Recall - PCM PROM Update for Engine Stalling
VERONASection Title: Engine
TSB No. TS 02 09214R
Division:
Automotive
Category:
Technical
SUBJECT:
SAFETY RECALL CAMPAIGN "KE"; ECM SOFTWARE UPDATE
Note:
It is no longer required to replace the ECM. Updates will be completed by using a PC, the Suzuki Diagnostic System (SDS) Tool and applicable reprogramming software.
MODEL(S):
VERONA (RP625)
YEAR(S):
2004
CONDITION:
An Engine Control Module (ECM) program fault could cause the fuel to air ratio to become too lean in some circumstances, resulting in engine stalling.
CAUSE:
ECM software logic.
CORRECTION:
Reprogram Engine Control Module (ECM)
NOTE:
When the KE Recall is completed, check the vehicle to see if the vehicle is included in the KC Recall and whether the KC Recall has already been completed. If the KC Recall has not been completed be sure to affix both the KE and KC completion stickers to the radiator support as shown below. For California vehicles be sure to provide the customer with a Proof of Correction certification as explained in the KC Emission Recall Bulletin No. SC-24.
AFFECTED VIN RANGE
PART(S) INFORMATION:
1. Open the hood and check for the KE sticker on the radiator core support. If present do not perform the repair, it has already been done. If not present, continue to the next step.
CAUTION:
The reprograming procedure should only be performed by a qualified Technician. If done improperly permanent ECM damage may result.
2. In order to complete the Campaign you need a PC and the following items pictured to the right: Operator's manual (1), the Software CD (2), the diagnostic System Cable (3), the USB Cable (4) and the SDS Interface Box (5). Extra SDS Tool's and Software CD's are available on the website.
3. The software includes a detailed operator's manual which fully explains PC minimum requirements, software installation, USB driver installation, the vehicle reprogramming procedure and trouble shooting charts. Please follow the instructions carefully and completely.
4. After successfully completing reprogram be sure to affix the "KE" sticker with the dealer number to the radiator core support as shown above. For vehicles that do not have the "KC" sticker please affix the included "KC" sticker along with the "KE" sticker. This update includes the "KC" Campaign fixes.
Disclaimer