Repair and Diagnosis: Technical Service Bulletins
- How to Find Technical Service Bulletins by Category/Symptom
- Recalls
- Customer Interest
- A/C - Unpleasant Odors Coming From Vents
- A/C - Unpleasant Musty Odor
- Engine - Idle Speed Hunts When Cold
- Fuel System - Poor Engine Performance
- Front Brakes - Rattling Noise
- Front Wheel Bearing - Clunking Noise
- Power Steering Gear - Fluid Leaks From Pinion Seal
- Coolant Pump - Leakage, Warning Lamp On, Residue
- Radiator Fan - Stays On High Speed When Extremely Cold
- Alternator - V Belt Slips Under Load
- Rear Tires - Abnormal Wear
- Window Regulator Motor - Inoperative
- Seat Cover Beading - Separated From Plastic Piping
- M/T - Difficulty Shifting In and Out of Gear
- M/T - Strainer Added to Prevent Ring and Pinion Damage
- ECM - Inoperative Due to Improper Battery Charging
- CIS E Motronic ECU - Update
- Engine - Poor Driveability
- Engine - Lack of Power, Stalls, Bucking, and Jerking
- Engine - Alternator Light On, V Belt Squeals When Wet
- Engine - No Start, Hard Start, or Poor Running
- Radio - Warning Chimes Remain On After Installation
- M/T - Difficult to Shift Into Gear
- Starter Motor - Noisy When Cranking Engine
- Starter - Does Not Engage/Restart When Engine is Hot
- Coolant Gauge - Becomes Inoperative
- Exterior Plastic Trim Parts - Discolored
- Wiper Blades - Jerk or Skip Across Windshield
- CD Changer - Skipping Over Rough Roads
- Coolant Indicator LED - Flashing At Normal Temp
- MIL ON - Poor Idle/Stalls, Loss of Power, Exhaust Smoke
- Fuel - Improved Additive
- Tires/Suspension - Vehicle Pulls to one side
- Wheels/Tires - Vibrations
- Front Seat - Insufficient Travel
- Interior Trim - Dirty/Soiled
- Radio - Causes Excessive Battery Drain
- Right Front Seat - Insufficient Travel
- A/C Drain Hose - Leaks Water Condesation Onto Carpet
- Final Drive - Leaking Oil
- Superceded Bulletins
- All Technical Service Bulletins
- A/C - Unpleasant Odors Coming From Vents
- Electrical - Diagnosis for Excessive Static Current Draw
- 259302 - 08/31/93
- Platform Wiring Harness - Repairing
- Vehicle - Fluids Capacity Chart
- Vehicle - Ordering VIN Plates/Safety And Emission Labels
- Electrical Contact Enhancer - Stabilant 22A
- Electrical - Aftermarket Equipment Installation
- Warranty - Plastic Bags for Electronic Parts Tag
- Fluids and Lubricants - Warranty Reimbursements
- Tools - Preventing Damage to VAG 1551 Diagnostic Tester
- Campaign - Missing Tool Kit Parts
- Warranty - Updated Policies and Procedures Manual
- Warranty Claim Adjusters Assignments
- Warranty - New Policies and Procedures Manual
- Warranty - New Information Network User's Guide
- Warranty - New Policies And Procedures Manual
- Warranty - Customer Satisfaction Telephone Follow-Up
- Warranty - Fluids And Lubricants Claims
- Warranty - Demonstrator Vehicle Extended
- Warranty - Limited For New and Remanufactured Parts
- Warranty - Vehicle Coverage Announcement
- Warranty - Replacement Price Estimate Guidelines
- Warranty - Loaner Car Charges, Paint/Corrosion Repairs
- Recall - Revised Vehicle System Work Procedures
- Engine Control Harness Connector Terminals - Replacing
- Electrical - Repairs on Connectors With Rubber Grommets
- Repair Group Numbers - Renamed in Service Manual
- Vehicle - Lubricant Capacities and Type
- Speedometer (Odometer) - Replacement Regulations
- A/C System - Retrofitting R-12 to R-134a
- A/C - Unpleasant Musty Odor
- A/C Refrigerant - Compliance With Enviromental Laws
- Revised Engine Repair Claim Instructions
- Engine - Oil Consumption
- Engine - Idle Speed Hunts When Cold
- Fuel System - Poor Engine Performance
- Front Brakes - Rattling Noise
- Tools - Adapter for Brake Pressure Regulator Adjustment
- A/C Compressor Clutch - Removal and Installation
- Recall - Heater Core Replacement
- Warranty - Limited Lifetime Mufflers, Struts and Shocks
- Front Wheel Bearing - Clunking Noise
- Tie Rod, Left - Checking and Adjusting Length
- Power Steering Gear - Fluid Leaks From Pinion Seal
- Engine - Attach Pressure Plate or Flywheel to Crankshaft
- Timing Belt - Revised Maintenance/Adjustment Procedure
- Timing Belt - Revised Adjustment/Replacement Intervals
- Coolant Pump - Leakage, Warning Lamp On, Residue
- Radiator Fan - Stays On High Speed When Extremely Cold
- Alternator - V Belt Slips Under Load
- Receiver Drier - Replacing
- Wheels/Tires - Eliminating Vibrations
- Alloy Wheels - Cleaning
- Tires- Rotation Tips
- Winter Tires/Snow Chains - Recommendations
- Tires - Winter and Non-Winter Application Chart
- Tires - Recommended Sizes/Inflation Pressures
- Rear Tires - Abnormal Wear
- Tires - Goodyear Tire And Rubber Toll Free Line
- Sidewinder Key and Locks - Ordering and Warranty Claim
- Window Regulator Motor - Inoperative
- Seat Cover Beading - Separated From Plastic Piping
- Tires - Aerosol Inflator/Sealer Flammability Hazard
- CV Joint - Revised Diagnosis, Inspection and Replacement
- M/T - When Replacing, Match Flanges to Driveshafts
- M/T - Difficulty Shifting In and Out of Gear
- Pressure Plate Mounting Bolts - Torque Change
- M/T - Strainer Added to Prevent Ring and Pinion Damage
- A/T Shift Handle - Replacement Part/Installation
- OBD - Basic Setting After Disconnecting Battery
- CIS E Motronic Control Unit - New
- ECM - Inoperative Due to Improper Battery Charging
- CIS E Motronic ECU - Update
- Engine - Poor Driveability
- Oxygen Sensor - Failure Due to Silicone
- Engine - Lack of Power, Stalls, Bucking, and Jerking
- Volume Air Flow (VAF) Sensor - Revised
- Wheel Brake Cylinder, Rear - Replacement Criteria
- Engine - Alternator Light On, V Belt Squeals When Wet
- Alternator Shaft - Design Changed
- Tools - Removing and Installing Generator V-Belt Pulley
- Knock Sensor - Avoiding Unnecessary Replacement
- Campaign - Knock Sensor Replacement
- Engine - No Start, Hard Start, or Poor Running
- Recall 92V131000: Loose Venturi Tube
- Exhaust - Sulfur Odor Noticed At the Pipe
- Radio - Warning Chimes Remain On After Installation
- Warranty - Unlocking Non-Fixed Code Radios Locked-Up
- Radio - Diagnosis Instructions
- Airbag System - Stabilant 22A on Terminals
- Vanity Mirror Bulb - Replacement
- M/T - Difficult to Shift Into Gear
- Engine - Troubleshooting Driveability Complaints
- Starter Motor - Noisy When Cranking Engine
- Starter - Does Not Engage/Restart When Engine is Hot
- Tools - Fuel Gauge Sending Unit
- Coolant Gauge - Becomes Inoperative
- Speedometer - Replacement Procedure, Regulations
- Speedometer - Replacement Guidelines
- Tools - Headlights, Aiming, Hella Beamsetter Series IV
- A/C Compressor Shaft Seal - Replacement
- Paint - Deletion of Surface Clear Coat
- Exterior Plastic Trim Parts - Discolored
- Engine Compartment - Protective Coating
- Warranty - New California Emission Part Tag
- Engine Controls - Accessing DTC's Using Jumper Wire
- VAG 1551 Scan Tool Printout - Attach to R/O for Warranty
- Tools - New Program Card For Fault Readout Unit
- Sunroof Cable - Available Rear/Front Guide Replacements
- Wiper Blades - Jerk or Skip Across Windshield
- Bumper Covers - Installation
- Engine Oil - Consumption Determination
- Engine - Approved Oil And Additives
- Coolant - Revision
- Tools - Brake Line Kit
- Tools - Universal Transmission Support 3282
- Warranty - Contact Tech Help Line During A/T Repair
- A/T - Diagnosis and Repair Using Test Kit and Worksheet
- A/T - Synthetic Oil for Final Drive
- Warranty - Transmission Manufacture Date, Code Letters
- A/T - Engine Vacuum Testing
- A/T - How To Use A Pressure Gauge
- A/T - ATF Leaking From Differential Pinion Seal Vent
- A/T - 010/087/089/090 Bind In Low and Reverse
- A/T - Intermittent Electrical Problems
- A/T - Failsafe Modes
- A/T - ATF Entering The Differential
- A/T - Drive Axle and Wheel Lug Nut Torque Specifications
- A/T - Slipping or No-Shift/Metal Sealing Rings
- A/T - Front Bushing Wear
- A/T - Math Formulas Part I
- A/T - Twenty Steps To Successful Repairs
- A/T - Math Part II
- A/T - Choosing the Right ATF
- M/T - Secure Magnet In Clutch Housing
- M/T - Gearshift Lever Revision and Adjustment
- Flywheel Mounting Bolt - Torque
- Drive Plate - No Longer Available
- Drive Plate - Revised Installation Procedure
- CD Changer - Skipping Over Rough Roads
- Coolant Indicator LED - Flashing At Normal Temp
- Crankshaft Drive Belt Sprocket Bolt - Torque Change
- MIL ON - Poor Idle/Stalls, Loss of Power, Exhaust Smoke
- Engine - Ignition Timing, CO and Idle Speed Setting
- Fuel - Improved Additive
- Alignment - Conversion Chart for Specifications
- Tires/Suspension - Vehicle Pulls to one side
- Wheels/Tires - Vibrations
- Front Seat - Insufficient Travel
- Interior Trim - Dirty/Soiled
- Windows - Adhesive Material Revised
- Radio - Causes Excessive Battery Drain
- Audio System - Radio Security Code Retrieval
- Paint Finishes - Restoration
- Paint - Water Borne Unicolor Paints
- Paint - Clear Coat Repairs
- Brake Fluid - Super DOT 4 Available
- On Board Diagnostic Troubleshooting Guide - Corrections
- M/T Case - Sealing Precautions
- Right Front Seat - Insufficient Travel
- A/C Drain Hose - Leaks Water Condesation Onto Carpet
- Child Safety Seat - Installation
- Final Drive - Leaking Oil
- Airbag - Deployed Airbag Repair
- Engine - Component Inspection During Engine Replacement
- Exhaust System - Heat Shield Replacement Guidelines