Sunroof With Glass Panel Overview

Sunroof with Glass Panel Overview






1 Sunroof Glass Panel

One-Piece Safety Glass

• Sunroof glass panel, removing and installing, refer to => [ Sunroof Glass Panel ] Service and Repair.

• Sunroof glass panel, adjusting, refer to => [ Sunroof Glass Panel Height, Adjusting ] Sunroof Glass Panel Height, Adjusting.

2 Panel Seal

• Adjusting panel seal, refer to => [ Panel Seal, Adjusting ] Adjustments.

• Seal joint at center in rear area.

• Panel Seal, Replacing, refer to => [ Panel Seal, Replacing ] Service and Repair.

3 Sun Shade

• Sun shade, removing and installing, refer to => [ Sun Shade ] Service and Repair.

4 Bolt

• 1.8 Nm

• Screws are microencapsulated and must always be replaced after removing.

• Quantity: 4

5 Spring Glider

• Attached to the sun visor.

• Quantity: 4

• can be replaced separately.

6 Bellows

• For covering slotted guide rail.

7 Water Channel

8 Guide Locking Hook

• removed together with slotted rail.

9 End Piece, Upper Part

• Clipped to lower part of end piece.

10 End Piece, Lower Part

• Can be replaced separately.

• Use a (AKL 450 005 05) for sealing.

11 Installation Unit

• Removing and installing installation unit. Refer to => [ Installation Unit ] Installation Unit.

• If necessary use special grease G 000 450 02 exclusively to grease guide channels, otherwise the functions cannot be guaranteed.

12 Bolt

• 3.5 Nm

• Screws are microencapsulated and must always be replaced after removing.

• quantity: 3

13 Emergency Operation Hex Key

• The hex wrench the emergency operation has been discontinued. Use a commercially available hex wrench.

14 Electrical Drive Motor

• Removing, refer to => [ Sunroof Glass Panel Drive ] Service and Repair.

• Drive Motor, Neutral Position, Adjusting, refer to => [ Sunroof Glass Panel Drive Zero Position, Adjusting ] Sunroof Glass Panel Drive Zero Position, Adjusting.

15 Spring

• Quantity: 2

• To open wind deflector.

• Clipped inside the wind deflector and cannot be replaced individually.

• Removing, refer to => [ Wind Deflector ] Wind Deflector.

16 Wind Deflector

• Removing, refer to => [ Wind Deflector ] Wind Deflector.

• Adjusting, refer to => [ Wind Deflector, Adjusting ] Adjustments.

• The adjustable wind deflector should not be retrofitted.

• Some wind deflectors have balance weights. This can be retrofitted.

17 Wind Deflector Bearing

• Quantity: 2

• Clipped inside the wind deflector and cannot be replaced individually.

• Removing, refer to => [ Wind Deflector ] Wind Deflector.

18 Front Guide

• Can be slid individually out of guide rail.

19 Rear Guide, Lower Part

• Removed together with slotted guide rail.

20 Bolt

• 5 Nm

• TORX T25

• 3 pieces per side

21 Slotted Guide Rail

• Removing and installing, refer to => [ Slotted Guide Rail ] Slotted Guide Rail.

22 Spacer

• Removing and installing, refer to => [ Slotted Guide Rail ] Slotted Guide Rail.