Heating and A/C System Components In Passenger Compartment, Servicing

Heating And A/C System Components In Passenger Compartment, Servicing

NOTE:
- Disconnect battery before removing components marked with**.
- A data plate indicates the refrigerant used and capacity.







1. Instrument panel**
2. Center air vents

3. Right side window defroster air duct
- In right A-pillar

4. Right air vent

5. Heating and A/C controls - Climatic
- With Fresh Air/Recirculating Flap Switch E159
- With Rear Window Defogger Switch E230
- with Fresh Air Blower Switch E9
- With A/C Control Module J301
- With Immediate Heating Button E537 where applicable

6. Recirculation Flap Motor V113
- Checking: Use Vehicle Diagnostic, Testing and Information System VAS 5051/5052 in operating mode "Guided Fault Finding".
- Replacing: Initiate Basic Setting using Vehicle Diagnostic, Testing and Information System VAS 5051/5052 in operating mode "Guided Fault Finding".
7. Right footwell air vent

8. Fresh Air Blower V2
- Depending on unit configuration, blower on vehicle may not be exactly as shown here

9. Fresh Air Blower Series Resistor With Fuse N24
- Depending on unit configuration, resistor with fuse may not be exactly as shown here

10. Heating and ventilation unit partition
- Removing

11. Evaporator Vent Temperature Sensor G263
12. Sealing caps
- Only in vehicles without air guide to vent installed in center console at rear

13. Dust and pollen filter
- With activated charcoal filter

14. Center console air duct
- Connection to center console air guide
- To remove, center console must be removed Body Interior.

15. Right rear footwell air duct

16. Left rear footwell air duct

17. Screws
- Qty. 8
- Observe varying lengths

18. Heating and A/C control adapter
19. Auxiliary Heater Heating Element Z35
- Only on models with Diesel engine

20. Heater core
21. Left footwell air vent

22. Temperature Regulator Flap Motor V68
- Checking: Use Vehicle Diagnostic, Testing and Information System VAS 5051/5052 in operating mode "Guided Fault Finding".
- Replacing: Initiate Basic Setting using Vehicle Diagnostic, Testing and Information System VAS 5051/5052 in operating mode "Guided Fault Finding".

23. Air distribution control - flexible cable
24. Footwell Outlet Temperature Sensor G192
25. Heating and A/C unit
- Disassembling and assembling.

26. Left side window defroster air duct
- In left A-pillar

27. Center Outlet Temperature Sensor G191