Installation

SUPPLEMENTAL RESTRAINT SYSTEM: FRONT PASSENGER AIRBAG ASSEMBLY: INSTALLATION

1. INSTALL INSTRUMENT PANEL WIRE ASSEMBLY

(a) Connect the 2 airbag connectors.

NOTICE:
When handling the airbag connector, take care not to damage the airbag wire harness.

(b) Install the clamp and instrument panel wire assembly on the front passenger airbag assembly.

2. INSTALL FRONT PASSENGER AIRBAG ASSEMBLY

(a) Engage the 5 hooks.

(b) Install the front passenger airbag assembly with the 5 hooks on the instrument panel.

3. INSTALL NO. 4 HEATER TO REGISTER DUCT Reassembly

4. INSTALL INSTRUMENT PANEL SAFETY PAD ASSEMBLY (for Pole Antenna Type) Installation

5. INSTALL INSTRUMENT PANEL SAFETY PAD ASSEMBLY (for Glass Antenna Type) Installation

6. CONNECT INSTRUMENT PANEL WIRE ASSEMBLY

(a) Check that the ignition switch is off.

(b) Check that the battery negative (-) terminal is disconnected.

CAUTION:
Wait for at least 90 seconds after disconnecting the cable to prevent airbag deployment.

(c) Connect the connector.

7. INSTALL FRONT NO. 2 SPEAKER ASSEMBLY (for LH Side) Installation

8. INSTALL NO. 1 INSTRUMENT PANEL SPEAKER PANEL SUB-ASSEMBLY Installation

9. INSTALL FRONT NO. 2 SPEAKER ASSEMBLY (for RH Side)

HINT
Use the same procedure for the RH side and the LH side Installation.

10. INSTALL NO. 2 INSTRUMENT PANEL SPEAKER PANEL SUB-ASSEMBLY Installation

11. INSTALL FRONT PILLAR GARNISH RH Installation

12. CONNECT FRONT DOOR OPENING TRIM WEATHERSTRIP RH Installation

13. INSTALL FRONT PILLAR GARNISH LH Installation

14. CONNECT FRONT DOOR OPENING TRIM WEATHERSTRIP LH Installation

15. INSTALL ENGINE SWITCH (w/ Smart Key System)

16. INSTALL FRONT NO. 2 CONSOLE BOX INSERT Installation

17. INSTALL FRONT NO. 1 CONSOLE BOX INSERT Installation

18. INSTALL CONSOLE BOX ASSEMBLY (w/o Rear Air Conditioning System) Installation

19. INSTALL CONSOLE BOX ASSEMBLY (w/ Rear Air Conditioning System) Installation

20. INSTALL LOWER REAR CONSOLE BOX Installation

21. INSTALL NO. 2 CONSOLE BOX DUCT (w/o Rear Air Conditioning System) Installation

22. INSTALL UPPER CONSOLE PANEL SUB-ASSEMBLY Installation

23. INSTALL LOWER INSTRUMENT PANEL SUB-ASSEMBLY Installation

24. INSTALL NO. 2 INSTRUMENT PANEL UNDER COVER SUB-ASSEMBLY Installation

25. INSTALL COWL SIDE TRIM SUB-ASSEMBLY RH

HINT
Use the same procedure for the RH side and the LH side Installation.

26. INSTALL FRONT DOOR SCUFF PLATE RH

HINT
Use the same procedure for the RH side and the LH side Installation.

27. INSTALL LOWER INSTRUMENT PANEL FINISH PANEL SUB-ASSEMBLY (for Manual Air Conditioning System) Installation

28. INSTALL LOWER INSTRUMENT PANEL FINISH PANEL SUB-ASSEMBLY (for Automatic Air Conditioning System) Installation

29. INSTALL COWL SIDE TRIM SUB-ASSEMBLY LH Installation

30. INSTALL FRONT DOOR SCUFF PLATE LH Installation

31. INSTALL RADIO RECEIVER ASSEMBLY WITH BRACKET (w/o Navigation System) Installation

32. INSTALL NAVIGATION RECEIVER ASSEMBLY WITH BRACKET (w/ Navigation System) Installation

33. INSTALL HEATER CONTROL AND ACCESSORY ASSEMBLY (for Manual Air Conditioning System) Installation

34. INSTALL AIR CONDITIONING CONTROL ASSEMBLY (for Automatic Air Conditioning System) Installation

35. INSTALL CENTER INSTRUMENT CLUSTER FINISH PANEL ASSEMBLY (w/o Smart Key System) Installation

36. INSTALL CENTER INSTRUMENT CLUSTER FINISH PANEL ASSEMBLY (w/ Smart Key System) Installation

37. INSTALL CENTER INSTRUMENT PANEL REGISTER ASSEMBLY Installation

38. INSTALL COMBINATION METER ASSEMBLY Installation

39. INSTALL INSTRUMENT CLUSTER FINISH PANEL ASSEMBLY Installation

40. POSITION FRONT WHEELS STRAIGHT AHEAD

41. INSTALL TURN SIGNAL SWITCH ASSEMBLY WITH SPIRAL CABLE SUB-ASSEMBLY Installation

42. INSTALL STEERING COLUMN COVER Installation

43. ADJUST SPIRAL CABLE Installation

44. INSTALL STEERING WHEEL ASSEMBLY Installation

45. INSPECT STEERING WHEEL CENTER POINT

46. INSTALL STEERING PAD Installation

47. INSTALL LOWER NO. 2 STEERING WHEEL COVER Installation

48. INSTALL LOWER NO. 3 STEERING WHEEL COVER Installation

49. CONNECT CABLE TO NEGATIVE BATTERY TERMINAL

NOTICE:
When disconnecting the cable, some systems need to be initialized after the cable is reconnected Repair Instruction - Initialization.

50. INSPECT STEERING PAD Installation

51. INSPECT SRS WARNING LIGHT

(a) Inspect the SRS warning light Diagnosis System.