Operation CHARM: Car repair manuals for everyone.

Right Catalytic Converter, With Automatic Transmission






Right Catalytic Converter, with Automatic Transmission

Special tools, testers and auxiliary items required

Engine/Transmission Jack (V.A.G 1383 A)

Transmission Support (T10337)

Scissor-Type Assembly Platform (VAS 6131 A)

Removing






- Remove the right front muffler. Refer to => [ Front Muffler ] Front Muffler.

- Remove the Heated Oxygen Sensor (HO2S) (G39) and Oxygen Sensor (O2S) after Three Way Catalytic Converter (TWC) (G130).


The suspension components could be damaged.

Do not rest the vehicle on its wheels if the subframe mount, the steering gear or the subframe crossbrace are not installed correctly.

Do not support the vehicle on the subframe or the subframe crossbrace (for example by a floor jack or similar device).

- Remove the subframe crossbrace.






- Position the (T10337) on the (V.A.G 1383 A).






- Position the (T10337) on the bottom of the transmission.

- Lift the transmission slightly using the (V.A.G 1383 A).


There is the risk of an accident.

The (V.A.G 1383 A) may only be used during assembly and must not sit unsupervised under the vehicle.

- Remove the bolts from the tunnel crossmember - arrows -.






- Next lower engine/transmission subassembly with (VAS 6131 A) only by dimension - a -.






Dimension - a - = 35 mm maximum.

- Remove the nuts - arrows - and the bolt - 1 - and the right catalytic converter.






Installing

Install in reverse order, paying attention to the following:

Tightening specification, refer to => [ Muffler Overview ] Muffler Overview.

Replace seals and self-locking nuts.

- Install the Heated Oxygen Sensor (HO2S) (G39) and Oxygen Sensor (O2S) after Three Way Catalytic Converter (TWC) (G130).

- Install the right front muffler. Refer to => [ Front Muffler ] Front Muffler.

- Install exhaust system free of stress. Refer to => [ Exhaust System, Installing ] Service and Repair.

- Install the subframe crossbrace, upper control arm and stabilizer bar and tighten the suspension strut on the control arm.