Repair and Diagnosis: Technical Service Bulletins
- How to Find Technical Service Bulletins by Category/Symptom
- Recalls
- Customer Interest
- Seals, Gaskets
- Superceded Bulletins
- All Technical Service Bulletins
- A/C - Unpleasant Odors Coming From Vents
- 178401 - 02/01/84
- Platform Wiring Harness - Repairing
- Vehicle - Ordering VIN Plates/Safety And Emission Labels
- Electrical Contact Enhancer - Enhances Conductivity
- Electrical - Aftermarket Equipment Installation
- Warranty - Plastic Bags for Electronic Parts Tag
- Fluids and Lubricants - Warranty Reimbursements
- Vehicle - Manufacturing Date Codes of Bosch Components
- Warranty - Replacement Price Estimate Guidelines
- Warranty - Loaner Car Charges, Paint/Corrosion Repairs
- Tools - Special Tool Minimum Requirements
- Tools - Digital Multimeter (Fluke 83) Introduction
- Vehicle - Archive Microfiche Available
- Engine Control Harness Connector Terminals - Replacing
- Towing - Information for Long Distance and Emergency
- Vehicle - Lubricant Capacities and Type
- Speedometer (Odometer) - Replacement Regulations
- A/C - Corrections to Aftermarket Kit Installation
- A/C - Unpleasant Musty Odor
- A/C Refrigerant - Compliance With Enviromental Laws
- Engines And Short Blocks - Label Information
- Tools - Engine/Transmission Oil Temperature Tester
- Engine - Oil Consumption
- Tools - Support to Remove/Install Engine, Transmission
- Tools - Coolant System Pressure Gauge
- Power Steering Fluid - New Type Approved For Use
- Fuel System - Poor Engine Performance
- Disc Brakes - Noisy
- Carburetor, Carter TYF - Changes
- Cylinder Head - Repair Information
- Fuel Injection - System Cleaning And Decarbonization
- Evaporator Core, Aluminum - Locations Where Installed
- Manual Steering Gear - Centering/Tie Rod Installation
- Engine - Flywheel, Drive or Pressure Plate Bolts
- Engine - Attach Pressure Plate or Flywheel to Crankshaft
- Camshaft - Checking Radial Clearance
- Engine - Metallic Clicking Noise
- Engine, Factory Rebuilt - Oil Filter Leaks
- Water Pump - Testing Procedure
- Coolant Pump - Leakage, Warning Lamp On, Residue
- Radiator Fan - Stays On High Speed When Extremely Cold
- Alternator - V Belt Slips Under Load
- Engine Oil Cooler - Leaks into the Cooling System
- Oil Cooler - Change in Location
- Wheels/Tires - Eliminating Vibrations
- Brake Calipers - Modification
- Rear Tires- Abnormal Wear
- Tires- Rotation Tips
- Tires - Goodyear Tire And Rubber Toll Free Line
- Wheel Bolt - Standardized Tightening Torque
- Aluminum Bumpers - Painting Procedure
- Keys - Lost or Broken
- Locks - Re-Keying to Maintain One-Key Operation
- Sidewinder Key and Locks - Ordering and Warranty Claim
- Seat Cover Beading - Separated From Plastic Piping
- Tires - Aerosol Inflator/Sealer Flammability Hazard
- Vent Window - Sticks to Weatherstrip
- Power Steering System - Knocking Noise
- Steering Wheels - Modification, Removal and Installation
- CV Joint - Revised Diagnosis, Inspection and Replacement
- M/T - When Replacing, Match Flanges to Driveshafts
- M/T - Grinds Into 1st/Reverse/Hard Shifting
- A/T Final Drive - Spring-Loaded Axle Shaft Flange Repair
- Clutch Pedal - Noise or Vibration
- Tools - VAG 1598 Test Box Description, Application List
- ECM - Inoperative Due to Improper Battery Charging
- Engine - Poor Driveability
- Oxygen Sensor - Failure Due to Silicone
- Engine Performance - Lack of Acceleration
- Brakes, Rear - Squeaking During Application
- Wheel Brake Cylinder, Rear - Replacement Criteria
- Battery - Charge Indicator Eye Shows No Charge Condition
- Low Maintenance Batteries - Updated Testing
- Charging - Battery Discharged, Indicator Light Flickers
- Engine - Does Not Crank or Battery Repeatedly Discharged
- Alternator Harness and Cable - Revised Routing
- Engine - Deflection Measurement for V-Belt Tension
- Tools - Removing and Installing Generator V-Belt Pulley
- Engine - Stops Running
- Distributors (W/HALL Connection) - Revised Part Numbers
- Tools - Carburetor T-Wrench
- Recall 85V015000: Throttle Shaft Breakage
- Cold Start Vacuum Lock Valve - Replacing Connector
- Idle Speed Boost System - Wiring Diagrams
- Idle Speed Control System - Operation and Testing
- Exhaust - Sulfur Odor Noticed At the Pipe
- Interior Light - Inoperative
- Door Contact Switch - Sticking
- Radio - Static When Listening to AM Stations
- Tools - Unlock Radio From Instrument Panel
- Warranty - Locked-Up Radio Repair Program
- Radio - Diagnosis Instructions
- Vanity Mirror Bulb - Replacement
- M/T - Difficult to Shift Into Gear
- M/T - Input Shaft Adjustment
- Starter - Does Not Engage/Restart When Engine is Hot
- Tools - Fuel Gauge Sending Unit
- Oil Pressure Buzzer - Sounds After Switching Ignition On
- Coolant Temperature Gauge Light - Flashes
- Voltage Stabilizer - Adding Diode To Circuit
- Speedometer - Calibration Specifications
- Speedometer - Replacement Procedure, Regulations
- Speedometer - Replacement Guidelines
- Tools - Headlights, Aiming, Hella Beamsetter Series IV
- Upshift/Back-Up Light Switch - Connector Change
- Cylinder Head Bolts - Tightening Procedures
- Clutch - Adjustments
- Exterior Plastic Trim Parts - Discolored
- Body Trim - Painting Plastic Parts
- Exhaust Swivel Joint - Squeaks While Driving
- Engine - Hesitation During Warm-Up Period When Cold
- Engine - Idle Fluctuations or Hunting
- Rear Hatch - Rattles
- A/T - Final Drive Housing Cover Bolt Torque
- Tools - New Tool for Aligning Door Hinges
- Rear Hatch - Hinge Gasket Material, Corrosion Protection
- Door Trim Panel - Attaching Screws Eliminated
- Door Paint - Chipping
- Windshield - Cracks
- Windshield - Squeaking Noise from the Outside Area
- Wiper Blade - Smearing Windshield
- Tools - Windshield Wiper Alignment
- Glass Guide - Installation of Revised Felt Pad
- Wiper Blade - Chatter and Skipping
- Wiper Blades - Jerk or Skip Across Windshield
- Tools - New Fuel Injector Insert/Washer Jet Aiming
- Mirror, Outside Remote - Glass Vibration
- Engine Oil - Capacity Reduced
- Engine - Approved Oil And Additives
- Coolant - Revision
- Tools - Universal Transmission Support 3282
- A/T - Shift Points, Stall Speed, Pressure Specifications
- A/T - Technical Data
- Tools - New High Lift Transmission Jack
- Warranty - Contact Tech Help Line During A/T Repair
- A/T - Diagnosis and Repair Using Test Kit and Worksheet
- A/T - Synthetic Oil for Final Drive
- A/T - Valve Body Modifications
- A/T - Engine Vacuum Testing
- A/T - How To Use A Pressure Gauge
- A/T - ATF Leaking From Differential Pinion Seal Vent
- A/T - 010/087/089/090 Bind In Low and Reverse
- A/T - ATF Entering The Differential
- A/T - Drive Axle and Wheel Lug Nut Torque Specifications
- A/T - Slipping or No-Shift/Metal Sealing Rings
- A/T - 010, 003 Bind In Reverse/2nd Gear Starts
- A/T - Front Bushing Wear
- A/T - Math Formulas Part I
- A/T - Twenty Steps To Successful Repairs
- A/T - Math Part II
- A/T - Choosing the Right ATF
- M/T - Secure Magnet In Clutch Housing
- M/T - Upshift Light Switch and Spring-Loaded Final Drive
- Engine - Locating Mark to Adjust Ignition Timing
- Flywheel Mounting Bolt - Torque
- Drive Plate - No Longer Available
- Drive Plate - Revised Installation Procedure
- M/T - Difficult to Shift
- Coolant Indicator LED - Flashing At Normal Temp
- Crankshaft Drive Sprocket Bolt - Changed
- Engine - Misfire
- Engine - Rough Idle or Misfiring During Partial Load
- MIL ON - Poor Idle/Stalls, Loss of Power, Exhaust Smoke
- Engine Performance - Tuneup Specifications
- Fuel - Improved Additive
- Fuel - Use of Gasolines Containing Detergent Recommended
- Cruise Control - Does Not Work
- Alignment - Conversion Chart for Specifications
- Tires/Suspension - Vehicle Pulls to one side
- Wheels/Tires - Vibrations
- Convertible Top - Eliminating Leaks
- Window, Rear - Installing New Support Brackets
- Convertible Top - Wind Noise
- Seat Belt - Adapter Kit to Adjust the Mounting Point
- Interior Trim - Dirty/Soiled
- Radio - Causes Excessive Battery Drain
- Paint Finishes - Restoration
- Brake Fluid - Super DOT 4 Available
- A/T - Modifications for Units With Code Letters TF, TH
- Hall Sensor Ignition Kit - Revised
- Instrument Panel - Milky/Spotted
- A/C Refrigerant - Capacity Reference Chart
- Final Drive - Leaking Oil
- Final Drive Flange Seal - Leaking Under Car