Installation (to 10/2010)
SUPPLEMENTAL RESTRAINT SYSTEM: CURTAIN SHIELD AIRBAG ASSEMBLY: INSTALLATION
CAUTION:
Some of these service operations affect the SRS airbag system. Read the precautionary notices concerning the SRS airbag system before servicing Service Precautions.
HINT
The procedure described below is for the RH side. Use the same procedure for both the RH and LH sides, unless otherwise specified.
1. INSTALL CURTAIN SHIELD AIRBAG ASSEMBLY RH
(a) Check that the ignition switch is off.
(b) Check that the battery negative (-) terminal is disconnected.
CAUTION:
Wait for 90 seconds after disconnecting the cable to prevent airbag deployment.
(c) Install 4 new clips and 4 new spacers to the curtain shield airbag assembly as shown in the illustration.
HINT
* Do not push in the pin.
* Make sure that the clips are installed in the correct direction.
* Make sure that the spacers are installed properly, in the correct direction, and that they are not damaged.
(d) Install the curtain shield airbag assembly with 6 new bolts.
Torque : 13 Nm (133 kgf-cm, 10 ft-lbf)
NOTICE:
Do not twist the curtain shield airbag assembly when installing it.
(e) Install the 4 clips with the curtain shield airbag assembly to the body panel as shown in the illustration.
NOTICE:
Make sure that the pins of the clips are pushed in firmly.
(f) Mark the clips.
HINT
Mark the clips to make sure that they are not reused.
(g) Connect the airbag connector.
NOTICE:
Securely lock the locking button.
2. INSTALL ROOF HEADLINING Installation (to 10/2010)
3. INSTALL UPPER INSTRUMENT PANEL SUB-ASSEMBLY Installation
4. INSTALL GLOVE COMPARTMENT DOOR ASSEMBLY Installation
5. INSTALL COMBINATION METER ASSEMBLY Installation
6. INSTALL INSTRUMENT CLUSTER FINISH PANEL ASSEMBLY Installation
7. INSTALL INSTRUMENT CLUSTER FINISH LOWER PANEL Installation
8. INSTALL INSTRUMENT CLUSTER FINISH CENTER PANEL SUB-ASSEMBLY Installation
9. INSTALL MAP LIGHT ASSEMBLY Installation (to 10/2010)
10. INSTALL ROOM LIGHT ASSEMBLY Installation (to 10/2010)
11. INSTALL VISOR HOLDER Installation (to 10/2010)
12. INSTALL VISOR ASSEMBLY RH Installation (to 10/2010)
13. INSTALL VISOR ASSEMBLY LH Installation (to 10/2010)
14. INSTALL ASSIST GRIP Installation (to 10/2010)
15. INSTALL FRONT PILLAR GARNISH RH Installation (to 10/2010)
16. INSTALL FRONT PILLAR GARNISH LH Installation (to 10/2010)
17. INSTALL CENTER PILLAR UPPER GARNISH RH Installation (to 10/2010)
18. INSTALL CENTER PILLAR UPPER GARNISH LH Installation (to 10/2010)
19. INSTALL CENTER PILLAR LOWER GARNISH RH Installation (to 10/2010)
20. INSTALL CENTER PILLAR LOWER GARNISH LH Installation (to 10/2010)
21. INSTALL FRONT SEAT OUTER BELT ASSEMBLY RH Installation (to 10/2010)
22. INSTALL FRONT SEAT OUTER BELT ASSEMBLY LH Installation (to 10/2010)
23. INSTALL SEAT BELT ANCHOR COVER CAP Installation (to 10/2010)
24. INSTALL ROOF SIDE INNER GARNISH ASSEMBLY RH Installation (to 10/2010)
25. INSTALL ROOF SIDE INNER GARNISH ASSEMBLY LH Installation (to 10/2010)
26. INSTALL DECK TRIM SIDE PANEL ASSEMBLY RH Installation (to 10/2010)
27. INSTALL DECK TRIM SIDE PANEL ASSEMBLY LH Installation (to 10/2010)
28. INSTALL REAR SEAT OUTER BELT ASSEMBLY RH Installation (to 10/2010)
29. INSTALL REAR SEAT OUTER BELT ASSEMBLY LH Installation (to 10/2010)
30. INSTALL REAR SEAT BACK HINGE Installation (to 10/2010)
31. INSTALL LUGGAGE HOLD BELT STRIKER ASSEMBLY Installation (to 10/2010)
32. INSTALL REAR DECK TRIM COVER Installation (to 10/2010)
33. INSTALL REAR DOOR OPENING TRIM WEATHERSTRIP RH Installation (to 10/2010)
34. INSTALL REAR DOOR OPENING TRIM WEATHERSTRIP LH Installation (to 10/2010)
35. INSTALL REAR DOOR SCUFF PLATE RH Installation (to 10/2010)
36. INSTALL FRONT DOOR OPENING TRIM WEATHERSTRIP RH Installation (to 10/2010)
37. INSTALL FRONT DOOR OPENING TRIM WEATHERSTRIP LH Installation (to 10/2010)
38. INSTALL COWL SIDE TRIM BOARD RH Installation (to 10/2010)
39. INSTALL COWL SIDE TRIM BOARD LH Installation (to 10/2010)
40. INSTALL FRONT DOOR SCUFF PLATE RH Installation (to 10/2010)
41. INSTALL FRONT DOOR SCUFF PLATE LH Installation (to 10/2010)
42. INSTALL REAR SEATBACK ASSEMBLY RH Installation
43. INSTALL REAR SEATBACK ASSEMBLY LH Installation
44. INSTALL REAR SEAT CUSHION WITH COVER PAD SUB-ASSEMBLY Installation
45. INSTALL DECK FLOOR BOX RH Installation (to 10/2010)
46. INSTALL DECK FLOOR BOX LH Installation (to 10/2010)
47. INSTALL REAR DECK FLOOR BOX Installation (to 10/2010)
48. INSTALL REAR FLOOR CARPET ASSEMBLY Installation (to 10/2010)
49. CONNECT CABLE TO NEGATIVE BATTERY TERMINAL
Torque : 5.4 Nm (55 kgf-cm, 48 in-lbf)
50. INSPECT SRS WARNING LIGHT
Diagnosis System