Emission Control Systems: Technical Service Bulletins

• Customer Interest
  • MIL ON - DTC P0141, Rear Heated O2 Sensor & PROM
  • EGR System - MIL ON/EGR DTC's Stored.
    • Overview
    • EGR - Insufficient Flow Detected
    • EGR - Pintle Position Error
    • EGR - Voltage Our of Range - Open/Short
    • EGR - Closed Position Error
  • Emissions - MIL ON/DTC P0440 (EVAP) Set
  • EVAP - Knocking or Rattle Noise at Right Front of Floor
• By Symptom
  • Customer Interest
    • MIL ON - DTC P0141, Rear Heated O2 Sensor & PROM
    • EGR System - MIL ON/EGR DTC's Stored.
      • Overview
      • EGR - Insufficient Flow Detected
      • EGR - Pintle Position Error
      • EGR - Voltage Our of Range - Open/Short
      • EGR - Closed Position Error
    • Emissions - MIL ON/DTC P0440 (EVAP) Set
    • EVAP - Knocking or Rattle Noise at Right Front of Floor
  • Driveability
    • Engine - Runs Rough, Surges at Idle, Stalls After Start
      • Overview
      • Procedures
  • Erratic Operation
    • Engine - Runs Rough, Surges at Idle, Stalls After Start
      • Overview
      • Procedures
  • False instrument warning light/gauges
    • EGR System - MIL ON/EGR DTC's Stored.
      • Overview
      • EGR - Insufficient Flow Detected
      • EGR - Pintle Position Error
      • EGR - Voltage Our of Range - Open/Short
      • EGR - Closed Position Error
  • Inoperative
    • MIL ON - DTC P0141, Rear Heated O2 Sensor & PROM
  • Noise
    • EVAP - Knocking or Rattle Noise at Right Front of Floor
  • Out of specification
    • Engine - Runs Rough, Surges at Idle, Stalls After Start
      • Overview
      • Procedures
• All Technical Service Bulletins
  • 01-T-29A - BULLETIN CANCELLATION NOTIFICATION
  • Emissions - OBDII I/M Readiness Testing
  • Engine Controls - MIL Function During I/M Testing
  • Engine - Runs Rough, Surges at Idle, Stalls After Start
    • Overview
    • Procedures
  • MIL ON - DTC P0141, Rear Heated O2 Sensor & PROM
  • Ignition - No Start, or Stall Then Long Crank/DTCs P0300
  • Misfire Calibration - Service Information
    • Overview
    • EGR - Pintle Position Error
    • EGR - Voltage Out of Range - Open/Short
    • Transaxle Fluid Temperature/IAT/ECT Sensor
    • EGR - Closed Position Error
    • MAP/TP Sensor Circuit - Range/Performance
    • Crankshaft Notch Adaptive Not Learned
  • EGR System - MIL ON/EGR DTC's Stored.
    • Overview
    • EGR - Insufficient Flow Detected
    • EGR - Pintle Position Error
    • EGR - Voltage Our of Range - Open/Short
    • EGR - Closed Position Error
  • Emissions - MIL ON/DTC P0440 (EVAP) Set
  • Engine Controls - Revised DTC P1406 Diagnosis, EGR
  • EVAP - Knocking or Rattle Noise at Right Front of Floor