Steering And Wheel Alignment - Repair (R61) -- Cooper Paceman

• General And Safety Information
  • 00 Safety information for working on vehicles with automatic engine start-stop function (MSA)
  • 32..... Overview of steering
  • 72 12... Components requiring inspection and/or replacement after airbag deployment
  • 32 00... Description of front axle and wheel alignment
  • 32 00... Identification of suspension without label
  • 31 00... Front axle + steering repair work requiring subsequent wheel alignment
  • 33 00... Rear axle repair work requiring subsequent wheel alignment
  • 32 00... Notes on replacement of steering gear/steering column/steering shaft following accident damage
  • 32 00... Moving vehicle into design position
    • Notes
    • 31 33 095 Measuring ride-level height of vehicle
  • 32 00... Moving vehicle into normal position
  • 32 00... Test conditions for chassis/wheel alignment check
  • 32 00 150 KDS chassis/wheel alignment check with vehicle load up to design position
    • Notes
    • 32 00... KDS data statuses
  • 32 00 155 KDS wheel alignment check with ride height measurement without vehicle load
  • 32 00 610 Adjusting toe-in and camber on front axle
  • 32 00 620 Adjusting rear axle
  • 61 31 996 Carrying out steering angle sensor adjustment
  • 32 00... Performing rim runout compensation
• Mechanical Steering Gear
  • 32 00... Notes on replacement of steering gear/steering column/steering shaft following accident damage
  • 32 11... Instructions for removing and installing ear clips
  • 32 11 100 Replacing gaiter for steering box on left or right
• Steering Gear With Servo Unit
  • 32 00... Notes on replacement of steering gear/steering column/steering shaft following accident damage
  • 32 13 572 Replace electrical steering box (EPS)
• Steering Arms, Tie Rods, Steering Damper
  • 32 21 231 Replacing (removing and installing) left or right track rod
  • 32 21 151 Replacing left or right track rod end
• Steering Column
  • 32 31 020 Removing and installing/replacing lower section of steering column shroud
  • 32 31 082 Removing and installing/replacing steering angle sensor
  • 32 31 090 Removing and installing/replacing steering column
  • 32 31 004 Removing and installing/replacing steering column shroud upper section
• Steering Wheel
  • 32 33 010 Removing and installing (replacing) sports steering wheel/steering wheel
  • 32 33... Replacing lower sport steering wheel trim
• Steering Wheel For Airbag
  • 72 00... Safety regulations for handling components with gas generators
  • 72 12... Components requiring inspection and/or replacement after airbag deployment
  • 32 34 020 Removing and installing/replacing airbag unit
  • 32 34 030 Removing and installing/replacing airbag unit (sport steering wheel)
• Electronic Power Steering
  • 32 43 550 Replacing EPS unit (N16/N18)