Engine, Installing
Engine, Installing
Install in the reverse order of removal. Note the following:
Servicing the clutch
- Make sure the alignment sleeves for centering the engine/transmission are installed in the cylinder block. Install them if necessary.
- When installing the "engine/transmission subassembly", make sure there is enough clearance around the subframe and the radiator.
- Adjust the engine/transmission mounts. Refer to => [ Engine/Transmission Mount, Adjusting ] Adjustments.
• Engine/transmission mount bolt tightening specifications, refer to => [ Fastener Tightening Specifications ] Engine Assembly - Fastener Tightening Specifications
with a Manual Transmission
- Install the hose/line assembly or pipe to the hydraulic clutch.
- Install the shift mechanism to the transmission and adjust it, if necessary.
Vehicles with a DSG(R)
- Install the selector lever cable to the transmission and adjust it, if necessary.
Continuation for All
• Make sure the particulate filter is free of tension when it is installed.
• Replace the self-locking nuts, the seals, gaskets and clamps.
Danger of causing damage to the coupling element behind the particulate filter. When removing and installing:
• Do not bend the coupling element more than 10°.
• Do not stretch the coupling element.
• Do not damage the wire mesh on the coupling element.
Install the particulate filter. Refer to => [ Particulate Filter with NOx Absorption Catalytic Converter ] Service and Repair.
- Install the drive axles at the transmission.
- Install the right drive axle heat shield and bolts - arrows -.
- Install the lock carrier.
- Install the refrigerant lines to the Air Conditioning (A/C) compressor and condenser without tension.
- Charge the A/C system.
- Install the battery tray and the battery.
- Observe the notes after connecting the battery.
- Fill with coolant. Refer to => [ Coolant, Draining and Filling ] Procedures.
- Fill/bleed the fuel system. Refer to => [ Fuel System, Filling/Bleeding ] Fuel System, Filling/Bleeding.
- Check the Diagnostic Trouble Code (DTC) memory of each control module. Erase all of the DTC entries that might have occurred during the assembly. Refer to the vehicle diagnostic tester.
- Check the headlamp adjustment and adjust, if necessary.
Tightening Specifications
• 1 M12 collar bolt tightening specification: 75 Nm