Passenger Compartment Climatronic
Passenger Compartment Climatronic
• Disconnect the battery before removing components marked with a **.
• A data plate on the lock carrier indicates the refrigerant used and capacity.
1 Dash Panel **
2 Sunlight Photo Sensor (G107) or Sunlight Photo Sensor 2 (G134)
• Checking: use the Vehicle Diagnostic Tester.
• Controls temperature door and fresh air blow depending on light intensity.
• Emergency running in the event of failure: the Climatronic control module (J255) utilizes a fixed value.
• Removing and installing, refer to => [ Sunlight Photo Sensors (G107)/(G134) ] Sunlight Photo Sensors (G107)/(G134).
3 Center Vents
• Removing, refer to => [ Center Vent ] Center Vent.
4 Air Outlet
• Removing, refer to => [ Driver and Passenger Side Vents ] Driver and Passenger Side Vents.
5 Right Vent Temperature Sensor (G151)
• Checking: use the Vehicle Diagnostic Tester.
• Removing and installing, refer to => [ Right Vent Temperature Sensor (G151) ] Right Vent Temperature Sensor (G151).
6 Front A/C Display Control Head (E87) with Climatronic Control Module (J255) , Through 18 May 2008
• The Climatronic Control Module and the Front A/C Display Control Head are one component that cannot be disassembled.
• Checking: use the Vehicle Diagnostic Tester.
• Removing and installing, refer to => [ Front A/C Display Control Head (E87)/(J255) ] Front A/C Display Control Head (E87)/(J255).
• Replacing: perform a basic setting using the Vehicle Diagnostic Tester. Refer to=> [ Checking and Adjusting Components ] Checking and Adjusting Components.
7 Front A/C Display Control Head (E87) with Climatronic Control Module (J255) , From 25 May 2008
• The Climatronic Control Module and the Front A/C Display Control Head are one component that cannot be disassembled.
• Checking: use the Vehicle Diagnostic Tester.
• Removing and installing, refer to => [ Front A/C Display Control Head (E87)/(J255) ] Front A/C Display Control Head (E87)/(J255).
• Replacing: perform a basic setting using the Vehicle Diagnostic Tester. Refer to=> [ Checking and Adjusting Components ] Checking and Adjusting Components.
8 Air Flow Door Motor (V71)
• Checking: use the Vehicle Diagnostic Tester.
• Removing and installing, refer to => [ Air Flow Door Motor (V71) with Back Pressure Door Motor Position Sensor (G113) ] Air Flow Door Motor (V71) with Back Pressure Door Motor Position Sensor (G113).
• Replacing: perform a basic setting using the Vehicle Diagnostic Tester. Refer to=> [ Checking and Adjusting Components ] Checking and Adjusting Components.
9 Recirculation Door Motor (V113)
• Checking: use the Vehicle Diagnostic Tester.
• Removing and installing, refer to => [ Fresh/Recirculating Air Door Motor (V154) ] Fresh/Recirculating Air Door Motor (V154).
• Replacing: perform a basic setting using the Vehicle Diagnostic Tester. Refer to=> [ Checking and Adjusting Components ] Checking and Adjusting Components.
10 Right Footwell Vent
• Removing and installing, refer to => [ Right Footwell Vent ] Right Footwell Vent.
11 Fresh Air Blower (V2) with Fresh Air Blower Control Module (J126)
• The fresh air blower control module and the fresh air blower are in a single housing together and cannot be replaced individually.
• Checking: use the Vehicle Diagnostic Tester.
• Removing and installing, refer to => [ Fresh Air Blower (V2)/Fresh Air Blower Control Module (J126) ] Fresh Air Blower (V2)/Fresh Air Blower Control Module (J126).
12 Connector
13 Heating Unit Partition
• Removing, refer to=> [ Partition ] Service and Repair.
14 Cap
• Only in vehicles without air duct to vent installed in center console at rear.
15 Dust and Pollen Filter
• With EVAP canister.
• Removing and installing, refer to => [ Dust and Pollen Filter ] Service and Repair.
16 Air Outlet Grille
17 Rear Channel For Right Footwell
• Removing and installing, refer to => [ Rear Footwell Channel ] Rear Footwell Channel.
18 Rear Channel For Left Footwell
• Removing and installing, refer to => [ Rear Footwell Channel ] Rear Footwell Channel.
19 Evaporator Vent Temperature Sensor (G263) or Evaporator Temperature Sensor (G308)
• Checking: use the Vehicle Diagnostic Tester.
• Removing and installing, refer to => [ Evaporator Vent or Evaporator Temperature Sensor (G263)/(G308) ] Evaporator Vent or Evaporator Temperature Sensor (G263)/(G308).
20 Right Temperature Door Motor (V159)
• Checking: use the Vehicle Diagnostic Tester.
• Removing and installing, refer to => [ Right Temperature Door Motor (V159) ] Right Temperature Door Motor (V159).
• Replacing: perform a basic setting using the Vehicle Diagnostic Tester. Refer to=> [ Checking and Adjusting Components ] Checking and Adjusting Components.
21 Heater Core
• Removing and installing, refer to => [ Heater Core ] Service and Repair.
22 Auxiliary Heater Heating Element (Z35)
• Only installed on vehicles with Diesel engine.
23 Central Air Door Motor (V70)
• Checking: use the Vehicle Diagnostic Tester.
• Removing and installing, refer to => [ Central Air Door Motor (V70) ] Central Air Door Motor (V70).
• Replacing: perform a basic setting using the Vehicle Diagnostic Tester. Refer to=> [ Checking and Adjusting Components ] Checking and Adjusting Components.
24 Left Footwell Vent
• Removing and installing, refer to => [ Left Footwell Vent ] Left Footwell Vent.
25 Left Temperature Door Motor (V158)
• Checking: use the Vehicle Diagnostic Tester.
• Removing and installing, refer to => [ Left Temperature Door Motor (V158) ] Left Temperature Door Motor (V158).
• Replacing: perform a basic setting using the Vehicle Diagnostic Tester. Refer to=> [ Checking and Adjusting Components ] Checking and Adjusting Components.
26 Left Footwell Vent Temperature Sensor (G261)
• Checking: use the Vehicle Diagnostic Tester.
• Removing, refer to => [ Left Footwell Vent Temperature Sensor (G261) ] Left Footwell Vent Temperature Sensor (G261).
27 Defroster Door Motor (V107)
• Checking: use the Vehicle Diagnostic Tester.
• Removing and installing, refer to => [ Defroster Door Motor (V107) ] Defroster Door Motor (V107).
• Replacing: perform a basic setting using the Vehicle Diagnostic Tester. Refer to=> [ Checking and Adjusting Components ] Checking and Adjusting Components.
28 Heating and A/C Unit
• Removing and installing, refer to => [ Heating and A/C Unit ] Heating and A/C Unit.
• Disassembling and assembling, refer to=> [ Climatronic Heater and A/C Unit ] Climatronic Heater and A/C Unit.
29 Right Footwell Vent Temperature Sensor (G262)
• Checking: use the Vehicle Diagnostic Tester.
• Removing, refer to => [ Right Footwell Vent Temperature Sensor (G262) ] Right Footwell Vent Temperature Sensor (G262).
30 Left Vent Temperature Sensor (G150)
• Checking: use the Vehicle Diagnostic Tester.
• Removing, refer to=> [ Right Vent Temperature Sensor (G151) ] Right Vent Temperature Sensor (G151).