Repair and Diagnosis: Technical Service Bulletins
- How to Find Technical Service Bulletins by Category/Symptom
- Recalls
- Customer Interest
- Keyless Start System - Engine No Start/No Crank
- Body - Upper Wheel Opening Front Fender Corrosion
- A/C - Unpleasant Odors Coming From Vents
- Wipers/Washers - Windshield Wipers Streak Or Smear
- Body - Front Doors Damaged By Ice Formation
- Electrical - Lock/Window/Fuel Door Switches Inoperative
- Interior - Front Center Armrest Cover Will Not Close
- Engine Controls - Noise After Cold Start And DTC P3081
- Brakes - Vibration/Pulsation Upon Application
- Restraints - Air Bag Lamp ON/DTC 02511 014 Stored
- Suspension - Front Suspension Creaking Noises
- Audio System - Poor Radio Reception
- Interior - Rear Door Panels Rattle From Audio Bass
- Audio/Interior - Door Panel Rattles With Bass
- Audio/Interior - Rear Door Panels Rattle With Bass
- Windshield Wipers - Smear or Streak Windshield
- Wipers - Windshield Wipers Streak or Smear Windshield
- Body - Fuel Tank Lid (Fuel Door) Does Not Close
- M/T - Humming Noise When Turning at Low Speeds
- Engine Controls - DTC's 00545/00638 Stored
- Navigation System - Various System Errors
- Computers/Controls - No Communication With Scan Tools
- A/T - High Launch RPM's/DTC P0716/P0740
- Lighting - Water Intrusion Into Tail Lamps
- Audio System - Poor Reception/Volume Fades
- Audio System - CD Player Jams/Magazine Won't Eject
- Engine Controls - MIL ON/DTC's P001, P000A Set
- Fuel System - Rattle From Front Passenger Floor Area
- Wipers/Washers - Insufficient Washer Nozzle Spray
- Audio System - Poor AM/FM Band Radio Reception
- Engine - Oil Filler Cap Separation
- Instruments - Speedometer Reads Too Fast
- Body - Driver's Door Lock Cylinder Inoperative (Canada)
- Body - Door Windows Separate From Regulator Clamps
- A/C - Rear Window Defogger Inoperative
- A/C - No Cooling/Compressor Seized
- Suspension - Rear Suspension is Noisy
- Body - Sunroof Malfunctions or is Inoperative
- M/T, A/T - Knocking Noise Under Load
- Engine Controls - Exhaust Noise/DTC's P0011/P000A
- Emissions - Possible MIL ON/Cat Converter DTC's Set
- A/T - Won't Shift Out of PARK/DTC's U0101/28773/01315
- Body - Fuel Door Will Not Close
- Body - Fuel Door Does Not Close
- A/C - Poor Performance/Insufficient Cooling
- A/C - Front Center Air Outlet Rattles (U.S. Only)
- A/C - Front Center Air Outlet Rattles (Canada Only)
- Body - Front/Rear Door Seals Detached
- A/C - Blower Motor Operates On High Only
- A/C - Does Not Get Cold Enough
- Interior - Front Seat Creaking/Cracking Noises
- Electrical - Driver's Window/Lock Switches Inoperative
- Electrical - Dome/Sun Visor Lamps Inoperative
- Suspension - Front Suspension Creaking Noise
- Restraints - Air Bag Lamp ON/DTCs 01217/01218 Set
- Instruments - Cruise Control is Inoperative
- Wipers/Washers - Smearing/Streaking (Canada)
- A/C - Poor Performance/Blows Warm Air/DTC's Set
- A/T - 'PRNDS' Indicator ON/DTC's Set/Emergency Mode
- Body - Rear Door Leading Edge Paint Wear
- Keyless Entry/Starting - Remote Key Inoperative
- Navigation Radio - Multiple Malfunctions
- Interior - Rear Cup Holder Sticks/Hard To Remove
- Audio System - Bass Flare/Poor Radio Reception
- Audio System - Aux Devices Inop After Radio Replacement
- Instruments - No Menu Using Steering Wheel Buttons
- Steering - Update Software After Part Replacement
- Cruise Control - SET/RES Intermittent, Won't Activate
- Lighting - HID Headlamp DTC's 01534 Or 01535
- Audio System - Auxiliary Jack/iPod(R)/CD Changer Inop.
- Charging System - No Start/Generator Lamp Flashing
- Interior - Rear Arm Rest Won't Fold Down
- Electrical - One Or More Back Glass Defroster Grids Inop
- Interior - Fuel Door Switch Falls Into Driver Door Panel
- Ignition System - MIL ON/DTC's P0300-P0312 Stored
- Superceded Bulletins
- 4009-02 - 03/16/09
- 9709-05 - 12/21/09
- 191002 - 03/17/10
- 9109-13 - 06/16-09
- 9109-16 - 06/25/09
- 8709-03 - 04/29/09
- 4809-01 - 03/03/09
- 9109-29 - 11/17/09
- 2809-01 - 10/21/09
- 2709-02 - 05/13/09
- 7008-01 - 01/01/08
- 5506-05 - 07/12/06
- 5707-07 - 07/18/07
- Vehicle - VIN Plate/Safety Certification Label Ordering
- 4607-01 - 06/11/07
- 3406-03 - 07/05/06
- 9206-02 - 05/18/06
- 3406-01 - 06/05/06
- 7006-04 - 05/04/06
- 48-06-02 - 04/01/06
- 6906-02 - 01/30/06
- 6906-01 - 01/20/06
- 9105-04 - 10/11/05
- Wipers/Washers - Front/Rear Washer Jets Restricted
- Wipers/Washers- Windshield Wipers Streak Or Smear
- Body - Window Glass Separates From Window Regulator
- Body - Windows Separate From Regulator Clamps
- Body - Door Glass Separates From Window Regulator
- A/C - Heated Rear Glass Has Lines That Are Inoperative
- Lighting - Water Intrusion Into Tail Lamp
- Lighting - Headlamp Range Control Motor Replacement
- Lighting - Exterior Light Moisture Accumulation
- Lighting - Condensation Inside Exterior Lights
- Instruments - Speedometer Inaccurate/Reads Too Fast
- Interior Seat Easy Entry Feature Inoperative
- Body - Sunroof Malfunctions/Inoperative Diagnosis
- Body - Underhood Not Painted Body Color
- Paint - Swirl Mark/Fine Scratch Removal
- Paint - Fine Scratch/Swirl Mark Reduction
- Body - Driver Door Lock Cylinder Inoperative
- Body - Driver's Door Lock Cylinder Inoperative
- Interior - Cleaning Tips for Fabrics/Vinyls/Plastics
- Body/Interior - Squeak and Rattle Kit Availability
- Interior - Front Center Armrest Cover Will Not Close
- Interior - Rear Arm Rest Will Not Fold Down/Binds
- Body - Upper Wheel Opening Front Fender Corrosion
- Body Upper Wheel Opening Front Fender Corrosion
- Body - Front Fender Corrosion At Upper Wheel Opening
- Body - Fuel Tank Lid Does Not Close
- Body/Fuel - Fuel Tank Lid Won't Close
- Body/Fuel System - Fuel Tank Lid Doesn't Close
- Interior - Fuel Door Switch Falls Into L/H Door Panel
- Interior - Front Door Panels Rattle From Audio Bass
- Audio System - Satellite Radio System Overview
- Audio System - Satellite Radio Overview
- Audio System - Antitheft Code Entering/Retrieval
- Audio System - Radio Antitheft Code Information
- Audio System - 'NO SAT' Message Displayed on Radio
- Audio System - Bass Flare
- Audio System - Bass Flare/Radio Won't Power Down
- Audio System - 'NO SAT' Message Displayed
- 9106-07 - 10/20/06
- Interior/Audio System - Bass Causes Door Panel Rattling
- Audio System - Poor AM/FM Band Reception
- Audio System - CD Player Diagnostics Overview
- Audio System CD Player Diagnostics Overview
- Audio System - Poor Sound Quality
- Audio System - Volume Fluctuation/Poor Sound Quality
- Navigation - Map Purchase And Update Information
- Audio/Navigation - Various Malfunctions
- Audio/Navigation Systems - Various Malfunctions
- Audio System - Radio And External Media Device Overview
- Audio System - External Media Device Overview
- Body/Controls - Sunroof/Central Control Module Diagnosis
- Cell Phone - Approved Bluetooth(R) Retrofit Kit
- Keyless Entry - Remote Key is Inoperative
- Keyless Entry - Inconsistent Operation or Inoperative
- Keyless Entry - Remote Key Feature Inoperative/Erratic
- Keyless Entry - Inconsistent Operation/Inoperative
- Keyless Entry - Inoperative/Inconsistent Operation
- Audio System - Inconsistent Sound/Reception Fades
- Audio System - Inconsistent Sound Quality
- 9106-06 - 10/20/06
- Audio/Navigation/GPS - Antenna Diagnosis Overview
- Audio System - Poor Radio Redeption
- Accessories - Steering Wheel Menu Change Button Inop.
- Restraints - Air Bag MIL ON/DTC 02511 014 Set
- Air Bag System - Air Bag Module ID and Coding
- Restraints - Air Bag Module Color Coding/Identification
- Restraints - Air Bag Lamp ON/DTC's 01217/01218 Set
- Air Bag System - Warning Lamp ON/DTC's 01217/01218
- A/C - Unpleasant Odors Coming From Vents
- A/C - System Flushing Information
- A/C - Unpleasant Odors Coming From Vents
- A/C - Inadequate Heater Output Explanation
- 8706-03 - 12/18/06
- 8706-02 - 12/04/06
- A/C - Inoperative/Low Cooling/DTC's 00819/00229
- 8707-11 - 08/28/07
- A/C - Unpleasant Odors From Vents After Sitting Unused
- A/C - Unpleasant Odors From Vents
- A/C - Musty/Mildew Odors
- A/C - Musty Odors From Vents
- A/C - Climatic Controls Operation
- 8707-08 - 07/26/07
- A/C - Does Not Cool/Compressor Seized
- A/C - Front Center Air Outlet Rattles (Canada)
- A/C - Front Center Air Outlet Rattles
- Steering - Adaptation Required After Parts Replacement
- Steering - Adaptation After Replacing Parts
- Steering - Adaptation After Parts Replacement
- Electrical - Various Electrical Conerns
- Electrical - Various Electrical Concerns
- Electrical - Battery Charging And Testing Information
- Electrical - Battery Charging and Testing Information
- Electrical - Battery Testing/Charging Information
- Electrical -Diagnosis for Excessive Static Current Draw
- Electrical - Battery Testing/Charging Procedures
- Battery - Current Draw Information
- Electrical - Battery Drain/No Start/Low Battery Codes
- Battery - Testing Procedures
- Electrical - Battery Testing and Charging Information
- Brakes - Abnormal Vibration When Braking
- Brakes - Vibration/Pulsation Upon Application
- Brakes - Brake Pedal Pulsation/Vibration
- Brakes - Abnormal Vibration When Braking
- Brakes - Pedal Pulsation/Vibration When Braking
- Brakes - Pedal Pulsation/Body/Steering Wheel Vibration
- Brakes - Pulsation Upon Highway Speed Application
- Brakes - Vibration Upon Brake Application
- Brakes - Vibration Upon Braking
- Brakes - Vibration While Braking
- Brakes - Vibration During Braking
- A/T - Direct Shift Gearbox (DSG) Delay On Acceleration
- Fuel System - Rattling Under Passenger Side Floor
- Fuel System - Passenger Floor/Dash Area Rattles
- Fuel System - Fuel Neutralization Procedure
- Emissions- EVAP System DTC Diagnostic Information
- Ignition System - MIL ON/Multiple Misfire DTCs Are Set
- Ignition System - MIL ON/Misfire DTC's Stored in ECM
- Computers/Controls - Management Of Software Versions
- 0108-30 - 10/24/08
- Emissions - Evaporative (EVAP) Emissions DTC Information
- Engine Controls - Cold Start Exhaust Noise/DTC P3081
- Fuel System - Fuel Quality Information
- Engine Controls - MIL ON/DTC's P001, P000A Stored
- Fuel System - Fuel Quality Information
- Computers/Controls - Software Version Management
- Emissions - EVAP System DTC Diagnosis
- Engine Controls - DTC P3081 Stored
- Air Bag System - Warning Lamp ON/DTC's 01217 / 01218
- Fuel System - Poor Fuel Quality Affecting Performance
- 0108-21 - 08/19/08
- Computers/Controls - Engine No Start/No Crank
- Engine Controls - Avoiding Unnecessary ECM Replacement
- Engine Controls - Exhaust Popping Noises (Canada)
- Engine Controls - Exhaust Popping Noise On Cold Start Up
- Engine Controls - Exhaust Noise On Cold Start Up
- Emissions - Catalytic Converter Replacement Guidelines
- Emissions - Catalytic Converter Replacement Guideline
- Body - Underbody Heat Shield Information
- Cooling System - Cooling Fans Run With Ignition Off
- Cooling System - Cooling Fans Run After Ign. Turned Off
- Engine - Replacement Precautions
- Cooling System - Coolant Staining Around Water Pump Area
- Engine Controls - Silicone Based Sealant/Lubricant Info.
- Engine - Oil Consumption Measurement
- Engine - Oil Filler Cap Comes Apart
- Engine - Oils Meeting Manufacturer Standards
- 1707-14 - 10/12/07
- Engine - Oils Meeting Standard VW502 00 And VW 50501
- A/C - Rear Window Defogger is Inoperative
- Tire Monitor System - System Overview
- Engine - Oil Meeting Specification VW 502 00/VW 505 01
- Tire Pressure Monitor - TPMS System Overview
- A/C - Unpleasant/Musty odors
- 1707-15 - 12/21/07
- Engine - VW Oil Standards 502 00/505 01/504 00/507 00
- Engine - Oils Meeting VW Standards
- 8708-06 - 09/16/08
- A/C - A/C Flushing Procedure
- Engine - Oils Meeting Manufacturer's Standard
- Engine - Measurement Of Oil Consumption
- All Technical Service Bulletins
- Body - Underhood Not Painted Body Color
- Paint - Swirl Mark/Fine Scratch Removal
- Keyless Start System - Engine No Start/No Crank
- A/C - System Flushing Information
- Emissions - Catalytic Converter Replacement Guideline
- Cooling System - Coolant ID/Mixing/Improved Coolant
- Electrical - Battery Charging And Testing Information
- Body - Upper Wheel Opening Front Fender Corrosion
- A/C - Unpleasant Odors Coming From Vents
- Cooling System - Cooling Fans Run With Ignition Off
- Wipers/Washers - Windshield Wipers Streak Or Smear
- Body/Interior - Squeak And Rattle Kit Available
- Navigation - Map Purchase And Update Information
- Engine Controls- Diag. Misfire After Campaign 28F/P1
- Electrical - Diagnosis for Excessive Static Current Draw
- Lighting - Exterior Light Moisture Accumulation
- Audio System - Antenna Diagnostic Overview
- Body - Front Doors Damaged By Ice Formation
- Audio System - CD Player Diagnostic Overview
- Electrical - Lock/Window/Fuel Door Switches Inoperative
- Interior - Front Center Armrest Cover Will Not Close
- Direct Shift Gearbox (DSG) - Delay On Acceleration
- Engine Controls - Noise After Cold Start And DTC P3081
- Brakes - Vibration/Pulsation Upon Application
- Engine - Measurement Of Oil Consumption
- Restraints - Air Bag Lamp ON/DTC 02511 014 Stored
- Suspension - Front Suspension Creaking Noises
- Recall 10V621000: Fuel Supply Line Replacement
- Vehicle - Certification Label/VIN Plate Ordering
- Computers/Controls - Various Control Modules With DTC's
- Audio System - Poor Radio Reception
- Instruments - Service Reminder Indicator Reset Procedure
- Engine - Oil Consumption Guidelines
- Campaign - Poor Radio Reception When Cold/Hot
- Campaign - Ground Connection Inspection
- Steering - DSR Activation And Programming Procedure
- Engine Controls - Wrong Cylinder Defined For Misfire DTC
- Interior - Rear Door Panels Rattle From Audio Bass
- Audio/Interior - Door Panel Rattles With Bass
- Audio/Interior - Rear Door Panels Rattle With Bass
- Windshield Wipers - Smear or Streak Windshield
- Wipers - Windshield Wipers Streak or Smear Windshield
- Body - Fuel Tank Lid (Fuel Door) Does Not Close
- M/T - Humming Noise When Turning at Low Speeds
- Interior - Headliner/Grab Handle/Sun Visor Installation
- Engine Controls - DTC's 00545/00638 Stored
- Navigation System - Various System Errors
- Airbag - Deployed Airbag Repair
- Air Bag System - Description, Passenger Side Air Bag
- Computers/Controls - No Communication With Scan Tools
- A/T - High Launch RPM's/DTC P0716/P0740
- Washer System - Washer Jets (Front or Rear), Restricted
- Lighting - Water Intrusion Into Tail Lamps
- Interior - Rear Arm Rest Lock Cylinder Noisy (Canada)
- A/T Gear Indicator Flashes/Engine RPM Fluctuation
- Audio System - Poor Reception/Volume Fades
- Audio System - CD Player Jams/Magazine Won't Eject
- Windshield Wipers - One Intermittent Sweep
- Instruments - Trip Computer Fuel Mileage Information
- Engine Controls - MIL ON/DTC's P001, P000A Set
- Fuel System - Rattle From Front Passenger Floor Area
- Recall 07V284000: Potential Fuel Line Chafing/Leakage
- Fuel System - Fuel Tank Ground Strap Installation
- Engine Controls - Scan Tool Displays Incorrect Values
- Campaign - Engine Wiring Harness Inspection/Update
- Wipers/Washers - Insufficient Washer Nozzle Spray
- Audio System - Poor AM/FM Band Radio Reception
- Engine - Oil Filler Cap Separation
- Engine - Oil Drain Plug Thread Cleaning
- Instruments - Speedometer Reads Too Fast
- Body - Driver's Door Lock Cylinder Inoperative (Canada)
- Body - Door Windows Separate From Regulator Clamps
- A/C - Rear Window Defogger Inoperative
- A/C - No Cooling/Compressor Seized
- Suspension - Rear Suspension is Noisy
- Interior - Cleaning Tips for Leather Upholstery
- Body - Sunroof Malfunctions or is Inoperative
- M/T, A/T - Knocking Noise Under Load
- Engine Controls - Avoiding Unnecessary ECM Replacement
- Engine Controls - Exhaust Noise/DTC's P0011/P000A
- Emissions - Possible MIL ON/Cat Converter DTC's Set
- A/T - Won't Shift Out of PARK/DTC's U0101/28773/01315
- Recall 07V442000: Headlamp Adjustment Non-Compliance
- Body - Fuel Door Will Not Close
- Body - Fuel Door Does Not Close
- Audio System - Antitheft Code Retrieval/Entering
- Body - Door Lock Rotary Switch Diagnostic Aid
- A/T - Fluid Leaking Between Case Halves
- A/C - Poor Performance/Insufficient Cooling
- A/C - Front Center Air Outlet Rattles (U.S. Only)
- A/C - Front Center Air Outlet Rattles (Canada Only)
- Body - Front/Rear Door Seals Detached
- A/C - Blower Motor Operates On High Only
- A/C - Does Not Get Cold Enough
- A/C - Seat Heater is Inoperative
- Interior - Front Seat Creaking/Cracking Noises
- Tire Monitoring System - System Overview
- Electrical - Driver's Window/Lock Switches Inoperative
- Electrical - Dome/Sun Visor Lamps Inoperative
- Suspension - Front Suspension Creaking Noise
- Restraints - Air Bag Lamp ON/DTCs 01217/01218 Set
- Engine - Component Inspection During Engine Replacement
- Engine Controls - Silicone Sealer/Lubricant Precautions
- Instruments - Cruise Control is Inoperative
- Restraints - Air Bag Color Code ID And Coding
- Wipers/Washers - Smearing/Streaking (Canada)
- Steering - Sensor Can't Be Adapted When Replacing Module
- Interior - Cleaning Tips for Vinyls/Plastics/Fabrics
- Audio System - Radio Part Number Interpretation
- A/C - Poor Performance/Blows Warm Air/DTC's Set
- A/C - Seat Heater Inoperative/Erratic Operation
- Exhaust System - Heat Shield Replacement Guidelines
- Steering - Adaptation Required After Part Replacement
- Fuel System - Neutralizing Fuel For Fuel Tank Disposal
- A/T - 'PRNDS' Indicator ON/DTC's Set/Emergency Mode
- Body - Rear Door Leading Edge Paint Wear
- Computers/Controls - Control Module Testing Information
- Keyless Entry/Starting - Remote Key Inoperative
- Interior - Cleaning Tips Fabrics, Vinyls And Plastics
- Cooling System, A/C - Poor Heater Output
- Recall - Inspect/Replace Fuel Supply Line Clamp
- Recall - Fuel Supply Line Clamp Inspection/Replacement
- Navigation Radio - Multiple Malfunctions
- Interior - Rear Cup Holder Sticks/Hard To Remove
- Fuel System - Fuel Related Driveability Issues
- Audio System - Bass Flare/Poor Radio Reception
- Audio System - Aux Devices Inop After Radio Replacement
- Instruments - No Menu Using Steering Wheel Buttons
- A/C - Climate Control Operation Information
- Steering - Update Software After Part Replacement
- Cruise Control - SET/RES Intermittent, Won't Activate
- Lighting - HID Headlamp DTC's 01534 Or 01535
- Body - Under Hood Paint Doesn't Match Exterior (Canada)
- Immobilizer System - Active/DTC's P0513/1177
- Audio System - Auxiliary Jack/iPod(R)/CD Changer Inop.
- Cooling System - Coolant Identification/Mixing
- Computers/Controls - Software Version Management Info.
- Navigation Radio - Radio Repair Program
- Charging System - No Start/Generator Lamp Flashing
- Emissions - Interim Repair For Recall 28F3
- Interior - Rear Arm Rest Won't Fold Down
- Audio System - Entering/Retrieving Anti-Theft Code
- Electrical - One Or More Back Glass Defroster Grids Inop
- Cell Phone - Bluetooth(R) Retrofit Kit
- Charging Sys/Lighting - Headlamps Dim At Idle
- Restraints - Child Restraint LATCH(R) Compliance
- Audio/Navigation - Antenna Diagnostics Overview
- Electrical - Ground Connection Verification Test
- Audio System - Radio And External Device Overview
- Interior - Fuel Door Switch Falls Into Driver Door Panel
- Ignition System - MIL ON/DTC's P0300-P0312 Stored
- Cooling System - Coolant Staining Around Water Pump Area
- Emissions - EVAP System DTC Diagnostic Information
- Engine - Oils Meeting Manufacturer's Standard
- Audio System - Satellite Radio System Overview