702319 Removing and installing trim panel for spring strut mount
WM 702319 Removing and installing trim panel for spring strut mount
Technical values
Preliminary work
1. Remove cover for rear. -> 705319 Removing and installing cover for rear - section on "Removing" 705319 Removing and installing rear cover.
2. Remove C-pillar trim panel. -> 706819 Removing and installing C-pillar trim panel - section on "Removing" 706819 Removing and Installing C-Pillar Trim Panel
Removing trim panel for spring strut mount
Installation position of trim panel for spring strut mount
1. Undo fastening screws -1-.
Removing trim panel for spring strut mount
Information
- To reduce the unclipping forces and thereby the risk of damage during removal, the removal steps must be carried out at the accessible connection points using a suitable tool.
2. Unclip trim panel for spring strut mount -2- first upwards -Arrows A- and then pull out slightly in -direction of Arrow B-.
3. Press locking tabs together -Arrows a- and disconnect connector for loudspeaker -1-.
Disconnecting connector for loudspeaker
4. Check fastening nuts -1- and clamps -2, 3- , and replace if necessary.
Checking fastening nut and clamps
Installing trim panel for spring strut mounts
Installation position of trim panel for spring strut mount
1. Push in connector for loudspeaker -1- until the locking tabs engage.
Pushing in connector for loudspeaker
Information
Make sure that the tie-down rings are not pinched.
2. Insert trim panel for spring strut mount -2- in the side trim panel -Arrows A- and press down until the clamps engage -Arrows B-.
Installing trim panel for spring strut mount
3. Align gap of trim panel for spring strut mount -2- to shelf and tighten fastening screws -1-. => Tightening torque: 1.5 Nm (1.0 ftlb.)
Subsequent work
1. Install C-pillar trim. -> 706819 Removing and installing C-pillar trim - section on "Installing" 706819 Removing and Installing C-Pillar Trim Panel
2. Install cover for rear. -> 705319 Removing and installing cover for rear - section on "Installing" 705319 Removing and installing rear cover.