Canada - Body - Front/Rear Sliding Roof Is Inoperative

Bulletin
T-TCI-3677

Issue Date
December 12, 2011

Market
Canada

Title
SLIDING ROOF INOPERATIVE

Service Category
Vehicle Exterior

Section
Sliding Roof/Convertible

Market
Canada






APPLICABILITY:

INTRODUCTION:

Some 2011 Sienna vehicles may exhibit a condition where the front or rear sliding roof becomes inoperative or jammed while trying to open/close. The sliding roof assembly has been improved to correct this condition.

PRODUCTION CHANGE INFORMATION:







This TSB applies to vehicles produced BEFORE the Production Change Effective VIN shown.






WARRANTY INFORMATION:






PARTS INFORMATION:

NOTE
Old side garnishes can NOT be used on the new front sliding roof subassembly. It is necessary to replace side garnishes with parts listed above when replacing front sliding roof housing.

REPAIR PROCEDURE:

1. Confirm front or rear sliding roof is inoperative. Replace the affected sliding roof assemblies by referring to the Technical Information System (TIS), applicable model and model year Repair Manual:

Front Sliding Roof
2011 Sienna:
Vehicle Exterior - Sliding Roof/Convertible - "Sliding Roof Housing: Removal / Disassembly / Reassembly / Installation"

Rear Sliding Roof
2011 Sienna:
Vehicle Exterior - Sliding Roof/Convertible - "Rear Slide Roof Housing: Removal / Disassembly / Reassembly / Installation"

2. Confirm proper operation has been restored.

NOTE:
Issue of this Technical Service Bulletin is to ensure that proper repair information is available. IT DOES NOT CONSTITUTE AN AUTHORIZATION FOR REPAIR. Normal provisions of the formal warranty policy, as applicable, will apply.