Repair and Diagnosis: Technical Service Bulletins
- How to Find Technical Service Bulletins by Category/Symptom
- Recalls
- Emissions
- Generals
- Campaign - A/C Plenum Drain Modification
- Service Action Circular
- Saga Claim Entry Procedure
- Customer Letter
- Campaign Work Procedure
- Work Procedure
- Vehicle Preparation
- Section A - Remove Chamber Cover
- Section B - Remove Wiper Arm
- Section C - Remove Coral Panel
- Section D - Remove Battery and Battery Tray
- Section E - Clean Air Plenum Area And Remove Drain Tube
- Section F - Reinstall Battery Tray and Battery
- Section G - Seal Pollen Filter Housing
- Section H - Reinstall Cowl
- Section J- Reinstall Wiper Arm
- Section K - Modify Sunroof Drain (If Equipped)
- Section L - Reinstall Plenum Chamber Cover
- Section M - Work Steps Required After Connecting Battery
- Campaign - A/C Plenum Drain Modification
- Safety
- Recall 08V156000: Potential Vehicle Fires
- Recall - Potential Under Vehicle Fires
- Recall Circular
- Criteria Code Contents
- Saga Claim Entry Procedure
- Customer Letter Example USA
- Customer Letter Example Canada
- Campaign Work Procedure
- Work Sequence
- Section A - Heat Shield Installation
- Section B - Fuel Line Bracket Removal and Fuel Line Inspection
- Section C - Fuel Line Foam Block Removal and Bracket Clipping
- Section D - Fuel Line Replacement
- Section E - Fuel Tank Inspection
- Section F - Visual Inspection/Vent Line Check
- Section G - Fuel Tank Removal
- Section H - Fuel Sending Unit Removal
- Section J - Fuel Sending Unit Installation
- Section K - Software Update Using Software Version Management
- Customer Interest
- A/C - Unpleasant Odors Coming From Vents
- Wipers/Washers - Windshield Wipers Streak Or Smear
- Brakes - Vibration/Pulsation Upon Application
- Engine - Low Oil Pressure Condition/Warning Lamp ON
- Engine - Upper Engine Oil Leak Diagnostic Guidelines
- Engine Controls - MIL ON/DTC P1603 (18011) Stored
- Brakes/Steering/Suspension - DTC 00778 And 01044 Stored
- Ignition System - MIL ON/Misfire DTC's Set/Rough Running
- Premium VI Radio - Controls Do Not Respond
- Radio - Poor Sound Quality/Insufficient L/H Side Bass
- Air Bag MIL ON, DTC 00588 (Resistance Too Low) Set
- Body - Trunk Lid Hard to Open or Close
- Audio System - Poor Radio Reception
- Audio System - CD Player/Changer Display ERR Code 1
- Audio System - Poor Radio Sound Quality/Bass
- Air Bag - MIL ON DTC 00588 (Resistance Too High) Set
- Interior - Water Leaks into Footwell Area
- Engine Controls - DTC's 00545/00638 Stored
- Engine Controls - Idle Dip/Fluctuation/MIL ON/DTC's Set
- Interior - Steering Wheel Leather Wrap Coming Loose
- Computers/Controls - No Communication With Scan Tools
- Engine - DTC's P1297/P1557 Stored in Memory
- Audio System - CD Player Jams/Magazine Won't Eject
- Engine - Low Oil Pressure Lamp ON
- Engine Controls - DTC's P0604/P0605/P0606 in Memory
- Audio System - Poor AM/FM Band Radio Reception
- A/C - Fresh Air Lever Light Inoperative
- Engine - Oil Pressure is Too Low
- Body - Sunroof Malfunctions or is Inoperative
- Emissions - Possible MIL ON/Cat Converter DTC's Set
- Keyless Entry/Starting - Remote Key Inoperative
- Engine Controls - MIL ON/Multiple DTC's
- Electrical - One Or More Back Glass Defroster Grids Inop
- Ignition System - MIL ON/DTC's P0300-P0312 Stored
- Recommended Repairs
- Superceded Bulletins
- 0000-06 - 09/08/00
- 191002 - 03/17/10
- 2809-01 - 10/21/09
- 1709-03 - 03/20/09
- 0109-05 - 04/08/09
- 7008-01 - 01/01/08
- Vehicle - VIN Plate/Safety Certification Label Ordering
- 2004-01 - 01/29/04
- 4607-01 - 06/11/07
- 8006-02 - 03/03/06
- 6406-08 - 09/13/06
- 6906-01 - 01/20/06
- MAINTVMS01-02 - 08/03/01
- 4401-04 - 08/16/01
- 9102-02 - 03/27/02
- 0102-08 - 12/04/02
- A/C - Heated Rear Glass Has Lines That Are Inoperative
- A/C - Rear Heated Window, One or More Lines Inoperative
- Lighting - Headlamp Electrical Connection Repair
- Lighting - Exterior Light Moisture Accumulation
- Lighting - Condensation Inside Exterior Lights
- Body - Sunroof Malfunctions/Inoperative Diagnosis
- Paint - Swirl Mark/Fine Scratch Removal
- Paint - Fine Scratch/Swirl Mark Reduction
- Interior - Cleaning Tips for Fabrics/Vinyls/Plastics
- Body/Interior - Squeak and Rattle Kit Availability
- Armrest Lid - Latch release Mechanism Broken
- Body - Grille Appears Incorrect
- Audio System - Antitheft Code Entering/Retrieval
- Audio System - Radio Antitheft Code Information
- Audio System - Antitheft Security Code Retrieval
- Radio - Aftermarket Installation Warning
- Radio - Controls Do Not Respond
- Body/Controls - Sunroof/Central Control Module Diagnosis
- Antitheft - Retrieving Immobilizer Codes
- Antitheft - Immobilizer Code Retrieval
- Antitheft System - Retrieving Immobilizer Codes
- Antitheft System - Immobilizer Code Retrieval
- Keyless Entry - Remote Will Not Lock/Unlock Vehicle
- Keyless Entry - Remote Key is Inoperative
- Keyless Entry - Inconsistent Operation or Inoperative
- Keyless Entry - Transmitter Won't Lock/Unlock Vehicle
- Keyless Entry - Remote Key Feature Inoperative/Erratic
- Keyless Entry - Transmitters Inoperative
- Keyless Entry - Inconsistent Operation/Inoperative
- Keyless Entry - Inoperative/Inconsistent Operation
- Audio System - Poor Radio Redeption
- Leather Upholstery - Dirty/Stained
- Interior Fabrics, Vinyls and Plastics - Dirty or Soiled
- Restraint System - 'LATCH' System Installation/Retrofit
- Driver's Side Airbag - On Board Diagnostic Procedures
- Air Bag System - Air Bag Module ID and Coding
- Restraints - Air Bag Module Color Coding/Identification
- Deployed Air Bag - Repair Warning
- A/C - Unpleasant Odors Coming From Vents
- A/C - System Flushing Information
- A/C - Unpleasant Odors Coming From Vents
- A/C - Musty Odors
- A/C - Unpleasant Odors From Vents After Sitting Unused
- A/C - Unpleasant Odors From Vents
- A/C - Musty/Mildew Odors
- A/C - Musty Odors From Vents
- Interior/Steering - Steering Wheel Leather Repair
- Electrical - Battery Charging And Testing Information
- Electrical - Battery Charging and Testing Information
- Electrical - Battery Testing/Charging Information
- Electrical -Diagnosis for Excessive Static Current Draw
- Electrical - Battery Testing/Charging Procedures
- Battery - Current Draw Information
- Electrical - Battery Drain/No Start/Low Battery Codes
- Battery - Testing Procedures
- Electrical - Battery Testing and Charging Information
- Brakes - Vibration/Pulsation Upon Application
- Brakes - Brake Pedal Pulsation/Vibration
- Brakes - Pedal Pulsation/Vibration When Braking
- Brakes - Pedal Pulsation/Body/Steering Wheel Vibration
- Brakes - Pulsation Upon Highway Speed Application
- Fuel System - Fuel Neutralization Procedure
- Ignition System - MIL ON/Multiple Misfire DTCs Are Set
- Ignition System - MIL ON/Misfire DTC's Stored in ECM
- 0108-30 - 10/24/08
- Fuel System - Fuel Quality Information
- Fuel System - Fuel Quality Information
- Fuel System - Fuel Mixture DTC Evaluation
- Fuel System - Poor Fuel Quality Affecting Performance
- Engine Controls - No Scan Tool Communication
- ECM - MIL ON, DTCs P0604, P0605, P0606 ECM Defective
- Engine Control Module - Unnecessary Replacement
- Engine Controls- Avoiding Unnecessary ECM Replacement
- Engine Controls - Avoiding Unnecessary ECM Replacement
- Emissions - Catalytic Converter Replacement Guidelines
- Emissions - Catalytic Converter Replacement Guideline
- Body - Underbody Heat Shield Information
- Engine Controls - ECT Sensor Checking
- Engine Controls - Engine Coolant Temp. Sensor Checking
- Engine - Replacement Precautions
- Engine - Replacement Precautions/Recommendations
- Engine Controls - Silicone Based Sealant/Lubricant Info.
- Engine - Boost/Vacuum Leak Detection/Diagnostics
- Engine - Oil Consumption Measurement
- Engine - Whining Noise Between 1,100 And 1,500 RPM
- Engine - Oil Leaks After Oil Change
- Engine - Low Oil Pressure Lamp ON/Low Oil Pressure
- Engine - Low Oil Pressure/Low Oil Pressure Lamp ON
- Engine - Timing Belt/Tensioner Application Precautions
- A/C - Unpleasant/Musty odors
- 8708-06 - 09/16/08
- Engine - Oil Specifications/Capacity/Oil Filter
- Engine - Oil Specifications/Capacities/Oil Filter
- Engine - Oils Meeting Standard VW502 00 And VW 50501
- Engine - Oil Meeting Specification VW 502 00/VW 505 01
- 1707-14 - 10/12/07
- 1707-15 - 12/21/07
- Engine - VW Oil Standards 502 00/505 01/504 00/507 00
- Engine - Oils Meeting VW Standards
- Engine - Oils Meeting Manufacturer Standards
- 1709-06 - 05/18/09
- Engine - Oils Meeting Manufacturer's Standard
- Engine - Measurement Of Oil Consumption
- Engine Controls - Fuel Mixture DTC Evaluation
- All Technical Service Bulletins
- Paint - Swirl Mark/Fine Scratch Removal
- A/C - System Flushing Information
- Emissions - Catalytic Converter Replacement Guideline
- Cooling System - Coolant ID/Mixing/Improved Coolant
- Electrical - Battery Charging And Testing Information
- A/C - Unpleasant Odors Coming From Vents
- Wipers/Washers - Windshield Wipers Streak Or Smear
- Engine Controls- Diag. Misfire After Campaign 28F/P1
- Electrical - Diagnosis for Excessive Static Current Draw
- Lighting - Exterior Light Moisture Accumulation
- Brakes - Vibration/Pulsation Upon Application
- Engine - Measurement Of Oil Consumption
- Vehicle - Certification Label/VIN Plate Ordering
- Maintenance - Interval Update
- Engine - Low Oil Pressure Condition/Warning Lamp ON
- Engine - Upper Engine Oil Leak Diagnostic Guidelines
- Alloy Wheels - Cleaning Procedure
- Engine Controls - MIL ON/DTC P1603 (18011) Stored
- Brakes/Steering/Suspension - DTC 00778 And 01044 Stored
- Ignition System - MIL ON/Misfire DTC's Set/Rough Running
- Radio (Premium VI) - Maximum Turn-On Volume Inoperative
- Premium VI Radio - Controls Do Not Respond
- Radio - Poor Sound Quality/Insufficient L/H Side Bass
- Air Bag MIL ON, DTC 00588 (Resistance Too Low) Set
- Immobilizer System - Obtaining PIN Number
- Immobilizer System - Code Retrieval
- Emissions - Evaporative Emissions System Testing
- Diagnostic Tester - 7 Digit Immobilizer PIN Update
- Body - Trunk Lid Hard to Open or Close
- Brake Pedal/Booster - Removing and Installing
- Audio System - Poor Radio Reception
- Audio System - CD Player/Changer Display ERR Code 1
- Engine - Oil Consumption Guidelines
- Audio System - Poor Radio Sound Quality/Bass
- Audio System - Radio Security Code Retrieval
- Paint - Swirl Mark and Fine Scratch Reduction
- Air Bag - MIL ON DTC 00588 (Resistance Too High) Set
- Interior - Water Leaks into Footwell Area
- Engine - Rattling Noise On Start Up (Normal Condition)
- Engine - Timing Belt Tensioner/Roller Precautions
- A/T - Cooler/Line Cleaning When Replacing A/T
- A/T - Torque Converter Installation Precautions
- Engine Controls - DTC's 00545/00638 Stored
- Brakes - Master Cylinder/ABS Pressure Testing Adapter
- Engine Controls - Idle Dip/Fluctuation/MIL ON/DTC's Set
- Airbag - Deployed Airbag Repair
- Lights - Headlight Electrical Connection Repair
- Interior - Steering Wheel Leather Wrap Coming Loose
- Computers/Controls - No Communication With Scan Tools
- Engine - DTC's P1297/P1557 Stored in Memory
- Audio System - CD Player Jams/Magazine Won't Eject
- Engine - Intake System Leak Checking
- Engine - Low Oil Pressure Lamp ON
- Engine Controls - DTC's P0604/P0605/P0606 in Memory
- Engine - Oil Filter/Oil Specifications/Capacities
- Engine Controls - Evaluating Fuel Mixture DTC's
- Restraints - LATCH(R) System Installation/Retrofitting
- Audio System - Poor AM/FM Band Radio Reception
- A/C - Fresh Air Lever Light Inoperative
- Engine - Oil Drain Plug Thread Cleaning
- Engine - Oil Pressure is Too Low
- Interior - Cleaning Tips for Leather Upholstery
- Body - Sunroof Malfunctions or is Inoperative
- Engine Controls - Avoiding Unnecessary ECM Replacement
- Emissions - Possible MIL ON/Cat Converter DTC's Set
- Emissions - Evaporative Emissions System Testing
- Audio System - Antitheft Code Retrieval/Entering
- Recall 08V156000: Potential Vehicle Fires
- Engine - Component Inspection During Engine Replacement
- Engine Controls - Silicone Sealer/Lubricant Precautions
- Restraints - Air Bag Color Code ID And Coding
- Interior - Cleaning Tips for Vinyls/Plastics/Fabrics
- Exhaust System - Heat Shield Replacement Guidelines
- Fuel System - Neutralizing Fuel For Fuel Tank Disposal
- Keyless Entry/Starting - Remote Key Inoperative
- Interior - Cleaning Tips Fabrics, Vinyls And Plastics
- Engine Controls - MIL ON/Multiple DTC's
- Fuel System - Fuel Related Driveability Issues
- Engine - Low Oil Pressure/Warning Lamp ON
- Recall - Potential Under Vehicle Fires
- Recall Circular
- Criteria Code Contents
- Saga Claim Entry Procedure
- Customer Letter Example USA
- Customer Letter Example Canada
- Campaign Work Procedure
- Work Sequence
- Section A - Heat Shield Installation
- Section B - Fuel Line Bracket Removal and Fuel Line Inspection
- Section C - Fuel Line Foam Block Removal and Bracket Clipping
- Section D - Fuel Line Replacement
- Section E - Fuel Tank Inspection
- Section F - Visual Inspection/Vent Line Check
- Section G - Fuel Tank Removal
- Section H - Fuel Sending Unit Removal
- Section J - Fuel Sending Unit Installation
- Section K - Software Update Using Software Version Management
- Immobilizer System - Active/DTC's P0513/1177
- Campaign - A/C Plenum Drain Modification
- Service Action Circular
- Saga Claim Entry Procedure
- Customer Letter
- Campaign Work Procedure
- Work Procedure
- Vehicle Preparation
- Section A - Remove Chamber Cover
- Section B - Remove Wiper Arm
- Section C - Remove Coral Panel
- Section D - Remove Battery and Battery Tray
- Section E - Clean Air Plenum Area And Remove Drain Tube
- Section F - Reinstall Battery Tray and Battery
- Section G - Seal Pollen Filter Housing
- Section H - Reinstall Cowl
- Section J- Reinstall Wiper Arm
- Section K - Modify Sunroof Drain (If Equipped)
- Section L - Reinstall Plenum Chamber Cover
- Section M - Work Steps Required After Connecting Battery
- Cooling System - Coolant Identification/Mixing
- Emissions - Interim Repair For Recall 28F3
- Audio System - Entering/Retrieving Anti-Theft Code
- Electrical - One Or More Back Glass Defroster Grids Inop
- Restraints - Child Restraint LATCH(R) Compliance
- Ignition System - MIL ON/DTC's P0300-P0312 Stored
- Engine - Oils Meeting Manufacturer's Standard