Engine Controls/Fuel System - MIL ON/DTCs P2111/P2112

T-SB-0092-11

August 9, 2011

MIL "ON" DTC P2111/P2112

Service Category
Engine/Hybrid System

Section
Engine Control

Market
USA





Applicability

Introduction

Some 2010 - 2011 model year 4Runner and FJ Cruiser vehicles equipped with the 1GR-FE (4.0L) engine may exhibit an intermittent MIL "ON" condition with Diagnostic Trouble Codes (DTCs) P2111 and/or P2112 (Throttle Actuator Control System) stored in the Engine Control Module or ECM (SAE Term: Powertrain Control Module/PCM). Use the following repair procedure to address this condition.

Production Change Information





This TSB applies to vehicles produced BEFORE the Production Change Effective VINs shown.





Parts Information





Warranty Information





Required Tools & Equipment

Repair Procedure

1. Using TIS Techstream retrieve any stored DTCs.

2. If DTC P2111 or P2112 are present replace the throttle body assembly.

Refer to the Technical Information System (TIS) applicable model and model year Repair Manual:

^ 2010 4Runner:
Engine/Hybrid System - Engine Control - "1GR-FE Engine Control: Throttle Body: Removal / Installation"

^ 2011 4Runner:
Engine/Hybrid System - Engine Control - "1GR-FE Engine Control: Throttle Body: Removal / Installation"

^ 2010 FJ Cruiser:
Engine/Hybrid System - Engine Control - "1GR-FE Engine Control System: Throttle Body: Removal / Installation"

^ 2011 FJ Cruiser:
Engine/Hybrid System - Engine Control - "1GR-FE Engine Control System: Throttle: Removal / Installation"

3. After the repair is complete clear any DTCs and confirm normal system operation and that there are NO pending DTCs.