Canada - Interior - Water Condensation Dripping From Headliner

Bulletin
TSB3076R

Issue Date
December 18 2008

Market
Canada

Title
WATER CONDENSATION DRIPPING FROM HEADLINER

Component
BODY

Models
'05-'10 Tacoma

TSB REVISION NOTICE:
- August 4, 2010: The applicable vehicle content has been updated.
Any previous printed versions of this service bulletin should be discarded.

INTRODUCTION:

Some customers may complain about water dripping from the dome lamp area in the headliner. Use the following repair procedure to correct this condition.






APPLICABILITY:






PARTS INFORMATION:






WARRANTY INFORMATION:






REQUIRED SSTS:

NOTE
Additional SSTs may be ordered by calling SPX/OTC at 1-800-933-8335.

REPAIR PROCEDURE:

1. Remove headliner.

For headliner removal and installation instructions, refer to the Repair Manual within E-TAS / TIS library:
- Model: Tacoma
- Year: 2005
- Service Category: Vehicle Interior
- Section: Interior Panels/Trim
- Keyword: Roof Headlining Assy (Double Cab): Components/Replacement

- Model: Tacoma
- Year: 2006/ 2007/ 2008/ 2009/ 2010
- Service Category: Vehicle Interior
- Section: Interior Panels/Trim
- Keyword: Interior: Roof Headlining (for Double Cab): Components / Removal

2. Add NEW pad material to the area as shown below in the illustration.

















3. Install the headliner in the reverse order as removal.

NOTE:
Issue of this Technical Service Bulletin is to ensure that proper repair information is available. IT DOES NOT CONSTITUTE AN AUTHORIZATION FOR REPAIR. Normal provisions of the formal warranty policy, as applicable, will apply.