Heating Components Overview

Heating Components Overview

Disconnect the battery before removing components marked with a **.






1 Dash Panel **

2 Center Vents

• Removing vents, refer to => [ Center Vent ] Center Vent.

3 Passenger Vent

• Removing vents, refer to => [ Driver or Passenger Vents ] Driver or Passenger Vents.

4 Fresh Air and Heated Air Controls

• With Fresh air/recirculating door switch (E159).

• Also with Immediate heating button (E537) in vehicles with an auxiliary heater.

• Removing controls, refer to => [ Heat and Fresh Air Controls ] Heat and Fresh Air Controls.

• On vehicles with heated seats also with Heated driver seat adjuster (E94) and Heated front passenger seat adjuster (E95).

5 Fresh/Recirculating Air Door Motor (V154)

• Removing and installing, refer to => [ Fresh/Recirculating Air Door Motor (V154) ] Fresh/Recirculating Air Door Motor (V154).

6 Right Footwell Vent

• Removing and installing, refer to => [ Right Footwell Vent ] Right Footwell Vent.

7 Fresh Air Blower (V2)

• Removing and installing, refer to => [ Fresh Air Blower (V2) ] Service and Repair.

8 Fresh Air Blower Series Resistor With Fuse (N24)

• Removing and installing, refer to => [ Fresh Air Blower Series Resistor With Fuse (N24) ] Service and Repair.

9 Heater Partition

• Removing and installing, refer to => [ Heater Partition ] Heater Partition.

10 Sealing Caps

• Only in vehicles without air duct to vent installed in center console at rear.

11 Air Guide

• Disassemble the center console in order to remove it. Refer to Storage Compartments, Covers and Trim.

12 Dust and Pollen Filter

• With EVAP canister.

• Removing and installing, refer to => [ Dust and Pollen Filter ] .

13 Connection

• For the center console air duct.

• Disassemble the center console in order to remove it. Refer to Storage Compartments, Covers and Trim.

14 Air Outlet Grille

• Depending on vehicle equipment.

15 Rear Channel For Right Footwell

• Removing and installing, refer to => [ Rear Footwell Channel ] Rear Footwell Channel.

16 Rear Channel For Left Footwell

• Removing and installing, refer to => [ Rear Footwell Channel ] Rear Footwell Channel.

17 Screw

• Quantity: 8

18 Adapter For Controls

19 Heater Core

• Replace all the coolant after replacing the heater core.

• Removing and installing, refer to => [ Heater Core ] Heater Core.

20 Left Footwell Vent

• Removing and installing, refer to => [ Left Footwell Vent ] Left Footwell Vent.

21 Bowden Cable For Temperature Door

• Removing and installing, refer to => [ Temperature Door Release Cable ] Service and Repair.

22 Flexible Shaft

• Removing and installing, refer to => [ Flexible Air Distribution Shaft ] Flexible Air Distribution Shaft.

23 Heater Unit

• Removing and installing, refer to => [ Heater Unit ] Heater Unit.

• Disassembling and assembling, refer to => [ Heater Unit ] Heater Unit.

Installation Position Of Seal For Heater and Engine Compartment





- First insert the seal into the plenum chamber bulkhead between the heater and engine compartment - A - and then place on the heater core.

• To prevent water from entering vehicle interior, note the installation position.