DTC 82-1

DTC 82-1: Right Search Coil Sensor (Open or Short)

NOTE: Before you troubleshoot, review the general troubleshooting information.

1. Disconnect SH-AWD control unit connector A (20P).
2. Check for continuity between SH-AWD control unit connector terminals A3 and Al2.





Is there continuity?

YES - Go to step 3.

NO - Go to step 6.

3. Check the REAR DIFFERENTIAL FLUID TEMPERATURE in the DATA LIST is above 68°F (20°C) with the HDS before proceeding to the next step. If the temperature is below 68°F (20°C), drive the vehicle to warm up the rear differential until the fluid temperature becomes above 68°F (20°C).
4. Measure resistance between SH-AWD control unit connector terminals A3 and Al2.





Is there 2.0 Ohms or more?

YES - Go to step 5.

NO - Go to step 7.

5. Check for continuity between SH-AWD control unit connector terminal A3 and body ground.





Is there continuity?

YES - Repair short in the wire between SH-AWD control unit connector terminal A3 and body ground.

NO - Check for loose connector terminals at the SH-AWD control unit and repair if necessary. If the connections are OK, update the SH-AWD control unit if it does not have the latest software, or substitute a known-good SH-AWD control unit and recheck. If the symptom/indication goes away with the updating SH-AWD control unit, troubleshooting is complete. If the symptom/indication goes away with a known-good SH-AWD control unit, replace the original SH-AWD control unit.

6. Connect a jumper wire between SH-AWD control unit connector terminals A3 and Al2. Disconnect the right solenoid 4P connector, then check for continuity between right solenoid 4P connector terminals No. 3 and No. 4.








Is there continuity?

YES - Replace the rear differential right side case.

NO - Repair open in the wires between right solenoid 4P connector terminals No. 3 and No. 4.

7. Disconnect the right solenoid 4P connector, then check for continuity between right solenoid 4P connector terminals No. 3 and No. 4.





Is there continuity?

YES - Repair short to ground in the wires between SH-AWD control unit connector A and the right search coil sensor connector.

NO - Replace the rear differential right side case.