Repair and Diagnosis: Technical Service Bulletins
- How to Find Technical Service Bulletins by Category/Symptom
- Recalls
- Customer Interest
- Labor/Parts Updates
- Tools, Equipment
- Superceded Bulletins
- All Technical Service Bulletins
- Cooling System - Coolant ID/Mixing/Improved Coolant
- A/C - Unpleasant Odors Coming From Vents
- Electrical - Diagnosis for Excessive Static Current Draw
- Vehicle - Revised Component Nomenclature
- Platform Wiring Harness - Repairing
- Vehicle - Fluids Capacity Chart
- Towing Eye Cover - Removing and Installing
- Vehicle - Ordering VIN Plates/Safety And Emission Labels
- Vehicle - Suggested Repair Times Microfiche
- Electrical Contact Enhancer - Stabilant 22A
- Electrical Contact Enhancer - Improves Performance
- Electrical - Aftermarket Equipment Installation
- Warranty - 10 Year/100,000 Mile Powertrain Eligibility
- Warranty - Plastic Bags for Electronic Parts Tag
- Fluids and Lubricants - Warranty Reimbursements
- Tools - Preventing Damage to VAG 1551 Diagnostic Tester
- Warranty - Replacement Price Estimate Guidelines
- Warranty - Loaner Car Charges, Paint/Corrosion Repairs
- Warranty - Vehicle Coverage Information
- Maintenance - Schedules And PDI
- Engine Control Harness Connector Terminals - Replacing
- Brake Pressure Regulator - Checking/Adjusting
- Front Brakes - High Pitched Squealing Noise
- Brakes - Cracking Noise When Applied
- Speedometer (Odometer) - Replacement Regulations
- A/C System - Insufficient Cooling
- A/C - R134a System Components And Capacities
- A/C System - R-134 Replacement and System Capacities
- A/C - Poor Air Distribution to Floor Vents/Binding Knob
- A/C - Unpleasant Musty Odor
- Main Bearing Cap - Tightening Torque Specifications
- Engine - Oil Consumption
- Engine Bulkhead - Bulkhead Sealing During PDI
- Engine - Idle Speed Hunts When Cold
- ISC - DTC 00533 (2231) Noise Damper Clogged
- Fuel System - Poor Engine Performance
- Spark Plug - Correct Application
- Instrument Panel - Restricted Air Flow from Left Side
- Suspension Strut Bearing - Available Versions
- Suspension - Front End Knock Driving Over Rough Roads
- Suspension - Front End Knock When Driving on Rough Roads
- Front Wheel Bearing - Clunking Noise
- Drum Brakes - Wheel Bearing and Axle Servicing
- Engine - Attach Pressure Plate or Flywheel to Crankshaft
- Recall 95V178000: Cooling Fan Motor Seizure
- Alternator - V Belt Slips Under Load
- Exhaust System - Revised Mounting Information
- Engine - Induction System Oil Accumulation
- Alloy Wheels - Cleaning
- Winter Tires/Snow Chains - Recommendations
- Tires - Recommended Sizes/Inflation Pressures
- Rear Tires - Abnormal Wear
- Tires - Goodyear Tire And Rubber Toll Free Line
- Central Locking - Install Revised Vacuum Lines at PDI
- Central Locking - Troubleshooting Pneumatic Operation
- Exterior Door Locks - Cannot be Locked or Unlocked
- Sidewinder Key and Locks - Ordering and Warranty Claim
- Electric Window Regulator - Servicing
- Window Regulator Motor - Inoperative
- Recall 96V128000: Window Regulator Shorting
- Rear Child Restraint - Anchorage Installation
- Tires - Aerosol Inflator/Sealer Flammability Hazard
- Door Glass Seal - Wind Noise at A- Pillar
- Door Seals - Friction Noise Driving Over Rough Surfaces
- Sunroof - Wind Noise
- Tools - Sunroof Seal Adjustment
- Sunroof - Water Leaks
- Sunroof - Popping Noise When Opening in Sliding Mode
- Sunroof - Noise and Vibration
- Glass Sliding Sunroof - Repairing, New Available Parts
- Roof Trim Assembly/Headliner - Removal
- M/T - Strainer Added to Prevent Ring and Pinion Damage
- Clutch Pedal - Squeaking Noises
- Camshaft Position Sensor - Updated Checking
- OBD - Basic Setting After Disconnecting Battery
- ECM - Replacing
- ECM - Inoperative Due to Improper Battery Charging
- Battery - Charging Precautions
- ECM/TCM - Component Replacement Identifiers
- ECM/TCM - Component Replacement Identification
- Engine - Poor Driveability
- Heated Oxygen Sensor - Replacement/Checking
- Heated Oxygen Sensor - Troubleshooting
- Post Oxygen Sensor - New Part Identifier
- Engine - Pulsating or Clicking from RF of Vehicle
- Brake Caliper, Rear - Revised
- Wheel Brake Cylinder, Rear - Replacement Criteria
- Battery - Revised Load Testing Information
- Battery - Low State of Charge
- Generator And Mounting Bracket - New Information
- Alternator Shaft - Design Changed
- Power Output Stage - Replacement
- Knock Sensor - Troubleshooting DTC 00524 (2124)
- Data Link Connector - New 16-Pin, Accessing/Connecting
- Fuel Pressure Regulator - Checking
- Engine - Intermittent No Start, Various DTC's Set in TCM
- Exhaust - Sulfur Odor Noticed At the Pipe
- A/T - Valve Body Replacement
- Alarm System Modules - Unnecessary Replacement
- Warranty - Unlocking Non-Fixed Code Radios Locked-Up
- Stereo System (Deluxe And Premium) - General Information
- Radio - Diagnosis Instructions
- Airbag System - Stabilant 22A on Terminals
- Steering Wheel - Off Center to RIght or Left
- Air Bag ECM - Recoding Procedure
- Airbag Control Module - Removing and Installing
- Vanity Mirror Bulb - Replacement
- Engine - Misfire, Poor Performance
- Horn Pad - Removal
- Horn System - Information
- Speedometer - Replacement Procedure, Regulations
- Speedometer - Replacement Guidelines
- Headlight Assembly - New Information
- Tools - Headlights, Aiming, Hella Beamsetter Series IV
- Instrument Cluster - Intermittent Loss of Illumination
- Windshield Wipers - Inoperative
- Parking Brake Cables - Revised
- Suspension - Correcting Front End Knock
- Mirrors, Outside - Troubleshooting Wind Noise
- Paints - Water Borne/Clear Coated Unicolor
- Lock Carrier - Installing and Adjusting
- Paint - Deletion of Surface Clear Coat
- Engine Compartment - Protective Coating
- Tools - Airbag Diagnosis Scan Tool Print Out Changes
- Airbag Units - Replacing Following an Accident
- Airbag System - Inspection Service
- Airbag/Pyrotechnic Seat Belt - Inquiries
- Antitheft Alarm System - Troubleshooting
- VAG 1551 Scan Tool Printout - Attach to R/O for Warranty
- Recall 98V160000: Hood Latch Bolt Comes Loose
- Hood Lock Fastener - Torque Revision
- Hood - Unable to Open with Release Handle
- Hood Lock Cable - Removing and Installing
- Rear Lid - Difficult to Close
- Door Seals - Friction Type Noise
- Front Door - Adjusting
- Doors, New - Installing Upper Seat Belt Buckle Support
- Recall - Install Door Opening Pretective Edge
- Trunk Lock - Opening Deficiencies
- Trunk Lid - Contacts Tail Light Lenses
- Sunroof Cable - Available Rear/Front Guide Replacements
- Wiper Blades - Jerk or Skip Across Windshield
- Body Side Moldings - Availability
- Body Side Molding - Will Not Adhere After Replacement
- Glove Box - Unauthorized Retrofit Warning
- Engine - Approved Oil And Additives
- Coolant - Revision
- Power Steering Pressure Line - Vibration/Noise
- Tools - Brake Line Kit
- Recall 98V195000: Brake Line Chafing
- Recall - Check/Replace Right Rear Brake Line
- Brakes - Drag, Poor Mileage, or Pulling to One Side
- Warranty - Contact Tech Help Line During A/T Repair
- A/T - Technical Data
- A/T - Variations
- A/T - Troubleshooting
- A/T - Main Pressure, Checking
- A/T - Valve Body Conductor Strip Removing/Installing
- A/T - Diagnosis and Repair Using Test Kit and Worksheet
- Warranty - A/T Diagnosing and Repairing
- Warranty - Transmission Manufacture Date, Code Letters
- A/T - Engine Vacuum Testing
- A/T - How To Use A Pressure Gauge
- A/T - Failsafe Modes
- A/T - 096/097 General Information
- A/T - ATF Entering The Differential
- A/T - Drive Axle and Wheel Lug Nut Torque Specifications
- A/T - Slipping or No-Shift/Metal Sealing Rings
- A/T - Front Bushing Wear
- A/T - Math Formulas Part I
- A/T - Twenty Steps To Successful Repairs
- A/T - Math Part II
- A/T - Choosing the Right ATF
- M/T - Shifting Problems, Bulletin Cancellation Notice
- M/T - Shifter Lever Vibration/Knocking
- M/T - Shift Linkage Adjusting Procedure
- CD Changer - Skipping Over Rough Roads
- Service Reminder Indicator - New Information
- Recall 95E034000: Sticking Cruise Control Cable
- A/C Cut-Off Thermal Switch - Removing and Installing
- Campaign - Replace Ignition Coil Cable
- MIL ON - Poor Idle/Stalls, Loss of Power, Exhaust Smoke
- Cruise Control Vacuum Vent Valves - Remove/Install
- Instrument Cluster - Removing/Installing and Repair
- Lubrication System - Specification Change
- CD Changer - Noise During Operation
- Rear Ashtray Light - Installation
- Daytime Running Light Relay - Noisy
- Daytime Running Lights - Resistor Wire Installation
- Alignment - Conversion Chart for Specifications
- Wheel Alignment - Data
- Tires/Suspension - Vehicle Pulls to one side
- Wheels/Tires - Vibrations
- Clutch Pedal - Vibrations
- Recall 95V065000: Power Window Hazard
- A/T - Erratic Shifting, No DTCs Stored in TCM
- Interior Trim - Dirty/Soiled
- Windows - Adhesive Material Revised
- Central Locking Sytem - Troubleshooting
- Audio System - Troubleshooting
- Radio - Causes Excessive Battery Drain
- Audio System - Radio Security Code Retrieval
- Center High-Mounted Brake Light - Replacing
- A/T - Shiftlock III System Operation
- Sun Visor Inboard Clip - Cracked
- M/T Case - Sealing Precautions
- M/T - Discontinued Needle Bearing and Retaining Bolt
- Recall 95V054000: Defective Vehicle Jacks
- ATF Temperature Sensor - Resistance Measurements
- Body Emblems - Peeling/Discolored
- Campaign - Check/Replace Air Bag ECM
- Engine Controls - Throttle Position Sensor Replacement
- Brakes - Master Cylinder/ABS Pressure Testing Adapter
- Airbag - Deployed Airbag Repair
- Audio System - CD Player Jams/Magazine Won't Eject
- Restraints - Air Bag Coding
- Restraints - LATCH(R) System Installation/Retrofitting
- Interior - Cleaning Tips for Leather Upholstery
- Engine - Component Inspection During Engine Replacement
- Engine Controls - Silicone Sealer/Lubricant Precautions
- Interior - Cleaning Tips for Vinyls/Plastics/Fabrics
- Exhaust System - Heat Shield Replacement Guidelines
- Interior - Cleaning Tips Fabrics, Vinyls And Plastics
- Immobilizer System - Active/DTC's P0513/1177
- Cooling System - Coolant Identification/Mixing