Keyless Entry - Reduced Range Above 95 F. Interior Temp.
BULLETIN NO.: 96-T-62AISSUE DATE: December, 1997
GROUP/SEQ. NO.: Electrical-04
CORPORATION NO.: 688104R
SUBJECT:
Remote Keyless Entry and/or Saturn Security System Inoperative at Temperatures Above 36°C (95°F) (Replace RKE or RKE/SSS Module)
Due to the addition of 1997 model vehicles and revisions to the service procedures, this bulletin supercedes bulletin 96-T-62, which should be discarded
MODELS AFFECTED:
1996 & 1997 Saturns with RKE/SSS (AU0)
CONDITION:
Some 1996 & 1997 Saturns equipped with the remote keyless entry (RKE) or remote keyless entry/Saturn security system (RKE/SSS) may exhibit a significant reduction in transmitter/receiver operating range during high vehicle interior temperatures of approximately 36°C (95°F) or above. This loss of range may be perceived as an inoperative condition. The transmitter/receiver may function normally once the vehicle interior temperature cools below 36°C (95°F).
CAUSE:
The loss of range may be due to an increase in internal resistance within the RKE or RKE/SSS module.
CORRECTION:
For 1996 vehicles:
If condition is verified as heat related, replace the suspected RKE module. (Refer to the "1996 Revised Electrical Service Manual" for removal and installation procedures).
^ For 1996 vehicles equipped with factory installed remote keyless entry (RKE) (no security system) use RKE module P/N 21023127.
^ For 1996 vehicles equipped with Retailer installed Saturn security system (SSS), use RKE/SSS module P/N 21024608. (Refer to "Programming the Saturn Security System" in this bulletin if RKE module [P/N 21024608] is installed in vehicle.)
If condition is not heat related, refer to "1996 Revised Electrical Service Manual" for further diagnosis.
For 1997 vehicles:
If condition is verified as heat related, replace RKE/SSS module with P/N 21024608. (Refer to the "1997 Revised Electrical Service Manual" for removal and installation procedures.)
(Refer to "Programming the Saturn Security System" in this bulletin if RKE module [P/N 21024608] is installed in vehicle.)
If condition is not heat related, refer to "1997 Revised Electrical Service Manual" for further diagnosis.
PROGRAMMING THE SATURN SECURITY SYSTEM
IMPORTANT:
The following information is for 1996 vehicles equipped with Retailer installed RKE/SSS or 1997 vehicles that have had RKE/SSS module P/N 21024608 installed.
The Saturn Security System can be programmed to any of the following modes; however, unless otherwise requested by the customer, the Saturn Security System should be programmed to mode 1. If the customer requests the passive arming feature to be enabled, use mode 5.
IMPORTANT:
The RKE or RKE/SSS module will be shipped with two pocket information cards and one owners manual page addendum indicating the optional mode selections and operating procedures. Forward this information to the vehicle owner.
PARTS REQUIREMENTS:
1996 Vehicles with factory installed RKE
21023127 Module Asm-R/Con Dr Lk Rcvr
1996 Vehicles with Retailer installed RKE/SSS
21024608 Module Asm-R/Con Dr Lk Rcvr
1997 Vehicles with factory or Retailer installed RKE/SSS
21024608 Module Asm-R/Con Dr Lk Rcvr
CLAIM INFORMATION:
To receive credit for this repair during the warranty coverage period, submit a claim through the Saturn Dealer System using the appropriate Electronic Labor Time Guide and Labor Operation Code R4480 (Remote Door/Rear Compartment Lock Receiver Replace).