Repair and Diagnosis: Technical Service Bulletins
- How to Find Technical Service Bulletins by Category/Symptom
- Recalls
- Customer Interest
- Superceded Bulletins
- All Technical Service Bulletins
- A/C - Unpleasant Odors Coming From Vents
- Electrical - Diagnosis for Excessive Static Current Draw
- Warranty - Defect in Materials or Workmanship Policy
- Platform Wiring Harness - Repairing
- Vehicle - Ordering VIN Plates/Safety And Emission Labels
- Electrical Contact Enhancer - Enhances Conductivity
- Electrical - Aftermarket Equipment Installation
- Warranty - Plastic Bags for Electronic Parts Tag
- Fluids and Lubricants - Warranty Reimbursements
- Tools - Preventing Damage to VAG 1551 Diagnostic Tester
- Warranty - Updated Policies and Procedures Manual
- Warranty - Coverage for Fire and Accident Cases
- Warranty - Replacement Price Estimate Guidelines
- Warranty - Loaner Car Charges, Paint/Corrosion Repairs
- Tools - Special Tool Minimum Requirements
- Tools - Digital Multimeter (Fluke 83) Introduction
- Engine Control Harness Connector Terminals - Replacing
- Electrical - Repairs on Connectors With Rubber Grommets
- Repair Group Numbers - Renamed in Service Manual
- Vehicle - Lubricant Capacities and Type
- Speedometer (Odometer) - Replacement Regulations
- A/C System - Retrofitting R-12 to R-134a
- A/C - Unpleasant Musty Odor
- A/C Refrigerant - Compliance With Enviromental Laws
- Tools - Engine/Transmission Oil Temperature Tester
- Engine - Warranty Repair Claims No Longer Covered
- Engine - Oil Consumption
- Engine - Idle Speed Hunts When Cold
- Power Steering Fluid - Change From ATF to Hydraulic Oil
- Fuel System - Poor Engine Performance
- Tools - Adapter for Brake Pressure Regulator Adjustment
- A/C Compressor Belt - Adjusting
- A/C - Vinyl Becoming Loose Around Defroster Vents
- A/C Compressor Clutch - Removal and Installation
- Engine - Attach Pressure Plate or Flywheel to Crankshaft
- Coolant Pump - Leakage, Warning Lamp On, Residue
- Radiator Fan - Stays On High Speed When Extremely Cold
- Alternator - V Belt Slips Under Load
- Warranty - Replacement Mufflers Warranty
- Wheels/Tires - Eliminating Vibrations
- Alloy Wheels - Cleaning
- Tires- Rotation Tips
- Winter Tires/Snow Chains - Recommendations
- Tires - Goodyear Tire And Rubber Toll Free Line
- Locks - Re-Keying to Maintain One-Key Operation
- Sidewinder Key and Locks - Ordering and Warranty Claim
- Seat Cover Beading - Separated From Plastic Piping
- Rear Child Restraint - Anchorage Installation
- Tires - Aerosol Inflator/Sealer Flammability Hazard
- CV Joint - Revised Diagnosis, Inspection and Replacement
- M/T - When Replacing, Match Flanges to Driveshafts
- M/T - Difficulty Shifting In and Out of Gear
- A/T - Shifts Erratically
- M/T - Strainer Added to Prevent Ring and Pinion Damage
- Engine - Ticking Noises at 1800 to 3200 RPM
- Warranty - Component Repair vs. Replacement Policy
- Engine - Rich Running Condition
- OBD - Basic Setting After Disconnecting Battery
- Tools - VAG 1598 Test Box Description, Application List
- ECM - Inoperative Due to Improper Battery Charging
- Engine - Poor Driveability
- Oxygen Sensor - Failure Due to Silicone
- Engine - Lack of Power, Stalls, Bucking, and Jerking
- Wheel Brake Cylinder, Rear - Replacement Criteria
- Tools - Do Not Use Computer Memory Saver On Airbag Cars
- Alternator Shaft - Design Changed
- Tools - Removing and Installing Generator V-Belt Pulley
- Knock Sensor - Avoiding Unnecessary Replacement
- Recall 92V058000: Leakage at Fuel Rail
- Recall - Fuel Tank Crack Causing Leakage
- Recall 91V201000: Fuel Tank Cracking
- Recall 91V162000: Accelerator Linkage Interference
- Exhaust - Sulfur Odor Noticed At the Pipe
- Radio - Heidelberg VI Fixed Coded
- Warranty - Locked-Up Radio Repair Program
- Warranty - Radio Handling Allowance Increased
- Warranty - Unlocking Non-Fixed Code Radios Locked-Up
- Radio - Diagnosis Instructions
- Airbag - Testing Fault Codes Using VAG 1551
- Vanity Mirror Bulb - Replacement
- M/T - Difficult to Shift Into Gear
- Starter - Does Not Engage/Restart When Engine is Hot
- Tools - Fuel Gauge Sending Unit
- Speedometer - Replacement Procedure, Regulations
- Speedometer - Replacement Guidelines
- Tools - Headlights, Aiming, Hella Beamsetter Series IV
- A/C Compressor Shaft Seal - Replacement
- Clutch - Adjustments
- Exterior Plastic Trim Parts - Discolored
- Engine Compartment - Protective Coating
- Airbag System - Safety Precautions When Handling
- Passive Restraint Systems - Investigation of Accidents
- Airbag System - Diagnosis
- Airbag System - Overview
- Airbag - Wiring Diagrams
- Airbag OBD System - Checking With VAG 1551 Tool
- VAG 1551 Scan Tool Printout - Attach to R/O for Warranty
- Windshield - Replacement Instructions
- Wiper Blade - Smearing Windshield
- Tools - Windshield Wiper Alignment
- Wiper Blade - Chatter and Skipping
- Wiper Blades - Jerk or Skip Across Windshield
- Engine - Approved Oil And Additives
- Coolant - Revision
- Tools - Universal Transmission Support 3282
- Tools - New High Lift Transmission Jack
- Warranty - Contact Tech Help Line During A/T Repair
- A/T - Diagnosis and Repair Using Test Kit and Worksheet
- A/T - Synthetic Oil for Final Drive
- Warranty - Transmission Manufacture Date, Code Letters
- A/T - Engine Vacuum Testing
- A/T - How To Use A Pressure Gauge
- A/T - ATF Leaking From Differential Pinion Seal Vent
- A/T - 010/087/089/090 Bind In Low and Reverse
- A/T - Intermittent Electrical Problems
- A/T - Failsafe Modes
- A/T - ATF Entering The Differential
- A/T - Drive Axle and Wheel Lug Nut Torque Specifications
- A/T - Slipping or No-Shift/Metal Sealing Rings
- A/T - Front Bushing Wear
- A/T - Math Formulas Part I
- A/T - Twenty Steps To Successful Repairs
- A/T - Math Part II
- A/T - Choosing the Right ATF
- M/T - Secure Magnet In Clutch Housing
- Flywheel Mounting Bolt - Torque
- Drive Plate - No Longer Available
- Drive Plate - Revised Installation Procedure
- CD Changer - Skipping Over Rough Roads
- Coolant Indicator LED - Flashing At Normal Temp
- Crankshaft Drive Sprocket Bolt - Changed
- Engine - Misfire
- MIL ON - Poor Idle/Stalls, Loss of Power, Exhaust Smoke
- Shift Lock - Wiring Diagram
- Fuel - Improved Additive
- Fuel - Use of Gasolines Containing Detergent Recommended
- Alignment - Conversion Chart for Specifications
- Tires/Suspension - Vehicle Pulls to one side
- Wheels/Tires - Vibrations
- Convertible Top - Stains Due to Storage or Use
- Interior Trim - Dirty/Soiled
- Radio - Causes Excessive Battery Drain
- Audio System - Radio Security Code Retrieval
- Paint Finishes - Restoration
- Brake Fluid - Super DOT 4 Available
- M/T Case - Sealing Precautions
- Tools - Refrigerant Recovery and Recycling System
- Recall 91V215000: Air Bag Harness Damage
- Seat Cover - Cleaning
- Final Drive - Leaking Oil
- Engine - Component Inspection During Engine Replacement
- Exhaust System - Heat Shield Replacement Guidelines