Repair and Diagnosis: Technical Service Bulletins
- How to Find Technical Service Bulletins by Category/Symptom
- Recalls
- Customer Interest
- A/C - Unpleasant Odors Coming From Vents
- Wipers/Washers - Windshield Wipers Streak Or Smear
- Body - Front Doors Damaged By Ice Formation
- Electrical - Lock/Window/Fuel Door Switches Inoperative
- Interior - Front Center Armrest Cover Will Not Close
- Brakes - Vibration/Pulsation Upon Application
- Restraints - Air Bag Lamp ON/DTC 02511 014 Stored
- Suspension - Front Suspension Creaking Noises
- Engine - Upper Engine Oil Leak Diagnostic Guidelines
- Engine Controls - MIL ON/DTC P1603 (18011) Stored
- Body - Trunk Lid Hard to Open or Close
- Audio System - Poor Radio Reception
- Interior - Rear Door Panels Rattle From Audio Bass
- Audio/Interior - Door Panel Rattles With Bass
- Audio/Interior - Rear Door Panels Rattle With Bass
- Windshield Wipers - Smear or Streak Windshield
- Wipers - Windshield Wipers Streak or Smear Windshield
- M/T - Humming Noise When Turning at Low Speeds
- Engine Controls - DTC's 00545/00638 Stored
- Navigation System - Various System Errors
- Interior - Steering Wheel Leather Wrap Coming Loose
- Computers/Controls - No Communication With Scan Tools
- Engine - DTC's P1297/P1557 Stored in Memory
- Lighting - Water Intrusion Into Tail Lamps
- Interior - Rear Center Arm Rest Lock Cylinder Noisy (US)
- Audio System - Poor Reception/Volume Fades
- Audio System - CD Player Jams/Magazine Won't Eject
- Fuel System - Rattle From Front Passenger Floor Area
- Instruments - Fuel Gauge May Not Read Full
- Wipers/Washers - Insufficient Washer Nozzle Spray
- Interior - Arm Rest Does Not Ratchet Correctly/Loose
- Audio System - Poor AM/FM Band Radio Reception
- Instruments - Speedometer Reads Too Fast
- Body - Driver's Door Lock Cylinder is Inoperative (US)
- A/C, Interior - Front Passenger Seat Heater Inoperative
- Body - Door Windows Separate From Regulator Clamps
- A/C - Rear Window Defogger Inoperative
- A/C - No Cooling/Compressor Seized
- Suspension - Rear Suspension is Noisy
- Body - Sunroof Malfunctions or is Inoperative
- M/T, A/T - Knocking Noise Under Load
- Engine Controls - DTC P3081/Cold Start Exhaust Noise
- Emissions - Possible MIL ON/Cat Converter DTC's Set
- Body - Fuel Door Will Not Close
- A/C - Poor Performance/Insufficient Cooling
- A/C - Front Center Air Outlet Rattles (U.S. Only)
- Body - Front/Rear Door Seals Detached
- A/C - Blower Motor Operates On High Only
- Interior - Front Seat Creaking/Cracking Noises
- Electrical - Driver's Window/Lock Switches Inoperative
- Suspension - Front Suspension Creaking Noise
- Restraints - Air Bag Lamp ON/DTCs 01217/01218 Set
- Instruments - Cruise Control is Inoperative
- Wipers/Washers - Smearing/Streaking (Canada)
- A/C - Poor Performance/Blows Warm Air/DTC's Set
- Body - Rear Door Leading Edge Paint Wear
- Keyless Entry/Starting - Remote Key Inoperative
- Body - Door Windows May Separate From Regulators
- Body - Driver/Passenger Window(s) Inoperative
- Engine Controls - DTC's P0300-P0304/P0420/P0441
- Navigation Radio - Multiple Malfunctions
- Interior - Rear Cup Holder Sticks/Hard To Remove
- Audio System - Bass Flare/Poor Radio Reception
- Audio System - Aux Devices Inop After Radio Replacement
- Cruise Control - SET/RES Intermittent, Won't Activate
- Lighting - HID Headlamp DTC's 01534 Or 01535
- Audio System - Auxiliary Jack/iPod(R)/CD Changer Inop.
- Charging System - No Start/Generator Lamp Flashing
- Interior - Rear Arm Rest Won't Fold Down
- Electrical - One Or More Back Glass Defroster Grids Inop
- Interior - Fuel Door Switch Falls Into Driver Door Panel
- Ignition System - MIL ON/DTC's P0300-P0312 Stored
- Superceded Bulletins
- 4009-02 - 03/16/09
- 9709-05 - 12/21/09
- 191002 - 03/17/10
- 9109-13 - 06/16-09
- 9109-16 - 06/25/09
- 8709-03 - 04/29/09
- 9109-29 - 11/17/09
- 2809-01 - 10/21/09
- 2709-02 - 05/13/09
- 0109-06 - 04/08/09
- 7008-01 - 01/01/08
- 5707-07 - 07/18/07
- Vehicle - VIN Plate/Safety Certification Label Ordering
- 4607-01 - 06/11/07
- 2007-04 - 03/29/07
- 3406-03 - 07/05/06
- 9206-02 - 05/18/06
- 3406-01 - 06/05/06
- 7006-04 - 05/04/06
- 48-06-02 - 04/01/06
- 6906-02 - 01/30/06
- 6906-01 - 01/20/06
- 9105-04 - 10/11/05
- 6805-02 - 08/09/05
- Wipers/Washers - Front/Rear Washer Jets Restricted
- Wipers/Washers- Windshield Wipers Streak Or Smear
- Body - Window Glass Separates From Window Regulator
- Body - Windows Separate From Regulator Clamps
- Body - Door Glass Separates From Window Regulator
- Body - Door Window Separates From Window Regulator
- A/C - Heated Rear Glass Has Lines That Are Inoperative
- Lighting - Water Intrusion Into Tail Lamp
- Lighting - Headlamp Range Control Motor Replacement
- Lighting - Exterior Light Moisture Accumulation
- Lighting - Condensation Inside Exterior Lights
- Instruments - Speedometer Inaccurate/Reads Too Fast
- Interior Seat Easy Entry Feature Inoperative
- Body - Sunroof Malfunctions/Inoperative Diagnosis
- Body - Underhood Not Painted Body Color
- Paint - Swirl Mark/Fine Scratch Removal
- Paint - Fine Scratch/Swirl Mark Reduction
- Body - Driver Door Lock Cylinder Inoperative
- Body - Driver's Door Lock Cylinder Inoperative
- Interior - Cleaning Tips for Fabrics/Vinyls/Plastics
- Body/Interior - Squeak and Rattle Kit Availability
- Interior - Front Center Armrest Cover Will Not Close
- Interior - Rear Arm Rest Will Not Fold Down/Binds
- Interior - Arm Rest Loose, Does Not Ratchet Correctly
- Interior - Console Arm Rest Lid Latch Broken
- Interior - Arm Rest Is Loose/Won't Ratchet Properly
- Interior - Rear Center Arm Rest Lock Cylinder Noisy
- Body - Upper Wheel Opening Front Fender Corrosion
- Body - Front Fender Corrosion At Upper Wheel Opening
- Body - Fuel Tank Lid Does Not Close
- Body/Fuel - Fuel Tank Lid Won't Close
- Body/Fuel System - Fuel Tank Lid Doesn't Close
- Interior - Fuel Door Switch Falls Into L/H Door Panel
- Interior - Front Door Panels Rattle From Audio Bass
- Audio System - Satellite Radio System Overview
- Audio System - Satellite Radio Overview
- Audio System - Antitheft Code Entering/Retrieval
- Audio System - Radio Antitheft Code Information
- Audio System - 'NO SAT' Message Displayed on Radio
- Audio System - Bass Flare
- Audio System - Bass Flare/Radio Won't Power Down
- Audio System - 'NO SAT' Message Displayed
- 9106-07 - 10/20/06
- Audio System - Antitheft Security Code Retrieval
- Interior/Audio System - Bass Causes Door Panel Rattling
- Audio System - Poor AM/FM Band Reception
- Audio System - CD Player Diagnostics Overview
- Audio System CD Player Diagnostics Overview
- Audio System - Poor Sound Quality
- Audio System - Volume Fluctuation/Poor Sound Quality
- Audio/Navigation - Various Malfunctions
- Audio/Navigation Systems - Various Malfunctions
- Audio System - Radio And External Media Device Overview
- Audio System - External Media Device Overview
- Body/Controls - Sunroof/Central Control Module Diagnosis
- Cell Phone - Approved Bluetooth(R) Retrofit Kit
- Antitheft - Retrieving Immobilizer Codes
- Antitheft - Immobilizer Code Retrieval
- Antitheft System - Retrieving Immobilizer Codes
- Antitheft System - Immobilizer Code Retrieval
- Keyless Entry - Remote Key is Inoperative
- Keyless Entry - Inconsistent Operation or Inoperative
- Keyless Entry - Remote Key Feature Inoperative/Erratic
- Keyless Entry - Transmitters Inoperative
- Keyless Entry - Inconsistent Operation/Inoperative
- Keyless Entry - Inoperative/Inconsistent Operation
- Audio System - Inconsistent Sound/Reception Fades
- Audio System - Inconsistent Sound Quality
- 9106-06 - 10/20/06
- Audio/Navigation/GPS - Antenna Diagnosis Overview
- Audio System - Antenna Diagnosis Overview
- Audio System - Poor Radio Redeption
- Restraint System - 'LATCH' System Installation/Retrofit
- Driver's Side Airbag - On Board Diagnostic Procedures
- Introduction
- Airbag on Board Diagnostic (OBD)
- Airbag Diagnostic Trouble Code (DTC) Table
- Measuring Value Block, Reading
- Display Group 001
- Evaluating Display Group 001
- Vas 5056 Test Box, Components
- Airbag, Connecting Test Box to Driver's Airbag Components
- Airbag Spiral Spring/Return Spring With Slip Ring, Installation
- Airbag Spiral Spring/Return Spring With Slip Ring, Adjustment
- Wire Harness, Repair
- Airbag Spiral/Return Spring W/Slip Ring-Connector Repair
- Airbag Spiral/Return Spring W/Slip Ring-Terminal Inspection
- Airbag Spiral/Return Spring W/Slip Ring Adapter Harness-Install
- Restraints - Air Bag MIL ON/DTC 02511 014 Set
- Air Bag System - Air Bag Module ID and Coding
- Restraints - Air Bag Module Color Coding/Identification
- Restraints - Air Bag Lamp ON/DTC's 01217/01218 Set
- Air Bag System - Warning Lamp ON/DTC's 01217/01218
- A/C - Unpleasant Odors Coming From Vents
- A/C - System Flushing Information
- A/C - Unpleasant Odors Coming From Vents
- A/C - Inadequate Heater Output Explanation
- A/C - Inoperative/Low Cooling/DTC's 00819/00229
- 8707-11 - 08/28/07
- A/C - Unpleasant Odors From Vents After Sitting Unused
- A/C - Unpleasant Odors From Vents
- A/C - Musty/Mildew Odors
- A/C - Musty Odors From Vents
- A/C - Climatic Controls Operation
- 8707-08 - 07/26/07
- A/C - Does Not Cool/Compressor Seized
- A/C - Front Center Air Outlet Rattles
- Interior/Steering - Steering Wheel Leather Repair
- Steering - Adaptation Required After Parts Replacement
- Steering - Adaptation After Replacing Parts
- Steering - Adaptation After Parts Replacement
- Electrical - Various Electrical Conerns
- Electrical - Various Electrical Concerns
- Electrical - Battery Charging And Testing Information
- Electrical - Battery Charging and Testing Information
- Electrical - Battery Testing/Charging Information
- Electrical -Diagnosis for Excessive Static Current Draw
- Electrical - Battery Testing/Charging Procedures
- Battery - Current Draw Information
- Electrical - Battery Drain/No Start/Low Battery Codes
- Battery - Testing Procedures
- Electrical - Battery Testing and Charging Information
- Brakes - Abnormal Vibration When Braking
- Brakes - Vibration/Pulsation Upon Application
- Brakes - Brake Pedal Pulsation/Vibration
- Brakes - Abnormal Vibration When Braking
- Brakes - Pedal Pulsation/Vibration When Braking
- Brakes - Pedal Pulsation/Body/Steering Wheel Vibration
- Brakes - Pulsation Upon Highway Speed Application
- Brakes - Vibration Upon Brake Application
- Brakes - Vibration Upon Braking
- Brakes - Vibration While Braking
- Brakes - Vibration When Braking
- Brakes - Vibration During Braking
- A/T - Direct Shift Gearbox (DSG) Delay On Acceleration
- Fuel System - Rattling Under Passenger Side Floor
- Fuel System - Fuel Neutralization Procedure
- Ignition System - MIL ON/Multiple Misfire DTCs Are Set
- Ignition System - MIL ON/Misfire DTC's Stored in ECM
- Computers/Controls - Management Of Software Versions
- 0108-30 - 10/24/08
- Fuel System - Fuel Quality Information
- Fuel System - Fuel Quality Information
- Computers/Controls - Software Version Management
- Fuel System - Fuel Mixture DTC Evaluation
- Air Bag System - Warning Lamp ON/DTC's 01217 / 01218
- Fuel System - Poor Fuel Quality Affecting Performance
- 0108-21 - 08/19/08
- Engine Controls - Avoiding Unnecessary ECM Replacement
- Emissions - Catalytic Converter Replacement Guidelines
- Emissions - Catalytic Converter Replacement Guideline
- Body - Underbody Heat Shield Information
- Engine Controls - ECT Sensor Checking
- Engine Controls - Engine Coolant Temp. Sensor Checking
- Cooling System - Cooling Fans Run With Ignition Off
- Cooling System - Cooling Fans Run After Ign. Turned Off
- Engine - Replacement Precautions
- Engine Controls - Silicone Based Sealant/Lubricant Info.
- Engine - Oil Consumption Measurement
- Engine - Oil Filler Cap Comes Apart
- Engine - Oil Leaks After Oil Change
- Engine - Oils Meeting Manufacturer Standards
- 1707-14 - 10/12/07
- Engine - Oils Meeting Standard VW502 00 And VW 50501
- A/C - Rear Window Defogger is Inoperative
- Engine - Oil Meeting Specification VW 502 00/VW 505 01
- A/C - Unpleasant/Musty odors
- 1707-15 - 12/21/07
- Engine - VW Oil Standards 502 00/505 01/504 00/507 00
- Engine - Oils Meeting VW Standards
- 8708-06 - 09/16/08
- A/C - A/C Flushing Procedure
- Engine - Oils Meeting Manufacturer's Standard
- Engine - Measurement Of Oil Consumption
- All Technical Service Bulletins
- Body - Underhood Not Painted Body Color
- Paint - Swirl Mark/Fine Scratch Removal
- A/C - System Flushing Information
- Emissions - Catalytic Converter Replacement Guideline
- Cooling System - Coolant ID/Mixing/Improved Coolant
- Electrical - Battery Charging And Testing Information
- A/C - Unpleasant Odors Coming From Vents
- Wipers/Washers - Windshield Wipers Streak Or Smear
- Body/Interior - Squeak And Rattle Kit Available
- Engine Controls- Diag. Misfire After Campaign 28F/P1
- Electrical - Diagnosis for Excessive Static Current Draw
- Lighting - Exterior Light Moisture Accumulation
- Audio System - Antenna Diagnostic Overview
- Body - Front Doors Damaged By Ice Formation
- Audio System - CD Player Diagnostic Overview
- Electrical - Lock/Window/Fuel Door Switches Inoperative
- Interior - Front Center Armrest Cover Will Not Close
- Direct Shift Gearbox (DSG) - Delay On Acceleration
- Brakes - Vibration/Pulsation Upon Application
- Engine - Measurement Of Oil Consumption
- Restraints - Air Bag Lamp ON/DTC 02511 014 Stored
- Suspension - Front Suspension Creaking Noises
- Vehicle - Certification Label/VIN Plate Ordering
- Engine - Upper Engine Oil Leak Diagnostic Guidelines
- Engine Controls/Antitheft - 7 Digit PIN Number
- Engine Controls - MIL ON/DTC P1603 (18011) Stored
- Immobilizer System - Code Retrieval
- Computers/Controls - Various Control Modules With DTC's
- Body - Trunk Lid Hard to Open or Close
- Audio System - Poor Radio Reception
- Engine - Oil Consumption Guidelines
- Audio System - XM Satellite Radio Activation
- Audio System - Radio Security Code Retrieval
- Campaign - Poor Radio Reception When Cold/Hot
- Campaign - Ground Connection Inspection
- Steering - DSR Activation And Programming Procedure
- Interior - Rear Door Panels Rattle From Audio Bass
- Audio/Interior - Door Panel Rattles With Bass
- Audio/Interior - Rear Door Panels Rattle With Bass
- Windshield Wipers - Smear or Streak Windshield
- Wipers - Windshield Wipers Streak or Smear Windshield
- M/T - Humming Noise When Turning at Low Speeds
- Engine - Rattling Noise On Start Up (Normal Condition)
- A/T - Torque Converter Installation Precautions
- Engine Controls - DTC's 00545/00638 Stored
- Navigation System - Various System Errors
- Airbag - Deployed Airbag Repair
- Interior - Steering Wheel Leather Wrap Coming Loose
- Air Bag System - Description, Passenger Side Air Bag
- Computers/Controls - No Communication With Scan Tools
- Engine - DTC's P1297/P1557 Stored in Memory
- Luggage Compartment - Trim Panel Net Repair Kit
- Washer System - Washer Jets (Front or Rear), Restricted
- Lighting - Water Intrusion Into Tail Lamps
- Interior - Rear Center Arm Rest Lock Cylinder Noisy (US)
- A/T Gear Indicator Flashes/Engine RPM Fluctuation
- Audio System - Poor Reception/Volume Fades
- Audio System - CD Player Jams/Magazine Won't Eject
- Windshield Wipers - One Intermittent Sweep
- Instruments - Trip Computer Fuel Mileage Information
- Fuel System - Rattle From Front Passenger Floor Area
- Fuel System - Fuel Tank Ground Strap Installation
- Instruments - Fuel Gauge May Not Read Full
- Recall 07V063000: Brake Light Switch Replacement
- Engine Controls - Evaluating Fuel Mixture DTC's
- Wipers/Washers - Insufficient Washer Nozzle Spray
- Interior - Arm Rest Does Not Ratchet Correctly/Loose
- Audio System - Poor AM/FM Band Radio Reception
- Engine - Oil Drain Plug Thread Cleaning
- Instruments - Speedometer Reads Too Fast
- Body - Driver's Door Lock Cylinder is Inoperative (US)
- A/C, Interior - Front Passenger Seat Heater Inoperative
- Body - Door Windows Separate From Regulator Clamps
- A/C - Rear Window Defogger Inoperative
- A/C - No Cooling/Compressor Seized
- Suspension - Rear Suspension is Noisy
- Interior - Cleaning Tips for Leather Upholstery
- Body - Sunroof Malfunctions or is Inoperative
- M/T, A/T - Knocking Noise Under Load
- Engine Controls - Avoiding Unnecessary ECM Replacement
- Engine Controls - DTC P3081/Cold Start Exhaust Noise
- Emissions - Possible MIL ON/Cat Converter DTC's Set
- Recall 07V442000: Headlamp Adjustment Non-Compliance
- Body - Fuel Door Will Not Close
- Audio System - Antitheft Code Retrieval/Entering
- Body - Door Lock Rotary Switch Diagnostic Aid
- A/T - Fluid Leaking Between Case Halves
- A/C - Poor Performance/Insufficient Cooling
- A/C - Front Center Air Outlet Rattles (U.S. Only)
- Body - Front/Rear Door Seals Detached
- A/C - Blower Motor Operates On High Only
- A/C - Seat Heater is Inoperative
- Interior - Front Seat Creaking/Cracking Noises
- Electrical - Driver's Window/Lock Switches Inoperative
- Suspension - Front Suspension Creaking Noise
- Restraints - Air Bag Lamp ON/DTCs 01217/01218 Set
- Engine - Component Inspection During Engine Replacement
- Engine Controls - Silicone Sealer/Lubricant Precautions
- Instruments - Cruise Control is Inoperative
- Restraints - Air Bag Color Code ID And Coding
- Wipers/Washers - Smearing/Streaking (Canada)
- Interior - Cleaning Tips for Vinyls/Plastics/Fabrics
- Audio System - Radio Part Number Interpretation
- A/C - Poor Performance/Blows Warm Air/DTC's Set
- A/C - Seat Heater Inoperative/Erratic Operation
- Exhaust System - Heat Shield Replacement Guidelines
- Steering - Adaptation Required After Part Replacement
- Fuel System - Neutralizing Fuel For Fuel Tank Disposal
- Body - Rear Door Leading Edge Paint Wear
- Computers/Controls - Control Module Testing Information
- Keyless Entry/Starting - Remote Key Inoperative
- Interior - Cleaning Tips Fabrics, Vinyls And Plastics
- Body - Door Windows May Separate From Regulators
- Body - Driver/Passenger Window(s) Inoperative
- Cooling System, A/C - Poor Heater Output
- Engine Controls - DTC's P0300-P0304/P0420/P0441
- Navigation Radio - Multiple Malfunctions
- Interior - Rear Cup Holder Sticks/Hard To Remove
- Fuel System - Fuel Related Driveability Issues
- Audio System - Bass Flare/Poor Radio Reception
- Audio System - Aux Devices Inop After Radio Replacement
- A/C - Climate Control Operation Information
- Cruise Control - SET/RES Intermittent, Won't Activate
- Lighting - HID Headlamp DTC's 01534 Or 01535
- Body - Under Hood Paint Doesn't Match Exterior (Canada)
- Immobilizer System - Active/DTC's P0513/1177
- Audio System - Auxiliary Jack/iPod(R)/CD Changer Inop.
- Cooling System - Coolant Identification/Mixing
- Computers/Controls - Software Version Management Info.
- Navigation Radio - Radio Repair Program
- Charging System - No Start/Generator Lamp Flashing
- Emissions - Interim Repair For Recall 28F3
- Interior - Rear Arm Rest Won't Fold Down
- Audio System - Entering/Retrieving Anti-Theft Code
- Electrical - One Or More Back Glass Defroster Grids Inop
- Cell Phone - Bluetooth(R) Retrofit Kit
- Charging Sys/Lighting - Headlamps Dim At Idle
- Restraints - Child Restraint LATCH(R) Compliance
- Audio/Navigation - Antenna Diagnostics Overview
- Electrical - Ground Connection Verification Test
- Audio System - Radio And External Device Overview
- Interior - Fuel Door Switch Falls Into Driver Door Panel
- Ignition System - MIL ON/DTC's P0300-P0312 Stored
- Emissions - EVAP System DTC Diagnostic Information
- Engine - Oils Meeting Manufacturer's Standard
- Audio System - Satellite Radio System Overview