Repair and Diagnosis: Technical Service Bulletins

• How to Find Technical Service Bulletins by Category/Symptom
• Recalls
  • Campaign - Unwanted Repeat Calls To OnStar(R)
  • Campaign - Deactivation Of Analog OnStar(R)
    • Overview
    • Service Procedure
      • 2001 and Older Model Year Vehicles (Except Saab Vehicles)
      • 2002 Through 2006 Model Year Vehicles (Except Saab Vehicles)
      • 2000-2002 Saab 9-3 (9400) 4D/5D; 2000-2003 Saab 9-3 (9400) CV
      • 2003-2005 Saab 9-3 (9400) 4D/5D; 2004-2005 Saab 9-3 (9400) CV
      • 2000-2004 Saab 9-5
    • Owner Letter
• Customer Interest
  • Interior - Eliminating Unwanted Odors in Vehicles
  • Fuel System - Driveability Concerns/MIL ON/Multiple DTC's
  • A/T - 1-2 Shift Shudder at Light to Moderate Accel.
  • Body - Broken Rear Window Defogger Grid Detection
  • Audio - Poor Radio Reception/Static Interference
  • Audio System - Noise When Using Portable Playback Unit
  • Tires/Wheels - Vibration Shortly After Tires Are Mounted on Rim
  • Steering - Power Steering Leaking Fluid
  • Power Steering - Fluid Leaks Due to Extreme Low Temps
  • Restraints - Seat Belt Latching Issues/Warning Lights
  • Tires/Wheels - Tire Slowly Goes Flat/Warning Light ON
  • A/C - Musty Odors Emitted From (HVAC) System
  • A/C - Window Defroster Contact/Tab Repair Information
  • Electrical - MIL ON/DTC's Set By Various Control Modules
  • OnStar(R) - Number Incorrect/Incorrectly Assigned
  • Starting System - Engine No Start/No Crank Condition
  • Wheels - Plastic Wheel Nut Covers Loose/Missing
  • Body/Interior - Headliner is Wet Around Sunroof
  • BCM - Security Lamp ON/No Crank/DTC's Set
  • Fuel System - Whistle Noise on Light Acceleration
  • Wipers - Park in The UP Position
  • OnStar(R) - System Inoperative/No LED Lamp ON
  • OnStar(R) - Microphone Inoperative
  • A/T - 4T65E Poor Performance/Harsh Shifts/DTC's Set
  • Body - Door Latches Freezing in Extreme Cold
  • Body - Rear Window Reveal Molding Loose at Corners
  • Instruments - GPS System Performance Degradation
  • Steering - Snap/Pop Noise When Turning Steering Wheel
  • Interior - Apparent Instrument Panel Gaps
  • Audio System - Static/Poor Radio Reception
  • Electrical - The Vehicle's Horn Is Inoperative
  • Instruments - Noises From The Instrument Cluster
  • Steering - Steering Gear Leaks/Moan or Groan Noise
  • Engine, A/T - Shift/Driveability Concerns/MIL ON
  • Interior Lighting - Sun Visor Vanity Mirror Lamp Inop.
  • Engine - Oil Leaks from Crankshaft Rear Main Seal
  • A/C - Not Cold Enough/Poor Heat Output/DTC's Set
  • OnStar(R) - Incorrect GPS Position Reported During Call
  • Engine - Oil Leaks From Front Crankshaft Seal
  • OnStar(R) - Loss of GPS Signal/Hands Free Issues
  • A/T - Harsh Shifts/Slipping/DTCs P0741/P0742/P0757/P842
  • A/T - No Movement in Drive or 3rd Gear
  • A/T - 4L60/65E, No Reverse/2nd or 4th Gear
  • A/C - Horizontal Vent Louvers Loose or Inoperative
  • OnStar(R) - No Power/Inoperative/No LED
  • A/T - 4T65E Fluid Leaking From A/T Vent
  • Body - Marks/Stains on Windshield When Wet
  • Body - Bumps or Rust Colored Spots in Paint
  • Body - Stain/Film On Windshield Glass Perimeter
  • Steering - Steering Column Clunking When Turning
  • Tires/Wheels - Low Tire/Leaking Cast Aluminum Wheels
  • Electrical - Intermittent MIL/DTC P2138/Reduced Power
  • A/T - 4T80-E (MH1) Left Front. Axle Seal Leak, Slipping
• Recommended Repairs
  • A/C - Musty Odors Emitted From (HVAC) System
• Superceded Bulletins
  • 10-00-89-010A - 10/19/12
  • 12-06-01-008 - 09/01/12
  • 04-06-01-029F - 09/01/12
  • 05-06-04-022H - 07/18/12
  • 04-06-04-047J - 07/18/12
  • 00-03-10-006G - 07/17/12
  • 03-03-10-007F - 07/12/12
  • 03-08-44-005K - 04/01/2012
  • 01-08-51-003A - 11/01/2010
  • 01-08-51-003 - 01/01/2010
  • 08-07-30-035A - 01/01/2010
  • 05-06-04-022F - 10/01/10
  • 00-07-30-009B - 11/01/09
  • 06-08-64-001 - 12/01/06
  • 06-08-64-001A - 10/01/09
  • 06-00-89-031 - 12/01/06
  • 05-03-08-002 - 12/01/05
  • 05-03-08-002A - 10/19/08
  • 05-03-08-002B - 10/01/09
  • 06-00-89-051B - 12/01/08
  • 08-08-44-010C - 06/01/08
  • 08-08-44-010B - 03/01/08
  • 08-08-44-010A - 02/01/08
  • 08-08-44-010 - 01/01/08
  • 04-07-30-017 - 01/01/08
  • 04-06-04-036D - 04/01/08
  • 04-08-50-006A - 12/01/07
  • 04-06-04-054 - 01/01/07
  • 03-07-30-043 - 05/01/06
  • 05-06-04-013 - 01/01/05
  • 05-08-44-029 - 02/08/05
  • 43-17-01 - 09/0/05
  • 43-17-01A - 10/01/05
  • 43-17-01B - 10/19/05
  • 00-06-01-012A - 02/08/05
  • 05-02-32-007 - 12/15/05
  • 02-01-39-004 - 01/12/02
  • 00-06-04-033 - 06/17/00
  • 02-07-30-001B - 05/01/05
  • 04-06-04-047B - 12/01/04
  • 00-07-30-022A - 11/01/04
  • Wipers/Washers - Wipers Park in the UP Position
  • Wipers/Washers - Windshield Wiper Maintenance/Cleaning
  • Wipers - Performance/Cleaning Instructions/Maintenance
  • Windshield Wipers - Performance/Cleaning and Maintenance
  • Body - Distortion in Outer Surface of Vehicle Glass
  • Glass/Body - Windshield Wiper Performance
  • Body - Distortion On Outer Glass Surfaces
  • A/C - Broken Rear Window Defogger Grid Detection
  • A/C - Rear Defogger Heating Grid Damage Detection
  • A/C - Rear Defogger Inoperative/Radio Interference
  • A/C - Window Defroster Contact/Tab Repair Information
  • A/C - Rear Window Defroster Grid Contact/Tab Repair
  • Electrical, A/C - Rear Defroster Grid Repair Information
  • Lighting - Exterior Lamp Condensation/Replacement
  • Electrical - Horn Is Inoperative
  • Lighting - Headlamp Replacement Guidelines
  • Lighting - Headlamp Polycarbonate Lens Damage Prevention
  • Lighting - Damage To Polycarbonate Headlamp Lenses
  • Lighting - Headlamp Polycarbonate Lens Damage Prevention
  • Lighting - Lamp Polycarbonate Lens Damage Prevention
  • Lighting - Replacement Guidelines for Condensation
  • Lighting - Exterior Lamp Condensation Guidelines
  • Lighting - Exterior Lamp Condensation Guideline
  • Lighting - Replacement Guidelines for Lamp Condensation
  • Exterior Lamps - Condensation Replacement Guidelines
  • Instruments - IPC Odometer Programming Method
  • Instruments - IPC Odometer Programming Reference Guide
  • Instruments - IPC Odometer Programming Reference Guide
  • Instruments - Odometer Programming Reference Guide
  • Instruments - IPC Odometer Programming Reference Guide
  • Instruments - IPC Odometer Programming Reference Guide
  • Instruments - IPC Programming Method Reference Guide
  • Body - Paint-Less Dent Repair Recommendations
  • Body - Application of Anti-Corrosion Materials
  • Body - Metal Body Panel Corrosion Protection
  • Body - Hem Flange Sealer For Corrosion Protection
  • Body - Metal Body Panel Corrosion Protection
  • Body - Metal Panel Corrosion Protection
  • Body - Non-Approval of 'Clipping' for Collision Repair
  • Body - Hem Flange Repair
  • Body - Paint-Less Dent Repair Recommendations
  • Interior - Seat Cover Wrinkle/Crease/Burn Info
  • Interior - Seat Cover Wrinkle/Crease/Crack/Burn Info.
  • Body -Bumps or Rust Colored Spots in Paint
  • Body - Bumps/Rust Colored Spots in Paint
  • Body - Rust Colored Spots in Paint
  • Instruments - Door Mirror Diagnostic Information
  • Mirrors - Heated Mirror Defrosting Time
  • Locks - Key Code Security Rules And Information
  • Locks - Key Code Securtiy Rules And Information
  • Interior/Lighting - Sun Visor Vanity Lamp Inoperative
  • Body/Interior - Headliner Wet Around Sunroof
  • Interior - Odor Elimination
  • Interior - Console Lid/Latch Design Change
  • Body - Squeeze Type Resistance Spot Welding/Equipment
  • Body - Information ON Hem Flange Repair
  • Body - Information On Metal Bonding
  • Body - Exterior Emblem Discoloration/Blistering/Peeling
  • Body - Exterior Emblem Discoloration/Peeling/Blistering
  • Body - Vehicle Glass Distortion Information
  • Body - Side Window Chipping Information
  • Body - Use of Silicone for Weatherstrip Maintenance
  • Body - Door Latch Freezing in Cold Weather
  • Body - Door Latches Freeze in Extreme Cold
  • Instruments - O/S Rearview Mirror Diagnostics
  • Body - TPO Fascia Cleaning Prior to Painting
  • OnStar(R) - Incorrect Phone Number Assigned to Vehicle
  • OnStar(R) - Incorrect Position Reported
  • OnStar(R) - Unable to Connect to OnStar (Alaska Only)
  • OnStar(R) - French Canadian Voice Recognition
  • OnStar(R) - No Power/No LED/Inoperative (Generation 6)
  • OnStar(R) - Programming for French Language (Canada)
  • OnStar(R) - Phone Number Concerns
  • Audio System - Interference With Rear Defogger ON
  • Audio System - Noise When Using Portable Playback Unit
  • Audio System -Interference With Rear Defogger ON
  • Audio System -Noise When Using Portable Playback Unit
  • A/C - Rear Defogger Inop/Poor Radio Reception
  • Audio, A/C - Poor Radio Reception/Defogger Grid Inop.
  • Audio System - Poor Reception/Static With Defogger ON
  • Audio System - Vinyl Roofs Affect Radio Performance
  • Audio System - Static/Poor/No Radio Reception (Police)
  • Audio System - Rear Headphone Ear Pads Worn/Damaged
  • Audio - Poor Radio Reception/Static Interference
  • Audio - Inadvertent Steering Wheel Button Activation
  • Navigation - Report Missing/Inaccurate Nav. Map Info
  • Navigation System - Software/DVD Update Program
  • Navigation System - DVD/Software Update Program
  • Navigation Radio - Diagnostics Information
  • Navigation Radio - Adaptation After Radio/Battery R/R
  • XM Radio/OnStar - Problems W/Cloth or Vinyl Roofs
  • OnStar(R) - Dual Mode System Information
  • OnStar(R) - System Inoperative/LED Not ON
  • OnStar(R) - Unable To Renew Hands-Free Call Minutes
  • Navigation System - Performance Degradation
  • Navigation Radio - Diagnostic Information
  • Campaign - Deactivating Analog OnStar(R)
  • OnStar(R) - Aftermarket Device Interference Information
  • Campaign - Deactivation of Analog OnStar(R)
  • Campaign - Analog OnStar(R) Deactivation
  • OnStar(R) - Dual Mode (Digital/Analog) Systems
  • OnStar(R) - Dual-Mode (Analog/Digital) Systems
  • OnStar(R) -Negative Impact of Cloth/Vinyl Roofs
  • OnStar(R) - Number Incorrect/Incorrectly Assigned
  • OnStar(R) - Incorrect GPS Location Reported During Call
  • OnStar(R) - Loses GPS/Can't Renew Hands-Free Minutes
  • OnStar(R) - Unable to Connect (Alaska Vehicles)
  • Campaign - Unwanted Repeat Calls to OnStar(R)
  • Campaign - Unwanted Repeat Calls to OnStar(R)
  • Keyless Entry - Operational Characteristics
  • Restraints - Availability of Seat Belt Extenders
  • Restraints - Seat Belt Extender Availability
  • Restraint System - Seat Belt Extender Availability
  • Restraints - Seat Belt Warning Lamp On/Buckling Issues
  • Restraints - Seat Belt Warning Lamp On/Buckling Issues
  • Restraint System - Normal Safety Belt Locking Conditions
  • Restraints - Seat Belt Locking Characteristics
  • Restraints - Seat Belt Operating Characteristic
  • Seat Belts - Seat Belt Extender Availability
  • Restraints - Seat Belt Latch Stop Button Availability
  • Restraints - Seat Belt Normal Locking Conditions
  • Restraints - Seat Belt Operating Characteristics
  • Restraints - Seat Belt Locking Conditions
  • Restraints - Driver/Passenger Seat Head Rest Information
  • Restraints - Driver/Passenger Seat Head Rest Information
  • Restraints - Passenger Presence System Information
  • Restraints - Passenger Presence Sensing System Info.
  • Restraints - Front Passenger Seat Accessory Precautions
  • SRS - Front Passenger Seat Alteration Precautions
  • Restraints - Passenger Presence System Information
  • Restraints - Passenger Presence System Information
  • SRS - Occupant Sensing System Precautions
  • A/C - Broken Rear Window Defogger Grid Detection
  • Interior - Elimination Of Unwanted Odors
  • A/C - Window Defroster Contact/Tab Repair Information
  • Interior - Elimination Of Unwanted Odors
  • Interior, A/C - Vehicle Odor Elimination
  • A/C - Musty Odors Emitted From (HVAC) System
  • A/C - Odors In Hot/Humid Conditions
  • A/C - Vent Louvers Loose or Inoperative
  • Interior - Eliminating Unwanted Odors
  • A/C - Not Cold Enough/DTC's Set/Mode Won't Change
  • A/C - Not Cold Enough/Mode Won't Change/Multiple DTC's
  • Suspension - Shock Absorber/Strut Fluid Leak Information
  • Suspension - Shock Absorber/Strut Leakage Information
  • Steering - BULLETIN 04-02-35-004D CANCELLATION
  • Steering/Suspension - Revised Outer Tie Rod Nut Torque
  • Steering - Clunk Felt/Heard From Column/Steering Gear
  • Steering - Clunk Heard/Felt in Column During Turns
  • Steering - Clunk Felt/Heard in Steering Column
  • Steering - Clunking Felt/Heard From Steering Column
  • Steering - Clunk Felt/Noise Heard From Steering Column
  • Steering - Clunk Noise Felt/Heard In Steering Column
  • Steering - Clunk Felt/Heard From Column on Turns
  • Steering - Clunk Felt/Heard From Steering Column
  • Steering - Clunk Felt/Heard From Front End on Turns
  • Steering - Clunk Heard/Felt From Steering Column
  • Steering - Front End Clunk On Turns
  • Steering - Steering Gear Stub Shaft Bearing Kit Info.
  • Steering - Steering Gear Stub Shaft Bearing Kit
  • Steering Gear - Stub Shaft Bearing Kit Available
  • Steering Gear - Stub Shaft Bearing Kit Availability
  • Steering - Overview of TSB's for Steering Noise
  • Steering - TSB Overview For Steering Noises
  • Steering Power Steering Pump Replacement Tips
  • Power Steering - Diagnostic Tips
  • Charging System - Low Voltage Display/Low/Dead Battery
  • Electrical - Wiring Terminal/Connector Repair Info.
  • Electrical - Information For Electrical Ground Repair
  • Electrical - Information For Electrical Ground Repair
  • Electrical - Information For Electrical Ground Repair
  • Electrical - Information For Electrical Ground Repair
  • Audio System - Portable Audio Equipment Noise
  • Locks - KeyCode Security Rules and Information
  • Locks - Key Code Security Rules and Information
  • Locks - Key Code Security Rules and Information (CANADA)
  • Charging System - Lights Dim/Low Voltage Display
  • Charging System - Operational Characteristics
  • Battery, Charging System - Electrical Diagnostics
  • Electrical - Battery Charging Tips
  • Battery/Charging System - Electrical Diagnosis
  • Battery/Charging System - Electrical Diagnostics
  • Electrical - Testing Prior to Alternator/Battery Service
  • Disc Brake System - Warranty Service and Procedures
  • Brakes - Brake Warranty Service and Procedures
  • Brakes - Warranty Guidelines and Service Procedures
  • Brake System - Service Procedures and Guidelines
  • Brakes - Service Guidelines and Procedures
  • Brakes - Service Guidelines/Procedures
  • Disc Brakes - Warranty Service and Procedures
  • Drivetrain - Clunk Noise Shifting From PARK Into Gear
  • A/T - DEXRON(R)-VI Fluid Information
  • Drivetrain - Clunk Noise Shifting From PARK Into Gear
  • Drivetrain - Driveline Clunk Information
  • Manual Transmission - M/T Operating Characteristics
  • M/T - Operating Characteristics
  • M/T - Operating Characteristics of Manual Transmissions
  • M/T - Normal Operating Characteristics
  • M/T - Characteristics of Operation
  • M/T - Operational Characteristics
  • M/T - Improved Hydraulic Clutch Bleeding Procedure
  • A/T - New/Reman A/T Identification
  • A/T - Goodwrench(R) Replacement Transmissions
  • A/T - Slight Vehicle Movement In Park At Start Up
  • A/T - DTC P0894/P1870 Diagnostic Information
  • A/T - Clunk When Shifting From PARK/DRIVE/REVERSE
  • A/T - Fluid Leak Diagnostics
  • A/T - Fluid Oil Cooler Flush
  • A/T - Fluid Oil Cooler Flush
  • A/T - Water Or Coolant Contamination Information
  • Automatic Transmission - Fluid Cooler Flushing
  • A/T - Revised Cooler Line Fitting/Converter Check Valve
  • A/T - 4T65-E Knocking Noise From Back of Engine
  • A/T - Torque Converter Replacement
  • A/T - Torque Converter Replacement Guideline
  • A/T - 4L60/65E No Reverse/2nd or 4th Gear
  • A/T - 4L60E/4L65E No Reverse/2nd or 4th Gears
  • A/T - Grinding/Growling In PARK On An Incline
  • A/T - 2-3 Upshift or 3-2 Downshift Clunk Noise
  • A/T - 1-2 Shift Shudder at Light to Moderate Accel.
  • A/T - 4T65E 1-2 Shift Shudder On Light Acceleration
  • A/T - 4T80E, Slips in Gear/L/H Axle Seal Leaks
  • A/T - L/H Front Axle Seal Leak/A/T Slips in Gear
  • 08-07-30-009 - 02/27/08
  • A/T - Light Throttle 1-2 Shift Shudder
  • A/T - 4T65-E, 1-2 Shift Shudder on Light Acceleration
  • A/T - 4T65-E 1-2 Shift Shudder on Light Acceleration
  • A/T - Fluid Leaking From Vent
  • A/T - 4T65-E Oil Leak From Transmission Vent
  • A/T - Cracked or Broken Case Diagnosis
  • A/T - Diagnostic Info on DTCs P0894/P1870
  • Fuel System 'TOP TIER' Detergent Gasoline Information
  • Fuel System - GM Fuel System Treatment PLUS(R) Info.
  • Fuel System - Poor Performance Due To Injector Clogging
  • Fuel System - 'TOP TIER' Detergent Gasoline Information
  • Fuel System - TOP TIER Detergent Gasoline (Canada)
  • Fuel System - TOP TIER Gasoline Usage (Canada)
  • Fuel System - TOP TIER Detergent Gasoline Usage
  • Fuel System - TOP TIER Detergent Gasoline
  • Fuel System - GM Fuel System Treatment Plus(R)
  • Fuel System - TOP TIER Gasoline Information (Canada)
  • Fuel System - TOP TIER Gasoline Information
  • Fuel System - E85 Fuel Usage Information
  • Fuel System - E85 Fuel Usage Recommendations
  • Fuel System - E85 Fuel Usage
  • Fuel System - Fuel System Treatment PLUS(R)
  • Fuel System - TOP TIER Gasoline Recommendations
  • Fuel System - E85 Fuel Usage Recommendations/Precautions
  • Fuel System - Top Tier Gasolines (Canada)
  • Fuel System - Top Tier Gasoline Recommendations
  • Fuel System - 'Top Tier' Gasoline Information
  • Engine Controls - Aftermarket Accessory Usage
  • Electrical - Intermittent MIL/DTC P2138/Reduced Power
  • Electrical - Intermittent MIL/DTC P2138/Reduced Power
  • Electrical - MIL ON/DTC's Set By Various Control Modules
  • Electrical - MIL ON/DTCs Set By Various Control Modules
  • A/T Controls - Snapshot Data Upload Information
  • Fuel System - Driveability Issues/MIL/Multiple DTC's
  • Electrical - Intermittent MIL/DTC P2138/Reduced Power
  • A/T Controls - Snapshot Data Upload Information
  • A/T - DTC P0756 Diagnostic Hints
  • A/T - Diagnostic Information for DTC P0894 and P1870
  • A/T - Slips/Harsh Shifts/DTC's P0741/P0742/P0757/P0842
  • Fuel System - MIL ON/Driveability Issues
  • Engine Controls - Warranty Info., Emissions Programming
  • Engine Controls - MIL ON/Reduced Power/DTC P2138
  • Fuel System - Driveability Issues/MIL ON/DTC's Set
  • A/T Controls - Snapshot Data Information
  • Fuel System - MIL ON/DTC's Set/Driveability Problems
  • Fuel System - Various Driveability Problem/MIL ON/DTC's
  • Engine Controls - Reprogramming Warranty Coverage
  • Engine Controls - Programming Warranty Coverage
  • A/T Controls - DTCs P0894/P1870 Diagnostics
  • Emissions - OBDII I/M Readiness Test
  • A/T - DTC's P0894 and P01870 Diagnostic Information
  • A/T - 4T65E Erratic/Poor Shifting/Low Power/DTC's Set
  • A/T - 4T65E SES Lamp ON/Slipping/DTC's Set/Harsh Shifts
  • Transmission Controls - DTC P0756 Diagnostic Tips
  • 09-06-03-004A - 08/10/09
  • Electrical MIL ON/DTC's Set by Various Control Modules
  • Engine Controls - Aftermarket Accessory Usage
  • Engine Controls - Aftermarket Accessory Usage
  • Engine Controls - Aftermarket Accessory Usage
  • Cooling System - Aluminum Radiator/Heater Core Info.
  • Vehicle - Engine Crankcase and Subsystems Flushing Info.
  • Vehicle - Engine Crankcase and Subsystems Flushing Info.
  • Vehicle - Engine/Subsystem Flushing Recommendations
  • Engine, A/T - Identification Information
  • Engine - Use of 'Surface Conditioning Disks'
  • Engine - Crankcase Flushing Information
  • Engine - Sealant Usage/procedures
  • Exhaust System - Close-Coupled Cat Converter Information
  • Engine - Surface Conditioning Disc Usage Prohibition
  • Engine - Sealant Usage Recommendations
  • Engine - Oil Leaks From Crankshaft Rear Main Seal
  • Engine - Rear Crankshaft Main Seal Oil Leaks
  • Engine - Oil Leaks From The Rear Main Seal
  • Engine - Rear Main Seal Oil Leakage
  • Engine - Rear Main Seal Oil Leaks
  • Engine - Rear Crankshaft Seal Oil Leaks
  • Engine - Intake Manifold Inspection/Replacement
  • Intake Manifold - Inspect/Replace After Engine Damage
  • Engine/Fuel - Additive Information
  • Manual Transmission - Operating Characteristics
  • Engine - Oil Consumption Guideline Info.
  • Engine/Fuel System - Oil/Fuel Additive Recommendations
  • Engine - Oil Consumption Guideline Information
  • Engine - New Long Block Installation Precaution
  • Fuel System - Fuel Injector Maintenance Cleaning
  • Fuel System - Injector Cleaning Recommendations
  • Steering - Moan/Groan Noise When Turning
  • Wheels - Chrome Wheel Pitting/Brake Dust Accumulation
  • Wheels - Aluminum Wheel Refinishing
  • Aluminum Wheels - Low Tire Pressure Condition
  • Wheels/Tires - Slow Leaks From Aluminum Wheels
  • Wheels - Aluminum Wheel Refinishing Recommendations
  • Tires - Puncture Repair Procedures
  • Tires - Radial Force Variation Information
  • Tires - Cold Tire Flat Spotting Explanation
  • Tires - Proper Air Pressure Information
  • Tires - Proper Inflation Pressures
  • Tires - Puncture Repair Procedure
  • A/T - Fluid Cooler Flushing
  • OnStar(R) - System Inoperative/No LED/No Power
  • Cooling System - Coolant Dye Update Information
  • Cooling System - DEX-COOL(R) Coolant Usage Information
  • Cooling System - DEX-COOL(R) Coolant Information
  • A/T - Fluid Flushing Procedure/Tool
  • A/T - DEXRON VI Release/Applications
  • A/T - DEXRON(R) VI Fluid Availability
  • Tires/Wheels - Low Tire Pressure With Aluminum Wheels
  • Tires/Wheels - Nitrogen Gas Usage for Filling Tires
  • A/C - R-134A System Flushing Guidelines and Procedures
  • Steering - Power Steering Moan/Groan Noise
  • Alignment - Recommendations and Requirements
  • A/C - PAG Oil Usage
  • Engine - Unnecessary Flushing Services
  • Wheels Chrome Wheel Chemical Staining/Pitting/Corrosion
  • Wheels - Changing Procedures/Precautions
  • Wheels - Pitting/Brake Dust On Chrome Wheels
  • Tires - Original Equipment Tire Characteristics
  • Tires - Inflation Pressure Information
  • Tires - Tread Puncture Repair Procedures
  • Tires - Radial Force Variation (RFV) Information
  • Engine - Engine Oil Consumption Guideline Information
  • Cooling System - DEXCOOL(R) Leak Detection Dye
  • Steering - Power Steering Moan/Groan/Whine Noise
  • Wheel Alignment - Recommendations/Requirements
  • Tires - Proper Tire Pressure Information
  • Tires - Proper Inflation Pressure Information
  • A/T - DEXRON-VI(R) Fluid Availability
  • Wheels/Tires - 'Upsized' Wheel And Tire Information
  • Tires - Proper Inflation Pressure Info.
  • Engine - Noise Damage Caused By The Oil Filter
  • Engine - Internal Noise/Damage After Oil Filter Change
  • Tires - Information on Proper Tire Pressure
  • A/C - Rear Window Defroster Contact or Tab Repair
  • Wheel/Tire - Upsized Wheel/Tire Performance Info.
  • Tires/Wheels - Vibration/Balance/Shake/Flat Spotting
  • Tires/Wheels - Tire Inflation Pressure Information
  • Tires - (RFV) Radial Force Variation Information
  • Tires - Tire Puncture Repair Procedures
  • Tires - Nitrogen Gas Usage
  • Wheels/Tires - Changing Tire and Wheel Assemblies
  • Wheels/Tires -Low Tire Pressure
  • Engine - Accessory Drive Belt Noise Diagnostics/Tool
  • Wheels/Tires - Accessory Wheel/Tire Mounting/Balancing
  • Wheels/Tires - Chrome or Chrome Plated Steel Valve Caps
  • Wheels/Tires - Tire Slowly Loses Air/Low Tire Message
  • Alignment - Specifications/Requirements/Recommendations
  • Tires - Radial Force Variation (RFV) Info.
  • Tire - Use Of Nitrogen Gas In Tires
  • Tires - Correct Inflation Pressure Information
  • Wheels/Tires - Original Equipment Characteristics
  • Wheels/Tires - Tire Puncture Repair Procedures
  • Wheels/Tires - Low Tire Pressure
  • Wheels/Tires - OE Tire/Wheel Characteristics
  • Wheels/Tires - Low Tire Pressure/Aluminum Wheels Leak
  • Wheels/Tires - Tire(s) Slowly Go Flat
  • Wheel - Refinishing Aluminum Wheels
  • Tires - Tire Radial Force Variation (RFV)
  • Wheels/Tires - Tire Slowly Goes Flat/Tire Air Loss
  • Wheels - Chrome Wheel Staining/Pitting/Corrosion
  • Wheels/Tires - Use of Nitrogen Gas in Tires
  • Wheels/Tires - Tire Radial Force Variation (RFV)
  • Engine - GM Dexos 1(R) and Dexos 2(R) Oil Specifications
  • Wheels - Chrome Wheel Staining/Pitting/Corrosion
  • Tires/Wheels - Tire Slowly Goes Flat/Warning Light ON
  • Tires/Wheels - Information on Tire Radial Force Variation (RFV)
  • A/T - Shift/Driveability Concerns/SES Lamp ON
• All Technical Service Bulletins
  • Electrical - Aftermarket Devices May Interfere With OnStar(R)
  • Interior - Eliminating Unwanted Odors in Vehicles
  • Locks - Key Code Security Rules, Key Code Look Up
  • Vehicle - Engine And Sub Systems Flushing Info. (CANADA)
  • Vehicle - Engine And Sub-Systems Flushing Recommendations
  • Wheels/Tires - Use Of Nitrogen Gas In Tires
  • Instruments - IPC Odometer Programming Method
  • Tires - Information On Proper Tire Pressure
  • Fuel System - Driveability Concerns/MIL ON/Multiple DTC's
  • Engine - THIS BULLETIN HAS BEEN CANCELED
  • A/T - Normal Maintenance or Warranty on 4T40, 4T45, 4T65, 4L60
  • Fuel System - TOP TIER Detergent Gasoline Information (Canada)
  • Fuel System - TOP TIER Detergent Gasoline
  • Tires/Wheels - OE Tire Shake/Vibration Information
  • Suspension - Shock Absorber/Strut Fluid Leak Information
  • M/T - Operating Characteristics Information
  • Brakes - Resurfacing Park Brake Portion of Rear Brake Rotor
  • Body - Hem Flange Sealer For Corrosion Protection
  • A/T - 1-2 Shift Shudder at Light to Moderate Accel.
  • Engine - Intake Manifold Inspection/Replacement
  • Body - Metal Body Panel Corrosion Protection
  • Fuel System - GM Fuel System Treatment PLUS(R) Info.
  • Body - Broken Rear Window Defogger Grid Detection
  • Fuel System - Fuel Injector Maintenance Cleaning
  • Audio - Poor Radio Reception/Static Interference
  • Audio - Inadvertent Steering Wheel Button Activation
  • Audio System - Noise When Using Portable Playback Unit
  • Tires/Wheels - Vibration Shortly After Tires Are Mounted on Rim
  • Steering - Power Steering Leaking Fluid
  • A/T - Fluid Oil Cooler Flow Test
  • Power Steering - Fluid Leaks Due to Extreme Low Temps
  • Restraints - Passenger Presence System Information
  • Lighting - Lamp Polycarbonate Lens Damage Prevention
  • Restraints - Seat Belt Latching Issues/Warning Lights
  • A/T Controls - Snapshot Data With Tech2(R) Information
  • Body - Side Window Chipping Information
  • Restraints - Driver/Passenger Seat Head Rest Information
  • Tires/Wheels - Tire Slowly Goes Flat/Warning Light ON
  • Restraint System - Normal Safety Belt Locking Conditions
  • Engine - Use of 'Surface Conditioning Disks'
  • Navigation - Report Missing/Inaccurate Nav. Map Info
  • Body - Application of Anti-Corrosion Materials
  • A/T - 2-3 Upshift or 3-2 Downshift Clunk Noise
  • A/C - Musty Odors Emitted From (HVAC) System
  • Navigation Radio - Problems After Radio/Battery Service
  • Campaign - Unwanted Repeat Calls To OnStar(R)
  • A/T - Slight Vehicle Movement In Park At Start Up
  • A/C - Window Defroster Contact/Tab Repair Information
  • A/T - DEXRON(R)-VI Fluid Information
  • Engine, A/T - Identification Information
  • Wheels/Tires - Refinishing Aluminum Wheels
  • Lighting - Exterior Lamp Condensation and Replacement
  • Electrical - MIL ON/DTC's Set By Various Control Modules
  • OnStar(R) - Number Incorrect/Incorrectly Assigned
  • Steering/Suspension - Wheel Alignment Specifications
  • Warranty - Claims Submission
  • Warranty - DTC's Required On Repair Orders
  • Electrical - Harness Connection Inspection
  • Electrical - Instrument Panel And General Wiring Repair
  • A/C - R-134a System Flushing Procedures
  • Starting System - Engine No Start/No Crank Condition
  • Wheels - Plastic Wheel Nut Covers Loose/Missing
  • Body/Interior - Headliner is Wet Around Sunroof
  • Body - Sunroof Creak
  • Engine, A/T Controls - Shared Diagnostic Trouble Codes
  • BCM - Security Lamp ON/No Crank/DTC's Set
  • Brakes - Wheel Cylinder Inspection Guidelines
  • Battery - Diagnosis and Charging
    • Overview
    • I.Battery Storage In Vehicle
    • II. Warranty Policy
    • III. Testing the Battery
    • IV. Diagnosing Discharged Batteries and Parasitic Battery Drains
    • V.Battery Charging
  • Battery - Parasitic Drain
  • Battery - Specification Label Clarification
  • Fuel System - Whistle Noise on Light Acceleration
  • Wipers - Park in The UP Position
  • OnStar(R) - System Inoperative/No LED Lamp ON
  • OnStar(R) - Microphone Replacement Addition
  • OnStar(R) - Microphone Inoperative
  • OnStar(R) - Unable to Connect, Bulletin Cancellation
  • OnStar(R) - Programming for Canadian French
  • SRS - New SIR System Disabling Procedure
  • Accessories - DTC's P0300, P1380, P1381
  • A/T - 4T65E Poor Performance/Harsh Shifts/DTC's Set
  • Body - Door Latches Freezing in Extreme Cold
  • Body - Rear Window Reveal Molding Loose at Corners
  • A/T - Diagnosing Fluid Leaks
  • A/T - 4L60-E/4L65-E/4L70-E Product Updates
  • A/T - 4T65-E Updated Internal Components
  • OnStar(R) - Cellular Antenna Replacement Parts
  • Instruments - GPS System Performance Degradation
  • Steering - Snap/Pop Noise When Turning Steering Wheel
  • Interior - Apparent Instrument Panel Gaps
  • Cruise Control - Increasing Set Speed
  • Tires/Wheels - Wheel Weight Usage Precautions
  • Interior - Broken Console or Storage Compartment Latch
  • Body - Urethane Adhesives for Glass Applications
  • Audio System - Static/Poor Radio Reception
  • Audio System - Radio Knob Availability
  • A/T - Shift Lock Control Feature Function
  • A/T - 4T65-E Final Drive Assembly Precaution
  • A/T - Cracked Case Diagnosis
  • Brakes - Revised Disc Brake Component Specifications
  • Fuel - Top Tier Detergent Gasoline Information
  • Fuel System - E85 Refueling Station Information
  • A/C - New PAG Oil
  • Brakes - Rotor/Drum Refinishing Labor Operations
  • Electrical - The Vehicle's Horn Is Inoperative
  • Body - Metal Panel Adhesive Bonding Information
  • Engine Controls - MIL Function During I/M Testing
  • Emissions - OBDII I/M Readiness Testing
  • Cooling System - Coolant Recycling Information
  • Instruments - Noises From The Instrument Cluster
  • Subframe/Frame - Clicking/Creaking Noise
  • A/C - Contaminated R134A Refrigerant
  • M/T - Hydraulic Clutch Bleeding Procedure Improvement
  • Steering - Steering Gear Leaks/Moan or Groan Noise
  • Engine, A/T - Shift/Driveability Concerns/MIL ON
  • Interior Lighting - Sun Visor Vanity Mirror Lamp Inop.
  • Navigation System - Replacement Navigation Discs
  • Instruments - Reduced PRNDL Display Visibility
  • Body - Polypropylene Energy Absorber Replacement
  • Steering - Front End Clunk Noise On Turns
  • Entertainment System - Headphone Foam Pad Replacement
  • Engine - Sealant Usage/Procedures
  • Engine - Oil Leaks from Crankshaft Rear Main Seal
  • A/C - Not Cold Enough/Poor Heat Output/DTC's Set
  • Electrical - Aftermarket Fuse Warning
  • Starting System - Starter Cranks After Key Released
  • Fuel System - E85 Fuel Usage Precautions
  • OnStar(R) - Incorrect GPS Position Reported During Call
  • OnStar(R) - Re-establishing OnStar(R) Communications
  • Engine - Oil Leaks From Front Crankshaft Seal
  • Cooling System - DEX-COOL(R) Coolant Leak Detection Dye
  • OnStar(R) - Loss of GPS Signal/Hands Free Issues
  • Exhaust System - Catalytic Converter Precautions
  • Wheels - Chrome Wheel Brake Dust Accumulation/Pitting
  • Electrical - Battery Charging Tips/Recommendations
  • Battery/Charging System - Electrical Diagnostics Info.
  • Brakes - Rotor Lateral Runout Correction Information
  • Restraints - Usage of Used/Salvaged/Imitation Components
  • A/T - Harsh Shifts/Slipping/DTCs P0741/P0742/P0757/P842
  • Fuel System - E85 Fuel Usage Precaution
  • Keyless Entry System - Characteristics of Operation
  • A/C - Refrigerant Recovery/Recycling/Equipment
  • Remote Starting System - System Inoperative Diagnostics
  • A/T - Torque Converter Replacement Information
  • Emission - Emissions Programming Warranty Coverage
  • A/T - Diagnostic Information for DTC's P0894/P1870
  • A/T - No Movement in Drive or 3rd Gear
  • A/T - Grinding/Growling Noise in Park on Incline
  • A/T - 4L60/65E, No Reverse/2nd or 4th Gear
  • Engine/Fuel System - Oil/Fuel Additive Information
  • A/C - Horizontal Vent Louvers Loose or Inoperative
  • Tire Monitor System - TPM Sensor Information
  • OnStar(R) - No Power/Inoperative/No LED
  • Charging System - Low Voltage Display/Battery Discharged
  • Cooling System, A/C - Aluminum Heater Cores/Radiators
  • Wheels/Tires - Upsized Wheel/Tire Characteristics
  • Audio System - Refurbishing Radio Faceplates/Knobs
  • Audio System - XM(R) Terrestrial Repeater Changes
  • OnStar(R) - Analog/Digital System Information
  • A/T - 4T65E Fluid Leaking From A/T Vent
  • Gasoline Engine - Oil Consumption Guidelines
  • A/T - Revised Converter Check Valve/Cooler Line Fitting
  • Body - Non-Approval of Clipping For Collision Repair
  • Electrical - Reducing Intermittent Electrical Concerns
  • A/T Control - DTC P0756 Diagnostic Tips
  • Instruments - Unnecessary Park Assist Mirror Replacement
  • Steering - Noise Diagnostics TSB References
  • Campaign - Deactivation Of Analog OnStar(R)
    • Overview
    • Service Procedure
      • 2001 and Older Model Year Vehicles (Except Saab Vehicles)
      • 2002 Through 2006 Model Year Vehicles (Except Saab Vehicles)
      • 2000-2002 Saab 9-3 (9400) 4D/5D; 2000-2003 Saab 9-3 (9400) CV
      • 2003-2005 Saab 9-3 (9400) 4D/5D; 2004-2005 Saab 9-3 (9400) CV
      • 2000-2004 Saab 9-5
    • Owner Letter
  • Body - Hem Flange Rust Repair Information
  • Body - Marks/Stains on Windshield When Wet
  • Wheels/Tires - Chrome/Steel Valve Stem Cap Precautions
  • Navigation Radio - Diagnostic Tips
  • Brakes- Disc Brake Warranty Service And Procedures
    • Overview
    • Procedures
      • GM Brake Service Procedure
      • Brake Lathe Calibration Procedure
      • Brake Pulsation
      • Brake Rotor Clean-Up Procedure
      • Brake Noise
      • Key Points - Frequently Asked Questions
      • Brake Warranty
  • OnStar(R) - Negative Impact of Cloth/Vinyl Roofs
  • Restraints - Seat Belt Latch Stop Button Availability
  • Body - Bumps or Rust Colored Spots in Paint
  • Engine - Noise/Damage Oil Filter Application Importance
  • Engine - Drive Belt Misalignment Diagnostics
  • Body - Maintaining Exterior Weatherstrip Appearance
  • 06-08-111-004B - BULLETIN CANCELLATION NOTIFICATION
  • Body - Stain/Film On Windshield Glass Perimeter
  • Wheels/Tires - Accessory Wheel And Tire Information
  • Steering - Power Steering Pump Replacement Tips
  • Steering - Steering Gear Stub Shaft Bearing Kit
  • Steering - Steering Column Clunking When Turning
  • Wheels/Tires - Replacement Wheel Weight Information
  • Tires/Wheels - Low Tire/Leaking Cast Aluminum Wheels
  • Tires/Wheels - Tire Puncture Repair Procedures
  • Lighting - Headlamp Warranty Replacement Guideline
  • Mirrors - Heated Mirrors, Defrosting Time
  • A/T - Goodwrench Transmission Replacement
  • Interior - Proper Use of Floor Mats
  • Wheels - Changing Procedures/Precautions
  • TPMS System - Service And Re-Learning Sensor IDs
  • Body - Squeeze Type Resistance Spot Welding/Equipment
  • Electrical - Intermittent MIL/DTC P2138/Reduced Power
  • Restraints - Extender Availability For Seat Belt
  • Interior - Seat Cover Wrinkle/Crease/Burn Info
  • A/T - Water Or Coolant Contamination Information
  • Body - Drilling High Strength Steel Using CryoCobalt(R)
  • Body - Vehicle Glass Distortion Information
  • Fuel System - TOP TIER Detergent Gasoline (Canada)
  • Tires/Wheels - Information on Tire Radial Force Variation (RFV)
  • Engine - GM Dexos 1(R) And 2(R) Oil Specifications
  • Engine - GM dexos 1(R) and dexos 2(R) Oil Specifications/Info.
  • Body - Pre-Painting/Cleaning Process For TPO Plastic Fascias
  • Drivetrain - Information on Driveline Clunk Noise
  • Wheels - Chromed Aluminum Wheel Staining/Pitting/Corrosion
  • Navigation System - DVD Navigation Update Program
  • Body - Paint-less Dent Repair Process
  • Wipers/Washers - Windshield Wiper Performance Information
  • A/T - 4T80-E (MH1) Left Front. Axle Seal Leak, Slipping
  • Electrical - Ground Repair Information