Installation

SEAT BELT: REAR NO. 1 SEAT OUTER BELT ASSEMBLY: INSTALLATION

1. INSTALL REAR NO. 1 SEAT OUTER BELT ASSEMBLY

(a) Install the rear No. 1 seat outer belt assembly with the 2 bolts.






Bolt [A] - Torque : 7.5 Nm (77 kgf-cm, 66 in-lbf)


Bolt [B] - Torque : 42 Nm (428 kgf-cm, 31 ft-lbf)

(b) Connect the shoulder anchor of the rear No. 1 seat outer belt assembly with the bolt.





Torque : 42 Nm (428 kgf-cm, 31 ft-lbf)

(c) Check if the ELR locks.

NOTICE:
The check should be performed with the outer belt assembly installed.

(1) With the belt assembly installed, check that the belt locks when it is pulled out quickly.

2. INSTALL QUARTER PILLAR GARNISH Installation

3. INSTALL DECK TRIM SIDE PANEL ASSEMBLY LH (for LH Side) Installation

4. INSTALL DECK TRIM SIDE PANEL ASSEMBLY RH (for RH Side) Installation

5. CONNECT REAR NO. 1 SEAT OUTER BELT ASSEMBLY

(a) Connect the floor anchor end of the rear No. 1 seat outer belt assembly and install the bolt.





Torque : 42 Nm (428 kgf-cm, 31 ft-lbf)

NOTICE:
Do not allow the anchor part of the rear No. 1 seat outer belt assembly to overlap the protruding part of the floor panel.

6. INSTALL FRONT DECK SIDE TRIM COVER LH Installation

7. INSTALL FRONT DECK SIDE TRIM COVER RH Installation

8. INSTALL NO. 2 DECK SIDE TRIM HOOK (for LH Side) Installation

9. INSTALL NO. 1 LUGGAGE COMPARTMENT TRIM HOOK (for RH Side) Installation

10. INSTALL ROPE HOOK ASSEMBLY Installation

11. INSTALL RECLINING REMOTE CONTROL LEVER BEZEL LH (for LH Side) Installation

12. INSTALL REAR POWER OUTLET SOCKET COVER (for LH Side) Installation

13. INSTALL REAR POWER POINT SOCKET ASSEMBLY (for LH Side) Installation

14. INSTALL REAR COMBINATION LIGHT SERVICE COVER LH (for LH Side) Installation

15. INSTALL REAR COMBINATION LIGHT SERVICE COVER RH (for RH Side) Installation

16. INSTALL SIDE TRIM COVER RH (for Manual Air Conditioning System) Installation

17. INSTALL REAR ROOM TEMPERATURE SENSOR (for Automatic Air Conditioning System) Installation

18. INSTALL SIDE TRIM COVER LH (for LH Side without Rear Seat Entertainment System) Installation

19. INSTALL POWER OUTLET SOCKET BEZEL (for LH Side with Rear Seat Entertainment System) Installation

20. INSTALL DECK SIDE TRIM LH Installation

21. INSTALL DECK SIDE TRIM RH Installation

22. INSTALL DECK SIDE TRIM COVER LH Installation

23. INSTALL DECK SIDE TRIM COVER RH Installation

24. INSTALL REAR SEAT SIDE GARNISH CAP Installation

25. INSTALL REAR FLOOR FINISH PLATE Installation

26. INSTALL REAR NO. 2 SEAT ASSEMBLY Installation

27. CONNECT REAR NO. 2 SEAT OUTER BELT ASSEMBLY LH Installation

28. CONNECT REAR NO. 2 SEAT OUTER BELT ASSEMBLY RH Installation

29. INSTALL REAR NO. 2 SEAT INNER BELT ASSEMBLY Installation

30. INSTALL REAR DECK FLOOR BOX Installation

31. INSTALL REAR MAT Installation

32. INSTALL DECK SIDE TRIM BOX RH Installation

33. INSTALL JACK CARRIER ASSEMBLY Installation

34. INSTALL JACK ASSEMBLY Installation

35. INSTALL JACK CARRIER CUSHION Installation

36. INSTALL JACK CARRIER SUPPORT Installation

37. INSTALL NO. 1 DECK BOARD Installation

38. INSTALL NO. 2 DECK BOARD Installation

39. INSTALL NO. 2 DECK BOARD SUB-ASSEMBLY Installation

40. CONNECT REAR DOOR OPENING TRIM WEATHERSTRIP

41. INSTALL REAR DOOR SCUFF PLATE Installation

42. INSTALL REAR NO. 1 SEAT ASSEMBLY Installation

43. CONNECT REAR NO. 1 SEAT LOCK CABLE ASSEMBLY Installation

44. INSPECT REAR SEAT SLIDE ADJUSTER LOCK Installation

45. INSTALL REAR SEAT LEG SIDE COVER RH (for RH Side) Installation

46. INSTALL REAR SEAT LEG SIDE COVER LH (for LH Side) Installation

47. INSTALL RECLINING HINGE COVER LH (for LH Side) Installation

48. INSTALL REAR INNER TRACK BRACKET COVER Installation

49. INSTALL REAR OUTER TRACK BRACKET COVER Installation

50. INSTALL REAR SEAT TRACK BRACKET COVER Installation

51. INSTALL REAR SEAT HEADREST ASSEMBLY Installation

52. INSTALL REAR CENTER SEAT ASSEMBLY (for LH Side)

53. CONNECT CABLE TO NEGATIVE BATTERY TERMINAL

NOTICE:
When disconnecting the cable, some systems need to be initialized after the cable is reconnected Repair Instruction - Initialization.

54. INSTALL BATTERY SERVICE HOLE COVER ASSEMBLY Installation

55. INSTALL DECK BOARD ASSEMBLY Installation