Porsche Approved Engine Oils
- Engine - Engine Oils Approve by Porsche
- Engine - Approved Engine Oils
- Engine - Engine Oils Approved by Porsche
- Tires/Wheels - Approved Summer Tires/Wheels
- Tires/Wheels - Winter Tires and Wheels
- Tires/Wheels - Approved Summer Tires and Wheels
- Tires/Wheels - Winter Wheels and Tires
- Wheels/Tires - Overview of Tires, Wheels, Spacer Rings
- Wheels/Tires - Steering Wheel Shake at 50-75 MPH
- Wheels/Tires - Tire/Wheel and Spacer Overview
- Engine - Engine Oils Approved By Porsche
- Wheels/Tires - Wheel/Tire/Spacer Overview
- Wheels/Tires - Approved Tires, Wheels and Spacers
- Engine - Overview Of Approved Engine Oils
- Engine - Approved Engine Oil Specifications
- Engine Controls - Driveability Problems Advisory
- All Technical Service Bulletins
- Body - Body Side Logo Installation Procedure
- Body - Body Side Moulding Installation Instructions
- Body - Side Molding Installation
- Steering/Suspension - Vehicle Pulls Or Steering Wheel Offline
- Drivetrain - All Wheel Drive Defective Message Displayed
- Fuel System - Fuel Filter/Fuel Pipe Replacement Info.
- Vehicle - Use Only Approved Parts For Collision Repairs
- Instruments - Wrong Time Indication in PCM2
- Brakes (Rear Axle) - Squeaking Noise
- Vehicle - Performance Kit Installation
- Steering - Steering Wheel Shaking
- Steering - Steering Wheel Shakes While Driving
- Wheels - 17mm Spacer Ring Installation
- Wheels/Brakes - Wheels for 19 Inch Brake Rotors
- Body - Rear Stainless Bumper Strip Cleaning Precautions
- Campaign - Seat Edge Trim Cap Replacement
- Steering - Steering Wheel Grinding Noise
- Engine Controls - Control Unit/Software Replacement
- Engine Controls - Unnecessary DME Module Replacement
- Engine Controls - 'Kickdown' Adaptation Faulty
- A/T, Engine Controls - Hard 1-2 Shifting
- Engine Controls - PSM Warning Lamp ON
- Steering Rattling Noise in Footwell Area
- Battery - Auxiliary Battery Deletion
- Starting System - Auxiliary Battery Operation/Service
- Engine Controls - DME Programming After Interruption
- Campaign - False 'Check Engine' Light ON
- Cellular Phone - Preparation for Installation
- Cell Phone - THB System 8 Installation
- Recall 04V593000: Seat Belt Defect
- Lighting - Headlamps Misting Up On The Inside
- Lighting - Headlamp Shaking While Driving
- Campaign - Headlamp Modification for Condensation
- Electrical - Multiple Malfunctions
- Porsche Stability Management - Diagnosis/Repair
- Campaign - Incorrect Steering Wheel Installed
- Body - Rocker Guard Installation
- Body - Sport Design Package Installation
- Electrical - Aftermarket Antitheft Installation Warning
- Campaign - W522 PCM2 Update/Navigation CD Update
- Suspension - Level Control System Calibration
- Drivetrain - '4WD' System Faulty Message/DTC 2039
- SRS - Air Bag Lamp ON/DTC's 1217/1218 Stored
- Recall 04V231000: Seat Belt Buckle Latch Defect
- Washers/Wipers - Rear Washer Nozzle Drips/Leaks
- Engine - Porsche Approved Oils
- Campaign - Console Selector Lever Screw Replacement
- Interior - Center Console Lid Can't be Opened
- Audio System - CD Changer Installation Instructions
- Antitheft/Keyless Entry - Remote Inoperative
- A/T - Revised Fluid Filling Capacities
- Campaign - A/C Regulator Assembly Replacement
- Fuel System - Aluminum Look Fuel Cap Retrofitting
- A/C - Erratic/Inoperative Auxiliary Heater Operation
- Electrical - Wiring Diagram Applications
- Wheels/Tires - Summer Wheel/Tire Applications
- Wheels/Tires - Winter Tire/Wheel Applications
- Tires/Wheels - Approved Summer Tires And Wheels
- Wheels/Tires - Steering Wheel Shaking at 50-75 MPH
- Keyless Entry System - Multiple Malfunctions
- Body - Roof Rail Installation/Service Precautions
- Body - Multiple Malfunctions of The Locking System
- Navigation System - Destination Input Not Possible
- Navigation System - Start Screen Visible Too Long
- Porsche Communication Management 2 - Installation
- Navigation - Off-Road Module Installation Instructions
- Air Suspension - Fault Code 0003/Warning Lamp ON
- Body - Running Board Installation
- A/T - Electrohydraulic Control Unit Replacement
- Body - Front Skid Plate Installation
- Drivetrain - Porsche Approved Oils/Lubricants
- Drivetrain - Final Drive/Transfer Case Oils/Capacities
- Audio System - Sporadic Sound Failure
- Auxiliary Equipment/Audio - Spare Parts Requirements
- Engine - Timing Cover Bolt Replacement
- Campaign - Towbar Control System Control Unit Update
- Tires/Wheels - Spare Tire Carrier Installation/Service
- Body - Stainless Steel Door Entry Guard Installation
- Body - Front Door Window Wind Noise
- Air Bag System - Warning Lamp ON/Codes 1217/1218
- Engine - Camshaft Housing Screw Replacement
- Steering/Suspension - Front Axle Alignment Specs.
- Recall 04V068000: Fuel Filler Neck Ground Inspection
- Recall 04V072000: Driver Side Seat Frame Defect
- Body - Roof Strip Installation
- Power Steering - Component Replacement
- Recall 04V069000: Wiring Harness Inspection/Replacement
- PCM2.0/PCM2.1 Control Unit - Display Pixel Errors
- Drivetrain - Unnecessary Transfer Case Replacement
- Engine Controls - Poor Engine Performance/Hard Start
- Electrical System - Malfunctions Due To Water Leaks
- Campaign W561 - Tire Compressor Hose Adapter
- M/T - Clutch Hydraulic Fluid Update
- Wipers/Washers - New Washer Fluid
- Campaign W575 - External Spare Tire Carrier Limit Switch
- Drivetrain Controls - Transfer Case Noises
- Battery - Care and Maintenance/Power Supply
- Body - Front Doors Do Not Close Properly
- Engine Controls - Engine Slow To Respond
- PCM 2.0 - Control Knob Replacement
- HomeLink(R) - Garage Door Opener Retrofit
- Auxiliary Heating System - Ticking Sound
- Battery - Care and Maintenance Procedures
- Accessories - Roof Box Assembly Instructions and Use
- Engine - Approved Engine Oils Overview
- Interior - Cargo Management System Retrofitting
- Wheels/Tires - Approved Tires/Wheels/Spacers
- Accessories - Trailer Hitch Retrofitting
- Tire Monitor System - Troubleshooting Tips
- Cooling System - Cleaning After Oil Contamination
- Engine Controls - Rough Idle/Jerking While Driving
- Engine - Oil Leaks From Turbocharger Pressure Hose
- Navigation System - PCM2.0 Navigation Update
- Audio System - Music Player Interface Retrofitting
- Cooling System - Plastic Coolant Pipes Leaking
- Tire Monitor System - Inactive After Wheel Change
- Engine - Approved Porsche A40 Engine Oils
- Tires/Wheels - Handling Instructions After Damaged
- Ignition System - Bar Ignition Module Replacement
- Engine Controls - Reduced Throttle Response
- Body - Roof Box Installation Instructions
- Engine - Approved Engine Oil Specification
- PCM2.0/PCM2.1(R) - Permissible Display Pixel Errors
- A/T - Fluid Leak From The Torque Converter Area
- Body - Roof Box Assembly And Usage