Repair and Diagnosis: Technical Service Bulletins
- How to Find Technical Service Bulletins by Category/Symptom
- Recalls
- Customer Interest
- Engine - Hesitation On Acceleration
- Brakes - Roughness During Application
- Power Steering Pump - Leakage At Dipstick Cap
- Power Steering Pump -Fluid Leaks At Dipstick Cap
- Crankshaft - Engine Knock
- Engine - Metal to Metal Noise
- Tires - Outer Edge Tire Wear/Rotation Procedure
- A/T - AOD Fluid Leak
- Disc Brake Caliper (Front) - Rattles
- Ignition Coil - Possible Damage From Antitheft Devices
- VV Carburetor - Engine Stalls/Stumbles
- Engine - Cold Weather Stalling
- Engine - Stalling or Hard/No Start
- Engine - Erratic Idle/Stalling
- Engine - Poor Performance/Low Fuel Pressure
- Body - Wind Noise/Turbulence
- Power Door Locks - Are Inoperative
- Thermactor Vacuum Hoses - Lack of Power/Poor Mileage
- Deck Lid - Hold Open Forces Insufficient
- Wiper/Washer - Low Fluid Warning Light Stays On
- Glove Compartment Door - Hard Closing/Loose
- Brake Pedal Pad/Trim Ring - Pulled Off
- A/T - No 3rd to 4th Gear Upshift or Slipping 4th Gear
- A/T - Synthetic Fluid Availability
- Carburetor - Rough Idle/Poor Fuel Economy
- Door/Vent Windows - Excessive Efforts to Open
- A/C System - Chemical/Refrigerator Type Odor
- Windshield Wipers - Inoperative
- Front Seat Cushion Frame - Loose At Track
- Parking Brake - Will Not Stay In Applied Position
- Seals, Gaskets
- Superceded Bulletins
- 91118 - 05/30/91
- Windshield and Interior Glass - Fog/Film
- Air Conditioning - Musty or Mildew Type Odors
- A/C System - Musty/Mildew Odors
- A/C - O Ring Removal From Spring Lock Coupling
- Electrical Diode - Identification/Service Replacements
- Brakes - Special Lubricant Requirements
- A/T - Fluid Application Charts
- A/C System - New A/C Filter Kit
- A/C - New Filter to Prevent Compressor Damage
- A/C System - New Filter Kit
- Air Conditioning - Prevent Damage to Compressor
- A/C - Refrigerant Filtering Tips
- A/C - Refrigerant Filtering Service Tips
- A/C System - Refrigerant Filtering Service Tips
- Wheels - Proper Lug Torque Procedures
- Brakes - Vibration Prevention Service tip
- Recycled Engine Coolant - Service Tip
- A/T - Transmission Fluid Usage Charts
- Automatic Transmission - Fluid Usage Charts
- A/C - Filter Kit Installation After Replacing Compressor
- A/C Compressor Replacement - Refrigerant Filtering
- A/C System - Use of R12 Refrigerant Substitutes
- Air Conditioning - Filtering Refrigerant
- All Technical Service Bulletins
- Recall/Owner Notification Program - Index Update
- RTV Sealant - Improved Material
- Air Conditioning - Odor Service Procedure
- A/C System - Service TSB List
- Air Conditioning - Return of Obsolete Filter Kits
- A/C - Filtering Refrigerant After Compressor Replacement
- Adhesives and Sealants - Availability and Usage
- Power Steering Pump - Changes
- Power Steering pump - Rotor and `C' Clip Changes
- Fuel Filter - Replacement Information
- Engine - Hesitation On Acceleration
- Brakes - Roughness During Application
- Graphic Display - False or No Warnings
- A/C - Warner Compressor Clutch Replacement
- Heater Core - Leakage Diagnostic Tips
- Campaign - Steering Gear Replacement
- Power Steering Pump - Leakage At Dipstick Cap
- Power Steering Pump -Fluid Leaks At Dipstick Cap
- Distributor - Ignition Rotor Alignment Procedure
- Crankshaft - Engine Knock
- Engine - Metal to Metal Noise
- Valve Stem Seal - Installation Preparation
- Aluminum Radiator - Repair Precautions
- Crankshaft Seal - Leaks, Air Pressure Test
- Seals For Rocker Cover, Oil Pan, and Crankshaft
- Aluminum Wheels - Wear/Corrosion Damage
- Tires - Outer Edge Tire Wear/Rotation Procedure
- Aluminum Wheel - New Improved Wrench Adapter
- Lug Nuts - Proper Installation/Torqueing Procedure
- Driver's Seat - Relocation
- Differential Pinion Bolt - Removal Aid
- A/T - AOD Fluid Leak
- Throttle Valve - Control Pressure Specification Revision
- TV Linkage - Revised Adjustment Procedure
- Injector O-Rings - Ordering Information
- EGR Solenoids - Contamination
- Disc Brake Caliper (Front) - Rattles
- Alternator - Rectifier Bench Test Procedure
- Ignition Coil - Possible Damage From Antitheft Devices
- Ignition Distributor - Advance Unit Not Adjustable
- VV Carburetor - Engine Stalls/Stumbles
- Carburetor and Tune-Up Specifications
- Carburetor/Tune-Up Specifications
- Carburetor - Altitude Calibrations
- Engine - Cold Weather Stalling
- Engine - Stalling or Hard/No Start
- Engine - Erratic Idle/Stalling
- Engine - Poor Performance/Low Fuel Pressure
- Fuel Tube/Connector - Service Procedure
- Seat/Shoulder Belts - General Service Information
- Overview
- Section 1 -Identification of Seat Belt System Types For Model Years 1974-1985
- Section 2-Description of Seat Belt System For Model Years 1974-1985
- A.Continuous Loop Three-Point Shoulder/Lap Belt - System With Moveable Tongue and One Retractor - 1976 to Present Cars and Ligh
- B.Dual Retractor Three-Point Shoulder/Lap System - 1974 to 1983 Cars and Light Trucks and 1974 to 1985 Econolines and Club Wago
- C.Two-Point System - Center Front/Rear and Rear Seat Lap Belts
- Section 3-Functional Test Procedure For Shoulder Harness
- Section 4-Functional Test Procedure For Lap Belts and Retractor
- Section 5-Seat Belt Procedure After an Accident
- Section 6-Cleaning Belt Webbing
- Section 7-Service Parts
- Section 8-Service Recalls Involving Seat Belts
- Section 9-TSB's Involving Seat Belts
- Vehicle - Intermittent Operation Diagnosis
- Speedometer/Odometer - Inaccurate Readings
- High Strength Steels - Welding Procedures
- Body - Wind Noise/Turbulence
- Antitheft Devices - Installation Precautions
- Aftermarket Antitheft Devices - Hard Start/No Start
- Idle Emissions - Test Procedure
- Emission Control System - Technician's Glossary
- Fuel System - Liquid/Vapor Leak Detection
- EEC Systems - Symptomized Comprehensive TSB Index
- EEC Harness - Engine Stalls/Stumble
- Electronic Modules - Protection From Static Electricity
- Electrical/Electronic/Fuel Induction - Glossary
- Power Door Locks - Are Inoperative
- Thermactor Vacuum Hoses - Lack of Power/Poor Mileage
- Deck Lid - Hold Open Forces Insufficient
- Safety Belt - Tongue Cover Now Available
- Windshield - Water Leaks
- Windshield - Material Usage Procedure
- Door Glass Spacer/Retainer - Correct Usage
- Wiper/Washer - Low Fluid Warning Light Stays On
- Bumpers - Isolator and Bracket Assembly Replacement
- Glove Compartment Door - Hard Closing/Loose
- Coolant Recovery Reservoir - Fill Procedure
- Recycled Engine Coolant - Service Tips
- Brake Pedal Pad/Trim Ring - Pulled Off
- A/T - AOD Slip/Bump On Upshift/Downshift
- A/T - No 3rd to 4th Gear Upshift or Slipping 4th Gear
- A/T - AOD Diagnostic Information
- A/T - New Rotunda Fluid Changer Service Tip
- A/T - AOD Identifying Valve Bodies
- A/T - AOD New Information/Clutch Return Spring Tension
- A/T - AOD 3-4 Accumulator Change
- A/T - Engine Vacuum Testing
- A/T - AOD 4th Gear Complaints
- A/T - Direct Clutch Failure/Excessive Case Bore Wear
- A/T - How To Use A Pressure Gauge
- A/T - AODE Cooler Return Line Filter Installation
- A/T - AOD Burned Or Slipping Direct Clutch
- A/T - AOD Planetary Gear Set Deterioration
- A/T - Shudder or Vibration During Coastdown 4-3 Shift
- A/T - AOD Reverse Drum Changes
- A/T - Pressure Tap Locations
- A/T - AOD Rough 1-2 Shift After Overhaul
- A/T - Overdrive in 2nd Gear and Lockout/Binds in 1st
- A/T - AOD Torque Converter Identification
- A/T - AOD Rebuild Tips
- A/T - 3-2 Too Sensitive, or No Part Throttle Downshift
- A/T - AOD Relief Valves For Valve Bodies
- A/T - AOD High Pitched Noise In All Ranges
- A/T - Slipping or No-Shift/Metal Sealing Rings
- A/T - AOD No End Play/Overdrive Band Burned
- A/T - AOD No Fourth Gear
- A/T - Front Bushing Wear
- A/T - AOD Burned Overdrive Band/End Play after Rebuild
- A/T - AOD Loss of Governor Pressure Through Valve Body
- A/T - Harsh 1-2 Upshift or Slide Bump 1-2 Upshift
- A/T - Sprag Rotation
- A/T - AOD Kills Engine In Reverse and/or Forward Gears
- A/T - AOD Failure In Rear Of Transmission/No Lubrication
- A/T - AOD No Manual Low Gear
- A/T - Rear Planet Failure/Lack Of Lubrication
- A/T - AOD Governor Pressure Leaks
- A/T - Math Formulas Part I
- A/T - Twenty Steps To Successful Repairs
- A/T - Math Part II
- A/T - Choosing the Right ATF
- Engine Mounts - New Service Parts
- A/T - Synthetic Fluid Availability
- A/T, M/T - New `Mercon' Transmission Fluid
- A/T, M/T - Fluid Usage Chart
- A/T - Mercon V ATF Usage
- Carburetor - Rough Idle/Poor Fuel Economy
- Oil Leak - Rotunda Black Light Diagnostic Procedures
- Wiring - Circuit Number/Color Code Charts
- Wire Harness Terminal and Connector - Service Kit
- Speed Control - New Rotunda Tester Information
- Door/Vent Windows - Excessive Efforts to Open
- Safety Belts - Service Procedure, Manual Revision
- Paint - Cosmetic Damage From Airborn Materials
- Paint - Cosmetic Surface Service Procedures
- Paint - Preparation Procedure And MSDS Information
- Paint - Iron Particle Removal
- A/C - Pressure Cycling Switch Diagnostic Procedure
- A/C System - Chemical/Refrigerator Type Odor
- A/T - AOD Orifice Control Valve Plug Retainer
- A/T - AOD Main Control Valve Body Gasket
- A/T - AOD Separator Plate Gasket Changes
- Tripminder - Operation
- A/T - AOD New Overdrive Band Anchor Pin
- Headlamp Bulb - Replacement Recommendations
- A/C - R12 Refrigerant Substitutes Service Tip
- R-12 Refrigerant - Substitutes
- Air Conditioning - Use of Correct Fluorescent Tracer Dye
- Windshield Wipers - Inoperative
- A/C Coupling - Cleaning Procedures
- Air Conditioning - O Ring Removal Service Tip
- Electric Choke System - Testing Tool
- Power Steering Fluid - Tips
- Recall 87V139000: Fuel Line Coupling Retainer Clips
- Front Seat Cushion Frame - Loose At Track
- Brakes - New Silicone Compound/Grease
- Parking Brake - Will Not Stay In Applied Position
- Rotunda Gas Chek Kit - Requires Modification
- Recall 82V041000: Fuel Filler Inspection
- Seat Back Frame - Unauthorized Service