Installation (from 10/2010)
SUPPLEMENTAL RESTRAINT SYSTEM: CURTAIN SHIELD AIRBAG ASSEMBLY: INSTALLATION
CAUTION:
Some of these service operations affect the SRS airbag system. Read the precautionary notices concerning the SRS airbag system before servicing Service Precautions.
HINT
The procedure described below is for the RH side. Use the same procedure for both the RH and LH sides, unless otherwise specified.
1. INSTALL CURTAIN SHIELD AIRBAG ASSEMBLY RH
(a) Check that the ignition switch is off.
(b) Check that the battery negative (-) terminal is disconnected.
CAUTION:
Wait for 90 seconds after disconnecting the cable to prevent airbag deployment.
(c) Install 4 new clips and 4 new spacers to the curtain shield airbag assembly as shown in the illustration.
HINT
* Do not push in the pin.
* Make sure that the clips are installed in the correct direction.
* Make sure that the spacers are installed properly, in the correct direction, and that they are not damaged.
Text in Illustration
(d) Install the curtain shield airbag assembly with 6 new bolts.
Torque : 13 Nm (133 kgf-cm, 10 ft-lbf)
NOTICE:
Do not twist the curtain shield airbag assembly when installing it.
(e) Install the 4 clips with the curtain shield airbag assembly to the body panel as shown in the illustration.
NOTICE:
Make sure that the pins of the clips are pushed in firmly.
(f) Mark the clips.
HINT
Mark the clips to make sure that they are not reused.
Text in Illustration
(g) Connect the airbag connector.
NOTICE:
Securely lock the locking button.
Text in Illustration
2. INSTALL ROOF HEADLINING Installation (from 10/2010)
3. INSTALL UPPER INSTRUMENT PANEL SUB-ASSEMBLY Installation
4. INSTALL GLOVE COMPARTMENT DOOR ASSEMBLY Installation
5. INSTALL COMBINATION METER ASSEMBLY Installation
6. INSTALL INSTRUMENT CLUSTER FINISH PANEL ASSEMBLY Installation
7. INSTALL INSTRUMENT CLUSTER FINISH LOWER PANEL Installation
8. INSTALL INSTRUMENT CLUSTER FINISH CENTER PANEL SUB-ASSEMBLY Installation
9. INSTALL SUN ROOF OPENING TRIM MOULDING (w/ Sliding Roof) Installation (from 10/2010)
10. INSTALL MAP LIGHT ASSEMBLY (w/o Sliding Roof) Installation (from 10/2010)
11. REMOVE MAP LIGHT ASSEMBLY (w/ Sliding Roof) Installation (from 10/2010)
12. INSTALL ROOM LIGHT ASSEMBLY Installation (from 10/2010)
13. INSTALL VISOR HOLDER Installation (from 10/2010)
14. INSTALL VISOR ASSEMBLY RH Installation (from 10/2010)
15. INSTALL VISOR ASSEMBLY LH Installation (from 10/2010)
16. INSTALL ASSIST GRIP Installation (from 10/2010)
17. INSTALL FRONT PILLAR GARNISH RH Installation (from 10/2010)
18. INSTALL FRONT PILLAR GARNISH LH Installation (from 10/2010)
19. INSTALL CENTER PILLAR UPPER GARNISH RH Removal (from 10/2010)
20. INSTALL CENTER PILLAR UPPER GARNISH LH Installation (from 10/2010)
21. INSTALL CENTER PILLAR LOWER GARNISH RH Installation (from 10/2010)
22. INSTALL CENTER PILLAR LOWER GARNISH LH Installation (from 10/2010)
23. INSTALL FRONT SEAT OUTER BELT ASSEMBLY RH Installation (from 10/2010)
24. INSTALL FRONT SEAT OUTER BELT ASSEMBLY LH Installation (from 10/2010)
25. INSTALL SEAT BELT ANCHOR COVER CAP Installation (from 10/2010)
26. INSTALL ROOF SIDE INNER GARNISH ASSEMBLY RH Installation (from 10/2010)
27. INSTALL ROOF SIDE INNER GARNISH ASSEMBLY LH Installation (from 10/2010)
28. INSTALL DECK TRIM SIDE PANEL ASSEMBLY RH Installation (from 10/2010)
29. INSTALL DECK TRIM SIDE PANEL ASSEMBLY LH Installation (from 10/2010)
30. INSTALL REAR SEAT OUTER BELT ASSEMBLY RH Installation (from 10/2010)
31. INSTALL REAR SEAT OUTER BELT ASSEMBLY LH Installation (from 10/2010)
32. INSTALL REAR SEAT BACK HINGE Installation (from 10/2010)
33. INSTALL LUGGAGE HOLD BELT STRIKER ASSEMBLY Installation (from 10/2010)
34. INSTALL REAR DECK TRIM COVER Installation (from 10/2010)
35. INSTALL REAR DOOR OPENING TRIM WEATHERSTRIP RH Installation (from 10/2010)
36. INSTALL REAR DOOR OPENING TRIM WEATHERSTRIP LH Installation (from 10/2010)
37. INSTALL REAR DOOR SCUFF PLATE RH Installation (from 10/2010)
38. REMOVE REAR DOOR SCUFF PLATE LH Installation (from 10/2010)
39. INSTALL FRONT DOOR OPENING TRIM WEATHERSTRIP RH Installation (from 10/2010)
40. INSTALL FRONT DOOR OPENING TRIM WEATHERSTRIP LH Installation (from 10/2010)
41. INSTALL COWL SIDE TRIM BOARD RH Installation (from 10/2010)
42. INSTALL COWL SIDE TRIM BOARD LH Installation (from 10/2010)
43. INSTALL FRONT DOOR SCUFF PLATE RH Installation (from 10/2010)
44. INSTALL FRONT DOOR SCUFF PLATE LH Installation (from 10/2010)
45. INSTALL REAR SEATBACK ASSEMBLY RH Installation
46. INSTALL REAR SEATBACK ASSEMBLY LH Installation
47. INSTALL REAR SEAT CUSHION WITH COVER PAD SUB-ASSEMBLY Installation
48. INSTALL DECK FLOOR BOX RH Installation (from 10/2010)
49. INSTALL DECK FLOOR BOX LH Installation (from 10/2010)
50. INSTALL REAR DECK FLOOR BOX Installation (from 10/2010)
51. INSTALL REAR FLOOR CARPET ASSEMBLY Installation (from 10/2010)
52. CONNECT CABLE TO NEGATIVE BATTERY TERMINAL
Torque : 5.4 Nm (55 kgf-cm, 48 in-lbf)
53. INSPECT SRS WARNING LIGHT
Diagnosis System