Repair and Diagnosis (Single Page)
You are viewing the full "tree" of links on one page. This can load slowly, but is easier to search. The same page can appear multiple times under a different folder, that is why the page is so large.View "split tree" where inner folders are split out. where inner links are on separate pages.
Quick Lookups- Accessories & Equipment
- Anti-Theft Systems
- Cruise Control Systems
- Connector Identification
- Self-Diagnostic Tests
- Notes
- Test SP-1A: Reading Fault Codes
- Test SP-2A: Repair Power & Ground For Open To Servo Solenoids
- Test SP-2B: Code 34, Cruise Control Vacuum Solenoid Control Circuit
- Test SP-2C: Code 34, Cruise Control Solenoid Circuit
- Test SP-3A: Code 15, No Vehicle Speed Signal
- Test SP-3B: Code 15, No Vehicle Speed Signal
- Test SP-4A: Testing Cruise Control Switches
- Test SP-5A: Testing Cruise Control On/Off Switch
- Test SP-5B: Checking Cruise Control On/Off Switch
- Test SP-6A
- Test SP-7A: Testing Cruise Control Resume Switch
- Test SP-8A
- Test SP-9A: Testing Cruise Control Set Switch
- Test SP-10A
- Test SP-11A: Checking BRAKELIGHT Switch Circuits For Opens
- Test SP-11B: Checking BRAKELIGHT Switch Circuits For Shorts
- Test SP-12A: Checking Park/Neutral Safety Switch
- Test SP-13A: Checking Cruise Control Servo Operation
- Test SP-13B: Checking Cruise Control Operation
- Test SP-14A: Checking For Intermittent Faults
- Test SP-VER: Cruise Control Verification
- Description
- Operation
- Self-Diagnostic System
- Trouble Shooting
- No Cruise Control When Set Button Is Pressed & Released
- Cruise Control Engages Without Actuating Cruise Set Button
- Cruise Control Engages When Engine Is Started
- Erratic Speed Or Engine Shuts Off
- Cruise Control Disengages On Rough Road
- Engine Does Not Return To Normal Idle
- No Resume When Resume Button Is Pressed
- Cruise Control Does Not Disengage With Brake Pedal Depressed
- Testing (Without DRB-II)
- Removal & Installation
- Wiring Diagrams
- Gauges & Instrument Panels
- Heated Glass/Defoggers
- Mirrors - Power
- Seats - Power
- Steering Column Switches
- Window Motors & Regulators
- Wiper/Washer Systems
- Description
- Trouble Shooting
- Windshield Wiper/Washer System Test
- Windshield Wiper Motor Will Not Run
- Windshield Wiper Motor Slow At All Speeds
- Windshield Wiper Motor Runs In Low Position Only
- Windshield Wiper Motor Runs In High Position Only
- Windshield Wiper Motor Runs With Switch In Off Or Park Position
- Windshield Wiper Motor Will Not Park When Switch Is In Off Position
- Delay Wiper System Test
- Testing Body Control Computer & Wiper/Washer Switch Test
- Testing Power & Ground Supply Test
- Testing Washer Pump Operation Test
- Verification Test
- Rear Wiper Motor Test
- Windshield Wiper/Washer Switch Test
- Removal And Installation
- Overhaul
- Wiring Diagrams
- Body & Frame
- Door Locks & Liftgate Release - Power
- Mirrors - Power
- Seats - Power
- Power Windows
- Brakes
- Anti-Lock Brakes
- Anti-Lock Brake System
- Description
- Operation
- System Precautions
- Bleeding Brake System
- Diagnosis & Testing
- Self-Diagnostic Tests
- Notes
- Visual Inspection
- Test 1A, Reading Fault Messages
- Test 2A, Testing Blank DRB-II Message Screen
- Test 3A, Testing DRB-II No Response Message
- Test 4A, Anti-Lock Light Fault
- Test 5A, Anti-Lock Light Relay Fault
- Test 6A, Boost Pressure Fault
- Test 6B, Boost Pressure Fault
- Test 6C, Boost Pressure Fault
- Test 6D, Boost Pressure Fault
- Test 6E, Boost Pressure Fault
- Test 7A, Cab Fault
- Test 8A, Excess Decay Valve Fault
- Test 9A, Hydraulic Pressure Performance Test
- Test 9B, Hydraulic Pressure Performance Test
- Test 9C, Hydraulic Pressure Performance Test
- Test 9D, Hydraulic Pressure Performance Test
- Test 10A, Hydraulic Pump/Motor Circuit Test
- Test 10B, Hydraulic Pump/Motor Circuit Test
- Test 10C, Hydraulic Pump/Motor Circuit Test
- Test 10D, Hydraulic Pump/Motor Circuit Test
- Test 11A, Left Front Wheel Speed Sensor Continuity Fault
- Test 12A, Left Front Wheel Speed Sensor Fault
- Test 13A, Left Rear Wheel Speed Sensor Continuity Fault
- Test 14A, Left Rear Wheel Speed Sensor Fault
- Test 15A, Low Accumulator Fault
- Test 16A, Low Fluid/Parking Brake Fault
- Test 16B
- Test 16C, Low Fluid/Parking Brake Fault
- Test 16D, Low Fluid/Parking Brake Fault
- Test 16E, Low Fluid/Parking Brake Fault
- Test 17A, Modulator Fault
- Test 17B, Modulator Fault
- Test 17C, Modulator Fault
- Test 17D, Modulator Fault
- Test 17E, Modulator Fault
- Test 17F, Modulator Fault
- Test 17G, Modulator Fault
- Test 17H, Modulator Fault
- Test 17J, Modulator Fault
- Test 17K, Modulator Fault
- Test 17L, Modulator Fault
- Test 18A, Primary Pressure Or Delta Pressure Fault
- Test 18B, Primary Pressure Or Delta Pressure Fault
- Test 18C, Primary Pressure Or Delta Pressure Fault
- Test 18D, Primary Pressure Or Delta Pressure Fault
- Test 18E, Primary Pressure Or Delta Pressure Fault
- Test 19A, Right Front Wheel Speed Sensor Continuity Fault
- Test 20A, Right Front Wheel Speed Sensor Fault
- Test 21A, Right Rear Wheel Speed Sensor Continuity Fault
- Test 21B, Right Rear Wheel Speed Sensor Continuity Fault
- Test 21C, Right Rear Wheel Speed Sensor Continuity Fault
- Test 21D, Right Rear Wheel Speed Sensor Continuity Fault
- Test 21E Right Rear Wheel Speed Sensor Continuity Fault
- Test 22A, Right Rear Wheel Speed Sensor Fault
- Test 23A, Solenoid UNDERVOLTAGE Fault
- Test 23B, Solenoid UNDERVOLTAGE Fault
- Test 24A, Stoplight Switch Input Test
- Test 25A, System Relay Fault
- Test 25B, System Relay Fault
- Test 26A, Complaint Of "Hard" Brake Pedal, Or "Clicking"
- Test 27A, Complaint Of Noisy Pump/Motor
- Test 28A, Complaint Of Scraping/Whirring Noise
- Test VER-1A, System Verification Test
- Removal & Installation
- Adjustments
- Torque Specifications
- Wiring Diagram
- Anti-Lock Brake System
- Mechanical - Hydraulic
- Disc & Drum
- Description & Operation
- Bleeding Procedures
- Adjustments
- Testing
- Power Brake Booster Functional Test
- Power Brake Booster Vacuum Test
- Power Brake Booster Check Valve Test
- Height Sensing Proportioning Valve Test
- Combination Valve Metering Valve Test
- Combination Valve Pressure Differential Switch Test
- Chart 1: Miscellaneous Conditions
- Chart 2: Actuation
- Chart 3: Brake System Diagnostics
- Chart 4: Brake Noise
- Chart 5: Wheel Brakes
- Removal & Installation
- Overhaul
- Torque Specifications
- Disc Brake Specifications
- Drum Brake Specifications
- Disc & Drum
- Traction Control
- Anti-Lock Brake System
- Description
- Operation
- System Precautions
- Bleeding Brake System
- Diagnosis & Testing
- Self-Diagnostic Tests
- Notes
- Visual Inspection
- Test 1A, Reading Fault Messages
- Test 2A, Testing Blank DRB-II Message Screen
- Test 3A, Testing DRB-II No Response Message
- Test 4A, Anti-Lock Light Fault
- Test 5A, Anti-Lock Light Relay Fault
- Test 6A, Boost Pressure Fault
- Test 6B, Boost Pressure Fault
- Test 6C, Boost Pressure Fault
- Test 6D, Boost Pressure Fault
- Test 6E, Boost Pressure Fault
- Test 7A, Cab Fault
- Test 8A, Excess Decay Valve Fault
- Test 9A, Hydraulic Pressure Performance Test
- Test 9B, Hydraulic Pressure Performance Test
- Test 9C, Hydraulic Pressure Performance Test
- Test 9D, Hydraulic Pressure Performance Test
- Test 10A, Hydraulic Pump/Motor Circuit Test
- Test 10B, Hydraulic Pump/Motor Circuit Test
- Test 10C, Hydraulic Pump/Motor Circuit Test
- Test 10D, Hydraulic Pump/Motor Circuit Test
- Test 11A, Left Front Wheel Speed Sensor Continuity Fault
- Test 12A, Left Front Wheel Speed Sensor Fault
- Test 13A, Left Rear Wheel Speed Sensor Continuity Fault
- Test 14A, Left Rear Wheel Speed Sensor Fault
- Test 15A, Low Accumulator Fault
- Test 16A, Low Fluid/Parking Brake Fault
- Test 16B
- Test 16C, Low Fluid/Parking Brake Fault
- Test 16D, Low Fluid/Parking Brake Fault
- Test 16E, Low Fluid/Parking Brake Fault
- Test 17A, Modulator Fault
- Test 17B, Modulator Fault
- Test 17C, Modulator Fault
- Test 17D, Modulator Fault
- Test 17E, Modulator Fault
- Test 17F, Modulator Fault
- Test 17G, Modulator Fault
- Test 17H, Modulator Fault
- Test 17J, Modulator Fault
- Test 17K, Modulator Fault
- Test 17L, Modulator Fault
- Test 18A, Primary Pressure Or Delta Pressure Fault
- Test 18B, Primary Pressure Or Delta Pressure Fault
- Test 18C, Primary Pressure Or Delta Pressure Fault
- Test 18D, Primary Pressure Or Delta Pressure Fault
- Test 18E, Primary Pressure Or Delta Pressure Fault
- Test 19A, Right Front Wheel Speed Sensor Continuity Fault
- Test 20A, Right Front Wheel Speed Sensor Fault
- Test 21A, Right Rear Wheel Speed Sensor Continuity Fault
- Test 21B, Right Rear Wheel Speed Sensor Continuity Fault
- Test 21C, Right Rear Wheel Speed Sensor Continuity Fault
- Test 21D, Right Rear Wheel Speed Sensor Continuity Fault
- Test 21E Right Rear Wheel Speed Sensor Continuity Fault
- Test 22A, Right Rear Wheel Speed Sensor Fault
- Test 23A, Solenoid UNDERVOLTAGE Fault
- Test 23B, Solenoid UNDERVOLTAGE Fault
- Test 24A, Stoplight Switch Input Test
- Test 25A, System Relay Fault
- Test 25B, System Relay Fault
- Test 26A, Complaint Of "Hard" Brake Pedal, Or "Clicking"
- Test 27A, Complaint Of Noisy Pump/Motor
- Test 28A, Complaint Of Scraping/Whirring Noise
- Test VER-1A, System Verification Test
- Removal & Installation
- Adjustments
- Torque Specifications
- Wiring Diagram
- Anti-Lock Brake System
- Anti-Lock Brakes
- Drivelines & Axles
- Electrical
- Charging Systems
- Alternator & Regulator
- Description
- Adjustments
- Trouble Shooting
- Testing (On-Vehicle)
- Bench Testing
- Self-Diagnostic System
- Self-Diagnostic Procedure
- Entering On-Board Self Diagnostics
- Self-Diagnostics DRB-II Test Functions
- Self Diagnosis DRB-II Problems & Error Messages
- Blank Message Screen
- No Response Message
- Ram Test Failure Message
- Cartridge Error Message
- Key Pad Test Failure Message
- High Or Low Battery Message
- Test Ch-1, Battery Test
- Test Ch-2, Alternator Field Not Switching Properly
- Test Ch-3, Charging System Voltage Low
- Test Ch-4, Charging System Voltage High
- Test Ch-5, Checking For Intermittent Problems
- Test Ch-VER, Charging Verification
- Overhaul
- Alternator Specifications
- Torque Specifications
- Alternator & Regulator
- Component Locations
- Fuses & Circuit Breakers
- Gauges
- Starter
- Wiring Diagrams
- Charging Systems
- Engine Mechanical
- Accessory Drive Belts
- Auxiliary Emission Control Systems
- Emission Control System Visual Inspection Procedures - General Information
- * Please Read This First *
- Emission Control Labels
- Emission Control Visual Inspection
- Notes
- Positive Crankcase Ventilation (PCV)
- Thermostatic Air Cleaner (TAC)
- Fuel Evaporative System (EVAP)
- Catalytic Converters
- Fill Pipe RESTRICTOR (Fr)
- Exhaust Gas RECIRCULATION (EGR) System
- Spark Controls (SPK)
- Air Injection System (AIS)
- Oxygen Sensor (O2)
- Computerized Engine Controls (CEC)
- Early Fuel Evaporation (EFE)
- Emission Maintenance Reminder Light (EMR) (If Equipped)
- Malfunction Indicator Light (Mil)
- Emission Control System Visual Inspection Procedures - General Information
- Engine Cooling Fan
- Cooling System (Mechanical)
- Mechanical
- 3.0L V6 - VIN [3]
- Starter
- Timing Belt Replacement - 3.0L - SOHC
- Engine Performance
- Engine Controls - Adjustments - Gasoline
- Application
- Emissions
- EGR Function Testing - CHRYSLER Trucks
- Emission Applications - Domestic Trucks
- Emission Control Abbreviations
- State Emission Standards - Diesel
- State Emission Standards - Gas
- ALASKA
- ARIZONA
- CALIFORNIA
- Colorado
- CONNECTICUT
- DELAWARE
- District Of COLUMBIA
- GEORGIA
- IDAHO
- ILLINOIS
- INDIANA
- KENTUCKY
- MARYLAND
- MASSACHUSETTS
- MISSOURI
- NEVADA
- New Jersey
- New MEXICO
- New YORK
- North CAROLINA
- OHIO
- OREGON
- PENNSYLVANIA
- RHODE Island
- TENNESSEE
- TEXAS
- UTAH
- VIRGINIA
- WASHINGTON
- WISCONSIN
- U. S. EPA ASM2525 & ASM5015 Start-Up Emission Standards
- U. S. EPA Revised Final ASM Emission Standards (ASM5015 & ASM2525)
- U.S. EPA Im240 Emission Standards
- Remove, Overhaul & Install
- Engine Controls - Remove/Install/Overhaul - Gasoline
- Introduction
- Ignition System
- Fuel System
- Fuel System Pressure Release
- Fuel Pump (Caravan, Town & Country, & Voyager)
- Fuel Pump Module (All-Wheel Drive)
- Fuel Pump Module (Except All-Wheel Drive)
- Draining Fuel Tank (Caravan, Town & Country, & Voyager)
- Draining Fuel Tank (DAKOTA, Pickup, RAMCHARGER & RWD Van)
- Fuel Tank (Caravan, Town & Country, & Voyager)
- Fuel Tank (DAKOTA, Pickup, RAMCHARGER & RWD Van)
- Fuel Injector Rails (PFI) (3.0L)
- Fuel Injector Rails (PFI) (3.3L)
- Fuel Injectors (2.5L)
- Fuel Injectors (3.0L & 3.3L)
- Fuel Injectors (3.9L, 5.2L & 5.9L)
- Fuel Pressure Dampener (3.3L)
- Fuel Pressure Regulator (3.3L)
- Fuel Pressure Regulator (3.9L, 5.2L & 5.9L)
- Idle Speed Control (ISC) Actuator (3.9L, 5.2L & 5.9L)
- Oxygen (O2) Sensor
- Throttle Body (TBI)
- Throttle Body (PFI)
- Throttle Body Temperature Sensor (2.5L)
- Throttle Body Temperature Sensor (5.2L & 5.9L)
- Throttle Position Sensor/Switch
- Torque Specifications
- Engine Controls - Remove/Install/Overhaul - Gasoline
- Sensor Range Charts
- Engine Controls - Specifications - Gasoline
- System
- EGR Function Testing
- Engine Controls - Basic Testing - Gasoline
- Engine Controls - System/Component Tests - Gasoline
- Engine Controls - Tests W/Codes - 3.0L
- Introduction
- Model Identification
- Self-Diagnostic System
- Operating Modes
- DRB-II Problems & Error Messages
- Emission Maintenance Reminder (EMR)
- Summary
- Fault Code Charts
- Trouble Shooting Charts
- No Start Tests NS-1A To NS-13A
- Notes
- NS-1A: Checking For Ignition Spark & Power Feed To Coil
- NS-2A: Checking TPS, Power To SBEC & Map Sensor, Theft Alarm Status & Fuel Pressure
- NS-3A: Checking For Wet Spark Plugs, Valve & Ignition Timing
- NS-3B: Checking Valve Timing & Compression
- NS-4A: Checking Fuel Filter, Fuel Pump, Fuel Pressure & Power To Fuel Pump
- NS-4B: Checking Fuel Return Lines & Pressure Regulator
- NS-4C: Checking Fuel Pump & Power To Fuel Pump
- NS-5A: Checking For Defective Coil Or Control Circuitry
- NS-6A: Checking System For Faults
- NS-7A: Checking Power Circuit To Injectors & Ignition Coil
- NS-8A: Checking System PWR & GND & Operation Of TPS, Map Sensor & SBEC
- NS-8B: Checking System PWR & GND & Operation Of TPS, Map Sensor & SBEC
- NS-8C: Checking System Power & Ground
- NS-9A: No Reference Signal (DTC 11)
- NS-9B: No Reference Signal
- NS-9C: No Reference Signal
- NS-10A: Auto Shutdown (ASD) Relay Circuit (DTC 42)
- NS-11A: Code 42, No Auto Shutdown (ASD) Relay Voltage Sensed At SBEC (DTC 42)
- NS-12A: Checking Idle Speed Motor Operation
- NS-12B: Checking Idle Speed Motor Operation
- NS-12C: Checking Idle Speed Motor Operation
- NS-12D: Checking Idle Speed Motor Operation
- NS-12E: Checking Idle Speed Motor Operation
- NS-13A: Performing Start & Stall Mechanical Test
- DRIVEABILITY Tests Dr-1A To Dr-47A
- Please Read This First *
- Dr-1A: Checking System For Faults
- Dr-1B: DRB-II Fault Messages
- Dr-2A: Slow Change In Map Signal (DTC 13)
- Dr-3A: No Change In Map From Start To Run (DTC 13)
- Dr-4A: Map Voltage Too Low (DTC 14)
- Dr-5A: Map Voltage Too High (DTC 14)
- Dr-6A: No Vehicle Speed Signal (DTC 15)
- Dr-7A: Oxygen Sensor (O2) Signal Stays At Center (DTC 21)
- Dr-8A: Oxygen Sensor (O2) Shorted To Voltage (DTC 21)
- Dr-9A: Coolant Temperature Sensor Voltage Too High (DTC 22)
- Dr-10A: Coolant Temperature Sensor Voltage Too Low (DTC 22)
- Dr-11A: Throttle Position Sensor (TPS) Voltage High (DTC 24)
- Dr-12A: Throttle Position Sensor (TPS) Voltage Low (DTC 24)
- Dr-13A: Automatic Idle Motor Circuits (DTC 25)
- Dr-14A: Injector No. 1 Peak Current Not Reached (DTC 26)
- Dr-15A: Injector No. 1 Control Circuit (DTC 27)
- Dr-15B: Injector No. 1 Control Circuit
- Dr-15C: Injector No. 1 Control Circuit
- Dr-15D: Injector No. 1 Control Circuit
- Dr-16A: Injector No. 2 Peak Current Not Reached (DTC 26)
- Dr-17A: Injector No. 2 Control Circuit (DTC 27)
- Dr-17B: Injector No. 2 Control Circuit
- Dr-17C: Injector No. 2 Control Circuit
- Dr-17D: Injector No. 2 Control Circuit
- Dr-18A: Injector No. 3 Peak Current Not Reached (DTC 26)
- Dr-19A: Injector No. 3 Control Circuit (DTC 27)
- Dr-19B: Injector No. 3 Control Circuit
- Dr-19C: Injector No. 3 Control Circuit
- Dr-19D: Injector No. 3 Control Circuit
- Dr-20A: Purge Solenoid Circuit (DTC 31)
- Dr-21A: EGR Solenoid Circuit (DTC 32)
- Dr-22A: EGR System Failure (DTC 32)
- Dr-23A: A/C Clutch Relay Circuit (DTC 33)
- Dr-24A: A/C Clutch Relay Circuit (DTC 33)
- Dr-25A: A/C Clutch Relay Circuit (DTC 33)
- Dr-25B: A/C Clutch Relay Circuit
- Dr-26A: A/C Clutch Relay Circuit (DTC 33)
- Dr-27A: Radiator Fan Relay Circuit (DTC 35)
- Dr-28A: Radiator Fan Relay Circuit (DTC 35)
- Dr-29A: Radiator Fan Relay Circuit (DTC 35)
- Dr-30A: No Auto Shutdown (ASD) Relay Voltage Sense At SBEC (DTC 42)
- Dr-31A: No Sync Pick-Up Signal (DTC 54)
- Dr-31B: No Sync Pick-Up Signal
- Dr-32A: SBEC Failure EMR Miles Not Stored & EEPROM Write Denied (DTC 63)
- Dr-33A: Checking Secondary Ignition & Timing
- Dr-34A: Checking Fuel Pressure
- Dr-34B: Checking Fuel Pressure
- Dr-35A: Checking Coolant & Throttle Position Sensor (TPS) Calibration
- Dr-36A: Checking Map Sensor Calibration
- Dr-37A: Checking Oxygen Sensor Switching
- Dr-37B: Checking Oxygen Sensor Switching
- Dr-38A: Checking Idle Speed Motor Operation
- Dr-38B: Checking Idle Speed Motor Operation
- Dr-38C: Checking Idle Speed Motor Operation
- Dr-38D: Checking Idle Speed Motor Operation
- Dr-38E: Checking Idle Speed Motor Operation
- Dr-39A: Checking Park/Neutral Switch Input
- Dr-40A: Checking SBEC Grounds & Power Circuits
- Dr-41A: Checking Engine Vacuum
- Dr-42A: Checking Minimum Idle Airflow
- Dr-43A: Performing No Fault Code Mechanical Test
- Dr-44A: Intermittent Test For Solenoids & Relays
- Dr-45A: Intermittent Test For Voltage Sensor
- Dr-45B: Intermittent Test For Map Sensor Signal Change
- Dr-46A: Intermittent Test For Idle Motor Circuits
- Dr-47A: Intermittent Test For Idle Motor Circuits
- Verification Procedures VER-1 To VER-3
- Engine Controls - Tests W/Codes - 3.3L
- Introduction
- Model Identification
- Self-Diagnostic System
- Operating Modes
- DRB-II Problems & Error Messages
- Emission Maintenance Reminder (EMR)
- Summary
- Fault Code Charts
- Trouble Shooting Charts NS-1A To NS-14A
- Notes
- NS-1A: Checking For Ignition Spark, Fault Messages & Dis Signal Status
- NS-2A: Checking Theft Alarm Status & Power To SBEC & Map Sensor
- NS-3A: Checking TPS, Fuel Pressure, Power To Coil, Spark Plugs & Engine Timing
- NS-4A: Checking Fuel Filter, Fuel Pump, Pressure Regulator & Power To Fuel Pump
- NS-5A: Checking For High Fuel Pressure At Pressure Regulator & Fuel Tank
- NS-5B: Checking Pressure Regulator & Dampener
- NS-6A: Checking Dis Signal Status & Dis Crankshaft Sensor
- NS-6B: Checking Dis Signal Status & Dis Crankshaft Sensor
- NS-7A: Checking Dis Camshaft Sensor
- NS-7B: Checking Dis Camshaft Sensor
- NS-8A: Checking Dis Camshaft & Crankshaft Sensor Circuits
- NS-8B: Checking Dis Camshaft & Crankshaft Sensor Circuits
- NS-9A: Repairing Ignition Coil Circuit, Power Feed To Injectors & Dis
- NS-10A: Checking For System Power & Ground, Operation Of Map Sensor & SBEC
- NS-10B: Checking For System Power & Ground, Operation Of MAPSENSOR & SBEC
- NS-10C: Checking For System Power & Ground, Operation Of Map Sensor & SBEC
- NS-11A: Auto Shutdown (ASD) Relay Control Circuit (DTC 42)
- NS-12A: No Auto Shutdown (ASD) Relay Voltage Sensed At SBEC (DTC 42)
- NS-13A: Checking Idle Speed Motor Operation
- NS-13B: Checking Idle Speed Motor Operation
- NS-13C: Checking Idle Speed Motor Operation
- NS-13D: Checking Idle Speed Motor Operation
- NS-13E: Checking Idle Speed Motor Operation
- NS-14A: Performing No Fault Code Mechanical Test
- DRIVEABILITY Tests Dr-1A To Dr-49A
- Notes
- Dr-1A: Checking System For Faults
- Dr-1B: DRB-II Fault Messages
- Dr-2A: No Change In Map From Start To Run (DTC 13)
- Dr-3A: Map Voltage Too Low (DTC 14)
- Dr-4A: Map Voltage Too High (DTC 14)
- Dr-5A: No Vehicle Speed Signal (DTC 15)
- Dr-6A: O2 Signal Stays At Center (DTC 21)
- Dr-7A: O2 Signal Shorted High (DTC 21)
- Dr-8A: Coolant Sensor Voltage Too High (DTC 22)
- Dr-9A: Coolant Sensor Voltage Too Low (DTC 22)
- Dr-10A: Charge Temperature Sensor Voltage High (DTC 23)
- Dr-11A: Charge Temperature Voltage Low (DTC 23)
- Dr-12A: Throttle Position Sensor Voltage High (DTC 24)
- Dr-13A: Throttle Position Sensor Voltage Low (DTC 24)
- Dr-14A: Automatic Idle Motor Circuits (DTC 25)
- Dr-15A: Injector No. 1 Peak Current Not Reached (DTC 26)
- Dr-16A: Injector No. 1 Control CKT & Peak Current Not Reached (DTC 27 & 26)
- Dr-17A: Injector No. 2 Peak Current Not Reached (DTC 26)
- Dr-18A: Codes 27 & 26, Injector No. 2 Control CKT & Peak Current Not Reached (DTC 27 & 26)
- Dr-19A: Injector No. 3 Peak Current Not Reached (DTC 26)
- Dr-20A: Injector No. 3 Control CKT & Peak Current Not Reached (DTC 27 & 26)
- Dr-21A: Purge Solenoid Circuit (DTC 31)
- Dr-22A: EGR Solenoid Circuit (DTC 32)
- Dr-23A: EGR System Failure (DTC 32)
- Dr-24A: A/C Clutch Relay Circuit (DTC 33)
- Dr-25A: A/C Clutch Relay Circuit (DTC 33)
- Dr-26A: Radiator Fan Relay Circuit (DTC 35)
- Dr-27A: Radiator Fan Relay Circuit (DTC 35)
- Dr-28A: Code 42, No Auto Shutdown (ASD) Relay Voltage Sensed At SBEC (DTC 42)
- Dr-29A: Ignition Coil No. 1 Primary Circuit (DTC 43)
- Dr-30A: Ignition Coil No. 2 Primary Circuit (DTC 43)
- Dr-31A: Ignition Coil No. 3 Primary Circuit (DTC 43)
- Dr-32A: SBEC Failure EMR Mileage Not Stored & EEPROM Write Denied (DTC 63)
- Dr-33A: Checking Secondary Ignition & Timing
- Dr-34A: Checking Fuel Pressure
- Dr-34B: Checking Fuel Pressure
- Dr-35A: Checking Coolant Temperature Sensor & TPS Calibration
- Dr-36A: Checking Map Sensor Calibration
- Dr-37A: Checking Oxygen Sensor Switching
- Dr-37B: Checking Oxygen Sensor Switching
- Dr-38A: Checking Idle Motor Operation
- Dr-38B: Checking Idle Motor Operation
- Dr-38C: Checking Idle Motor Operation
- Dr-38D: Checking Idle Motor Operation
- Dr-38E: Checking Idle Motor Operation
- Dr-39A: Checking Park/Neutral Switch Input
- Dr-40A: Checking SBEC Grounds & Power Circuits
- Dr-41A: Checking EGR Operation, Federal Emissions
- Dr-42A: Checking Engine Vacuum
- Dr-43A: Checking Minimum Idle Airflow
- Dr-44A: Checking Knock Sensor Circuit
- Dr-45A: Performing No Fault Code Mechanical Test
- Dr-46A: Intermittent Test For Solenoids & Relays
- Dr-47A: Intermittent Test For Voltage Sensors
- Dr-47B: Intermittent Test For Slow Change Or No Change In Map Sensor
- Dr-48A: Intermittent Test For Automatic Idle Speed (AIS) Motor Circuits
- Dr-49A: Intermittent Test For Fuel Injectors
- Verification Procedures VER-1 To VER-3
- Engine Controls - Tests W/Codes - Body Control Computer
- Introduction
- Self-Diagnostic System
- Diagnostic Procedure
- Self-Diagnostic Tests
- Trouble Shooting Charts
- Note
- Test 1A (1 Of 2) - Vehicle Equipment & System Problems Id
- Test 1A (2 Of 2) - Vehicle Equipment & System Problems Id
- Test 2A - Electronic Cluster Diagnosis
- Test 2B - Repairing Electronic Cluster "Power Upon Entry"
- Test 3A - Electronic Cluster Fault Codes
- Test 4A - Electronic Cluster Problem Not Identified By A
- Test 4B - Electronic Cluster Odometer Failure
- Test 4C - Electronic Cluster Switch Test
- Test 5A - Identifying Faulty Gauge
- Test 6A - Repairing Temperature Gauge Problems
- Test 7A - Identifying Faulty Warning Indicator
- Test 8A - Electronic Cluster Illumination Test
- Test 8B - Electronic Cluster Illumination Test
- Test 8C - Electronic Cluster Illumination Test
- Test 8D - Electronic Cluster Illumination Test
- Test 8E - Electronic Cluster Illumination Test
- Test 8F - Electronic Cluster Illumination Test
- Test 8G - Electronic Cluster Illumination Test
- Test 8H - Repairing Mic Cluster Illumination
- Test 9A - Electro/Mechanical Cluster Diagnosis
- Test 10A - Faulty Gauge On Electro/Mechanical Cluster Id
- Test 10B - Repairing Faulty Gauge On Electro/Mechanical
- Test 11A - Electro/Mechanical Cluster Odometer Failure
- Test 12A - Faulty Warning Lamp On Premium Electro/Mechanical
- Test 12B - Faulty Warning Lamp On Base Electro/Mechanical
- Test 12C - Repairing Faulty Warning Lamp Condition
- Test 13A - Repairing Door Ajar Warning Lamp
- Test 14A - Repairing Voltage Gauge Or Voltage Lamp Problem
- Test 22A - Intermittent Wiper Problem Id
- Test 22B - Checking Controller & Wiper Switch
- Test 23A - Checking Power & Ground Supply
- Test 24A - Checking Washer Pump Operation
- Test 28A - Diagnosing Left Pod Switch & Power
- Test 28B - Checking Power & Ground Supply
- Test 28C - Checking Wiring & Body Controller For Shorts
- Test 29A - Checking Body Controller & Wiring For Shorts To
- Test 30A - Checking Left Front Door Jamb Switch & Wiring For
- Test 30B - Checking Ground Supply & Diode Assembly For Open
- Test 31A - Checking Right Front Door Jamb Switch & Wiring For
- Test 32A - Checking Side Door Jamb Switch & Wiring For Open
- Test 33A - Checking Left Pod Switch & For Open Ground
- TEST 34A - REPAIRING FAULTY REAR DOME & LIFTGATE Lamps
- Test 34B - Checking Liftgate Latch Switch & Wiring For Shorts
- Test 34C - Checking Liftgate Latch Switch & Wiring For Open
- Test 35A - Checking Diode Assembly & Liftgate Lamps Wiring
- Test 36A - Checking Key In Lamp Circuit
- Test 36B - Checking For Key In Lamp Circuit Short
- Test 36C - Checking Door Jamb CKT For Ignition Key In Lamp
- Test 37A - Headlights Will Not Turn Off
- Test 37B - Headlight Time Delay Will Not Work
- Test 39A - Diagnosing Seat Belt Warning Light Circuit
- Test 39B - Diagnosing Seat Belt Warning Light Circuit
- Test 39C - Diagnosing Seat Belt Warning Light Circuit
- Test 39D - Diagnosing Seat Belt Warning Light Circuit
- Test 42A - Diagnosing Left Front Door Ajar Circuit
- Test 43A - Diagnosing Right Front Door Ajar Circuit
- Test 44A - Diagnosing Side Front Door Ajar Circuit
- Test 45A - Diagnosing Liftgate Ajar Circuit
- Test 46A - Repairing Faulty Washer Fluid Level Switch
- Test 47A - Repairing Fuel Level Problem
- Test 48A - Repairing Fuel Level Problem
- Test 49A - Checking Wiring & Sending Unit For Proper
- Test 49B - Checking Wiring & Sending Unit For Proper
- Test 49C - Checking Wiring, Controller & Cluster For Proper
- Test 50A Verification Test
- Test 1A - General Failure Messages
- Test 1B - Testing DRB-II
- Test 2A - Testing For Ram Test Failure
- Test 3A - Testing For Cartridge Error Message
- Test 4A - Testing For Keypad Test Failure Message
- Test 5A - Testing For High Battery Message
- Test 6A - Testing For Low Battery Message
- Test 7A - CCD Bus Failure Messages
- Test 53A - Testing For Short To Battery On Bus
- Test 54A - Testing For Short To 5 Volts On Bus
- Test 55A - Testing For Short To Ground On Bus
- Test 56A - Testing For Bus (+) & Bus (-) Shorted Together
- Test 57A - Testing For No Termination On Bus
- Test 58A - Testing For Bus Bias Level Too Low
- Test 58B - Testing For Bus Bias Level Too Low
- Test 59A - Bus Bias Level Too High
- Test 59B - Bus Bias Level Too High
- Test 60A - No Bus Bias
- Test 61A - Testing For Bus (+) Open
- Test 62A - Testing For Bus (-) Open
- Test 63A - Testing For Bus (+) & Bus (-) Open
- Test 64A - Testing For Not Receiving Bus Message Correctly On
- Test 65A - No Response (*) As-Body System
- Test 66A - Testing For Electronic Instrument Cluster No
- Test 66B - Testing For Electronic Instrument Cluster No
- Test 66C - Testing Electronic Instrument Cluster For No
- Test 67A - Testing Mechanical Instrument Cluster For No
- Test 67B - Testing G5, A21, & A01 Wires For Power
- Test 67C - Testing M01 Circuit
- Test 68A - Testing A-604 Controller For No Response
- Test 70A - Testing Mechanical Instrument Cluster For No
- Test 70B - Testing G5, A21, & A01 Circuits
- Test 70C - Testing M01 Circuit
- Test 71A - Testing Engine Controller For No Response
- Test 72A - Testing For Blank DRB-II Message Screen
- Test 108A - Testing Engine Diagnostic Connector Ground & DRB-II For Correct Operation
- Test 109A - Testing For No Response On The DRB-II Screen
- Test 109B - Testing For No Response On The DRB-II Screen
- Test VER-1 - Verification Test
- Engine Controls - Tests W/O Codes - Gasoline
- Introduction
- Symptoms Diagnosis
- Notes
- No Start (Cold Engine)
- No Start (Warm Engine)
- Starts But Stalls
- Hard To Start (Cold Engine)
- Erratic Idle (Warm-Up)
- Engine Surges
- Backfiring
- Incorrect Idle Speed
- Hesitation On Acceleration
- Hesitation When Coasting
- Knocking
- Engine Misfire On All Conditions
- Insufficient Engine Power
- Poor Fuel Economy
- EXCESSIVE HC & NOx
- Intermittent Problem Diagnosis
- Intermittent Test Procedures
- Waveform (Injector) - 3.0L MFI VIN [3]
- Waveform (Injector) - 3.3L MFI VIN [R]
- Testing & Diagnosis
- EGR Function Testing
- Engine Controls - Basic Testing - Gasoline
- Engine Controls - System/Component Tests - Gasoline
- Engine Controls - Tests W/Codes - 3.0L
- Introduction
- Model Identification
- Self-Diagnostic System
- Operating Modes
- DRB-II Problems & Error Messages
- Emission Maintenance Reminder (EMR)
- Summary
- Fault Code Charts
- Trouble Shooting Charts
- No Start Tests NS-1A To NS-13A
- Notes
- NS-1A: Checking For Ignition Spark & Power Feed To Coil
- NS-2A: Checking TPS, Power To SBEC & Map Sensor, Theft Alarm Status & Fuel Pressure
- NS-3A: Checking For Wet Spark Plugs, Valve & Ignition Timing
- NS-3B: Checking Valve Timing & Compression
- NS-4A: Checking Fuel Filter, Fuel Pump, Fuel Pressure & Power To Fuel Pump
- NS-4B: Checking Fuel Return Lines & Pressure Regulator
- NS-4C: Checking Fuel Pump & Power To Fuel Pump
- NS-5A: Checking For Defective Coil Or Control Circuitry
- NS-6A: Checking System For Faults
- NS-7A: Checking Power Circuit To Injectors & Ignition Coil
- NS-8A: Checking System PWR & GND & Operation Of TPS, Map Sensor & SBEC
- NS-8B: Checking System PWR & GND & Operation Of TPS, Map Sensor & SBEC
- NS-8C: Checking System Power & Ground
- NS-9A: No Reference Signal (DTC 11)
- NS-9B: No Reference Signal
- NS-9C: No Reference Signal
- NS-10A: Auto Shutdown (ASD) Relay Circuit (DTC 42)
- NS-11A: Code 42, No Auto Shutdown (ASD) Relay Voltage Sensed At SBEC (DTC 42)
- NS-12A: Checking Idle Speed Motor Operation
- NS-12B: Checking Idle Speed Motor Operation
- NS-12C: Checking Idle Speed Motor Operation
- NS-12D: Checking Idle Speed Motor Operation
- NS-12E: Checking Idle Speed Motor Operation
- NS-13A: Performing Start & Stall Mechanical Test
- DRIVEABILITY Tests Dr-1A To Dr-47A
- Please Read This First *
- Dr-1A: Checking System For Faults
- Dr-1B: DRB-II Fault Messages
- Dr-2A: Slow Change In Map Signal (DTC 13)
- Dr-3A: No Change In Map From Start To Run (DTC 13)
- Dr-4A: Map Voltage Too Low (DTC 14)
- Dr-5A: Map Voltage Too High (DTC 14)
- Dr-6A: No Vehicle Speed Signal (DTC 15)
- Dr-7A: Oxygen Sensor (O2) Signal Stays At Center (DTC 21)
- Dr-8A: Oxygen Sensor (O2) Shorted To Voltage (DTC 21)
- Dr-9A: Coolant Temperature Sensor Voltage Too High (DTC 22)
- Dr-10A: Coolant Temperature Sensor Voltage Too Low (DTC 22)
- Dr-11A: Throttle Position Sensor (TPS) Voltage High (DTC 24)
- Dr-12A: Throttle Position Sensor (TPS) Voltage Low (DTC 24)
- Dr-13A: Automatic Idle Motor Circuits (DTC 25)
- Dr-14A: Injector No. 1 Peak Current Not Reached (DTC 26)
- Dr-15A: Injector No. 1 Control Circuit (DTC 27)
- Dr-15B: Injector No. 1 Control Circuit
- Dr-15C: Injector No. 1 Control Circuit
- Dr-15D: Injector No. 1 Control Circuit
- Dr-16A: Injector No. 2 Peak Current Not Reached (DTC 26)
- Dr-17A: Injector No. 2 Control Circuit (DTC 27)
- Dr-17B: Injector No. 2 Control Circuit
- Dr-17C: Injector No. 2 Control Circuit
- Dr-17D: Injector No. 2 Control Circuit
- Dr-18A: Injector No. 3 Peak Current Not Reached (DTC 26)
- Dr-19A: Injector No. 3 Control Circuit (DTC 27)
- Dr-19B: Injector No. 3 Control Circuit
- Dr-19C: Injector No. 3 Control Circuit
- Dr-19D: Injector No. 3 Control Circuit
- Dr-20A: Purge Solenoid Circuit (DTC 31)
- Dr-21A: EGR Solenoid Circuit (DTC 32)
- Dr-22A: EGR System Failure (DTC 32)
- Dr-23A: A/C Clutch Relay Circuit (DTC 33)
- Dr-24A: A/C Clutch Relay Circuit (DTC 33)
- Dr-25A: A/C Clutch Relay Circuit (DTC 33)
- Dr-25B: A/C Clutch Relay Circuit
- Dr-26A: A/C Clutch Relay Circuit (DTC 33)
- Dr-27A: Radiator Fan Relay Circuit (DTC 35)
- Dr-28A: Radiator Fan Relay Circuit (DTC 35)
- Dr-29A: Radiator Fan Relay Circuit (DTC 35)
- Dr-30A: No Auto Shutdown (ASD) Relay Voltage Sense At SBEC (DTC 42)
- Dr-31A: No Sync Pick-Up Signal (DTC 54)
- Dr-31B: No Sync Pick-Up Signal
- Dr-32A: SBEC Failure EMR Miles Not Stored & EEPROM Write Denied (DTC 63)
- Dr-33A: Checking Secondary Ignition & Timing
- Dr-34A: Checking Fuel Pressure
- Dr-34B: Checking Fuel Pressure
- Dr-35A: Checking Coolant & Throttle Position Sensor (TPS) Calibration
- Dr-36A: Checking Map Sensor Calibration
- Dr-37A: Checking Oxygen Sensor Switching
- Dr-37B: Checking Oxygen Sensor Switching
- Dr-38A: Checking Idle Speed Motor Operation
- Dr-38B: Checking Idle Speed Motor Operation
- Dr-38C: Checking Idle Speed Motor Operation
- Dr-38D: Checking Idle Speed Motor Operation
- Dr-38E: Checking Idle Speed Motor Operation
- Dr-39A: Checking Park/Neutral Switch Input
- Dr-40A: Checking SBEC Grounds & Power Circuits
- Dr-41A: Checking Engine Vacuum
- Dr-42A: Checking Minimum Idle Airflow
- Dr-43A: Performing No Fault Code Mechanical Test
- Dr-44A: Intermittent Test For Solenoids & Relays
- Dr-45A: Intermittent Test For Voltage Sensor
- Dr-45B: Intermittent Test For Map Sensor Signal Change
- Dr-46A: Intermittent Test For Idle Motor Circuits
- Dr-47A: Intermittent Test For Idle Motor Circuits
- Verification Procedures VER-1 To VER-3
- Engine Controls - Tests W/Codes - 3.3L
- Introduction
- Model Identification
- Self-Diagnostic System
- Operating Modes
- DRB-II Problems & Error Messages
- Emission Maintenance Reminder (EMR)
- Summary
- Fault Code Charts
- Trouble Shooting Charts NS-1A To NS-14A
- Notes
- NS-1A: Checking For Ignition Spark, Fault Messages & Dis Signal Status
- NS-2A: Checking Theft Alarm Status & Power To SBEC & Map Sensor
- NS-3A: Checking TPS, Fuel Pressure, Power To Coil, Spark Plugs & Engine Timing
- NS-4A: Checking Fuel Filter, Fuel Pump, Pressure Regulator & Power To Fuel Pump
- NS-5A: Checking For High Fuel Pressure At Pressure Regulator & Fuel Tank
- NS-5B: Checking Pressure Regulator & Dampener
- NS-6A: Checking Dis Signal Status & Dis Crankshaft Sensor
- NS-6B: Checking Dis Signal Status & Dis Crankshaft Sensor
- NS-7A: Checking Dis Camshaft Sensor
- NS-7B: Checking Dis Camshaft Sensor
- NS-8A: Checking Dis Camshaft & Crankshaft Sensor Circuits
- NS-8B: Checking Dis Camshaft & Crankshaft Sensor Circuits
- NS-9A: Repairing Ignition Coil Circuit, Power Feed To Injectors & Dis
- NS-10A: Checking For System Power & Ground, Operation Of Map Sensor & SBEC
- NS-10B: Checking For System Power & Ground, Operation Of MAPSENSOR & SBEC
- NS-10C: Checking For System Power & Ground, Operation Of Map Sensor & SBEC
- NS-11A: Auto Shutdown (ASD) Relay Control Circuit (DTC 42)
- NS-12A: No Auto Shutdown (ASD) Relay Voltage Sensed At SBEC (DTC 42)
- NS-13A: Checking Idle Speed Motor Operation
- NS-13B: Checking Idle Speed Motor Operation
- NS-13C: Checking Idle Speed Motor Operation
- NS-13D: Checking Idle Speed Motor Operation
- NS-13E: Checking Idle Speed Motor Operation
- NS-14A: Performing No Fault Code Mechanical Test
- DRIVEABILITY Tests Dr-1A To Dr-49A
- Notes
- Dr-1A: Checking System For Faults
- Dr-1B: DRB-II Fault Messages
- Dr-2A: No Change In Map From Start To Run (DTC 13)
- Dr-3A: Map Voltage Too Low (DTC 14)
- Dr-4A: Map Voltage Too High (DTC 14)
- Dr-5A: No Vehicle Speed Signal (DTC 15)
- Dr-6A: O2 Signal Stays At Center (DTC 21)
- Dr-7A: O2 Signal Shorted High (DTC 21)
- Dr-8A: Coolant Sensor Voltage Too High (DTC 22)
- Dr-9A: Coolant Sensor Voltage Too Low (DTC 22)
- Dr-10A: Charge Temperature Sensor Voltage High (DTC 23)
- Dr-11A: Charge Temperature Voltage Low (DTC 23)
- Dr-12A: Throttle Position Sensor Voltage High (DTC 24)
- Dr-13A: Throttle Position Sensor Voltage Low (DTC 24)
- Dr-14A: Automatic Idle Motor Circuits (DTC 25)
- Dr-15A: Injector No. 1 Peak Current Not Reached (DTC 26)
- Dr-16A: Injector No. 1 Control CKT & Peak Current Not Reached (DTC 27 & 26)
- Dr-17A: Injector No. 2 Peak Current Not Reached (DTC 26)
- Dr-18A: Codes 27 & 26, Injector No. 2 Control CKT & Peak Current Not Reached (DTC 27 & 26)
- Dr-19A: Injector No. 3 Peak Current Not Reached (DTC 26)
- Dr-20A: Injector No. 3 Control CKT & Peak Current Not Reached (DTC 27 & 26)
- Dr-21A: Purge Solenoid Circuit (DTC 31)
- Dr-22A: EGR Solenoid Circuit (DTC 32)
- Dr-23A: EGR System Failure (DTC 32)
- Dr-24A: A/C Clutch Relay Circuit (DTC 33)
- Dr-25A: A/C Clutch Relay Circuit (DTC 33)
- Dr-26A: Radiator Fan Relay Circuit (DTC 35)
- Dr-27A: Radiator Fan Relay Circuit (DTC 35)
- Dr-28A: Code 42, No Auto Shutdown (ASD) Relay Voltage Sensed At SBEC (DTC 42)
- Dr-29A: Ignition Coil No. 1 Primary Circuit (DTC 43)
- Dr-30A: Ignition Coil No. 2 Primary Circuit (DTC 43)
- Dr-31A: Ignition Coil No. 3 Primary Circuit (DTC 43)
- Dr-32A: SBEC Failure EMR Mileage Not Stored & EEPROM Write Denied (DTC 63)
- Dr-33A: Checking Secondary Ignition & Timing
- Dr-34A: Checking Fuel Pressure
- Dr-34B: Checking Fuel Pressure
- Dr-35A: Checking Coolant Temperature Sensor & TPS Calibration
- Dr-36A: Checking Map Sensor Calibration
- Dr-37A: Checking Oxygen Sensor Switching
- Dr-37B: Checking Oxygen Sensor Switching
- Dr-38A: Checking Idle Motor Operation
- Dr-38B: Checking Idle Motor Operation
- Dr-38C: Checking Idle Motor Operation
- Dr-38D: Checking Idle Motor Operation
- Dr-38E: Checking Idle Motor Operation
- Dr-39A: Checking Park/Neutral Switch Input
- Dr-40A: Checking SBEC Grounds & Power Circuits
- Dr-41A: Checking EGR Operation, Federal Emissions
- Dr-42A: Checking Engine Vacuum
- Dr-43A: Checking Minimum Idle Airflow
- Dr-44A: Checking Knock Sensor Circuit
- Dr-45A: Performing No Fault Code Mechanical Test
- Dr-46A: Intermittent Test For Solenoids & Relays
- Dr-47A: Intermittent Test For Voltage Sensors
- Dr-47B: Intermittent Test For Slow Change Or No Change In Map Sensor
- Dr-48A: Intermittent Test For Automatic Idle Speed (AIS) Motor Circuits
- Dr-49A: Intermittent Test For Fuel Injectors
- Verification Procedures VER-1 To VER-3
- Engine Controls - Tests W/Codes - Body Control Computer
- Introduction
- Self-Diagnostic System
- Diagnostic Procedure
- Self-Diagnostic Tests
- Trouble Shooting Charts
- Note
- Test 1A (1 Of 2) - Vehicle Equipment & System Problems Id
- Test 1A (2 Of 2) - Vehicle Equipment & System Problems Id
- Test 2A - Electronic Cluster Diagnosis
- Test 2B - Repairing Electronic Cluster "Power Upon Entry"
- Test 3A - Electronic Cluster Fault Codes
- Test 4A - Electronic Cluster Problem Not Identified By A
- Test 4B - Electronic Cluster Odometer Failure
- Test 4C - Electronic Cluster Switch Test
- Test 5A - Identifying Faulty Gauge
- Test 6A - Repairing Temperature Gauge Problems
- Test 7A - Identifying Faulty Warning Indicator
- Test 8A - Electronic Cluster Illumination Test
- Test 8B - Electronic Cluster Illumination Test
- Test 8C - Electronic Cluster Illumination Test
- Test 8D - Electronic Cluster Illumination Test
- Test 8E - Electronic Cluster Illumination Test
- Test 8F - Electronic Cluster Illumination Test
- Test 8G - Electronic Cluster Illumination Test
- Test 8H - Repairing Mic Cluster Illumination
- Test 9A - Electro/Mechanical Cluster Diagnosis
- Test 10A - Faulty Gauge On Electro/Mechanical Cluster Id
- Test 10B - Repairing Faulty Gauge On Electro/Mechanical
- Test 11A - Electro/Mechanical Cluster Odometer Failure
- Test 12A - Faulty Warning Lamp On Premium Electro/Mechanical
- Test 12B - Faulty Warning Lamp On Base Electro/Mechanical
- Test 12C - Repairing Faulty Warning Lamp Condition
- Test 13A - Repairing Door Ajar Warning Lamp
- Test 14A - Repairing Voltage Gauge Or Voltage Lamp Problem
- Test 22A - Intermittent Wiper Problem Id
- Test 22B - Checking Controller & Wiper Switch
- Test 23A - Checking Power & Ground Supply
- Test 24A - Checking Washer Pump Operation
- Test 28A - Diagnosing Left Pod Switch & Power
- Test 28B - Checking Power & Ground Supply
- Test 28C - Checking Wiring & Body Controller For Shorts
- Test 29A - Checking Body Controller & Wiring For Shorts To
- Test 30A - Checking Left Front Door Jamb Switch & Wiring For
- Test 30B - Checking Ground Supply & Diode Assembly For Open
- Test 31A - Checking Right Front Door Jamb Switch & Wiring For
- Test 32A - Checking Side Door Jamb Switch & Wiring For Open
- Test 33A - Checking Left Pod Switch & For Open Ground
- TEST 34A - REPAIRING FAULTY REAR DOME & LIFTGATE Lamps
- Test 34B - Checking Liftgate Latch Switch & Wiring For Shorts
- Test 34C - Checking Liftgate Latch Switch & Wiring For Open
- Test 35A - Checking Diode Assembly & Liftgate Lamps Wiring
- Test 36A - Checking Key In Lamp Circuit
- Test 36B - Checking For Key In Lamp Circuit Short
- Test 36C - Checking Door Jamb CKT For Ignition Key In Lamp
- Test 37A - Headlights Will Not Turn Off
- Test 37B - Headlight Time Delay Will Not Work
- Test 39A - Diagnosing Seat Belt Warning Light Circuit
- Test 39B - Diagnosing Seat Belt Warning Light Circuit
- Test 39C - Diagnosing Seat Belt Warning Light Circuit
- Test 39D - Diagnosing Seat Belt Warning Light Circuit
- Test 42A - Diagnosing Left Front Door Ajar Circuit
- Test 43A - Diagnosing Right Front Door Ajar Circuit
- Test 44A - Diagnosing Side Front Door Ajar Circuit
- Test 45A - Diagnosing Liftgate Ajar Circuit
- Test 46A - Repairing Faulty Washer Fluid Level Switch
- Test 47A - Repairing Fuel Level Problem
- Test 48A - Repairing Fuel Level Problem
- Test 49A - Checking Wiring & Sending Unit For Proper
- Test 49B - Checking Wiring & Sending Unit For Proper
- Test 49C - Checking Wiring, Controller & Cluster For Proper
- Test 50A Verification Test
- Test 1A - General Failure Messages
- Test 1B - Testing DRB-II
- Test 2A - Testing For Ram Test Failure
- Test 3A - Testing For Cartridge Error Message
- Test 4A - Testing For Keypad Test Failure Message
- Test 5A - Testing For High Battery Message
- Test 6A - Testing For Low Battery Message
- Test 7A - CCD Bus Failure Messages
- Test 53A - Testing For Short To Battery On Bus
- Test 54A - Testing For Short To 5 Volts On Bus
- Test 55A - Testing For Short To Ground On Bus
- Test 56A - Testing For Bus (+) & Bus (-) Shorted Together
- Test 57A - Testing For No Termination On Bus
- Test 58A - Testing For Bus Bias Level Too Low
- Test 58B - Testing For Bus Bias Level Too Low
- Test 59A - Bus Bias Level Too High
- Test 59B - Bus Bias Level Too High
- Test 60A - No Bus Bias
- Test 61A - Testing For Bus (+) Open
- Test 62A - Testing For Bus (-) Open
- Test 63A - Testing For Bus (+) & Bus (-) Open
- Test 64A - Testing For Not Receiving Bus Message Correctly On
- Test 65A - No Response (*) As-Body System
- Test 66A - Testing For Electronic Instrument Cluster No
- Test 66B - Testing For Electronic Instrument Cluster No
- Test 66C - Testing Electronic Instrument Cluster For No
- Test 67A - Testing Mechanical Instrument Cluster For No
- Test 67B - Testing G5, A21, & A01 Wires For Power
- Test 67C - Testing M01 Circuit
- Test 68A - Testing A-604 Controller For No Response
- Test 70A - Testing Mechanical Instrument Cluster For No
- Test 70B - Testing G5, A21, & A01 Circuits
- Test 70C - Testing M01 Circuit
- Test 71A - Testing Engine Controller For No Response
- Test 72A - Testing For Blank DRB-II Message Screen
- Test 108A - Testing Engine Diagnostic Connector Ground & DRB-II For Correct Operation
- Test 109A - Testing For No Response On The DRB-II Screen
- Test 109B - Testing For No Response On The DRB-II Screen
- Test VER-1 - Verification Test
- Engine Controls - Tests W/O Codes - Gasoline
- Introduction
- Symptoms Diagnosis
- Notes
- No Start (Cold Engine)
- No Start (Warm Engine)
- Starts But Stalls
- Hard To Start (Cold Engine)
- Erratic Idle (Warm-Up)
- Engine Surges
- Backfiring
- Incorrect Idle Speed
- Hesitation On Acceleration
- Hesitation When Coasting
- Knocking
- Engine Misfire On All Conditions
- Insufficient Engine Power
- Poor Fuel Economy
- EXCESSIVE HC & NOx
- Intermittent Problem Diagnosis
- Intermittent Test Procedures
- Waveform (Injector) - 3.0L MFI VIN [3]
- Waveform (Injector) - 3.3L MFI VIN [R]
- Theory and Operation
- Engine Controls - Theory & Operation - Gasoline
- Introduction
- Single Board Engine Controller (SBEC)
- Input Devices
- Introduction
- A/C Switch
- Battery Voltage
- Brake Switch
- Camshaft Angle Sensor
- Charge Temperature Sensor
- Clutch Switch
- Coolant Temperature Sensor (Cts)
- Crankshaft Angle Sensor
- Detonation Sensor (3.3L)
- Hall Effect Switch
- Idle Contact Switch
- Manifold Absolute Pressure (Map) Sensor
- Optical Distributor (3.0L)
- Oxygen (O2) Sensor
- Park/Neutral (P/N) Switch
- Throttle Body Temperature Sensor (5.2L & 5.9L)
- Throttle Position Sensor (TPS)
- Transmission Gear Selection
- Vehicle Speed Sensor (VSS)
- Output Signals
- Notes
- A/C Clutch Relay
- Air Switching Solenoid
- Alternator
- Automatic Idle Speed (AIS) Motor
- Auto Shutdown (ASD) Relay
- Canister Purge Solenoid
- Check Engine Light
- Electric EGR Transducer (EET)
- Emission Maintenance Reminder (EMR) Light
- Exhaust Gas RECIRCULATION (EGR) Solenoid
- Fuel Injectors
- Idle Speed Control (ISC) Actuator
- Direct Ignition System
- Optical Ignition System
- Magnetic Ignition System (Hall Effect)
- In-Tank Fuel Pump
- Limp-In Mode
- Lock-Up Torque Converter Solenoid
- Overdrive Solenoid
- Radiator Fan Relay
- Speed Control Servo
- Fuel Delivery System Operation
- Fuel Control Operation
- Idle Speed
- Direct Ignition System (3.3L) Operation
- Optical Ignition System (3.0L)
- Magnetic Ignition System (Hall Effect)
- Ignition Timing Control System
- Air Injection System Operation
- Evaporative Emission System
- Heated Air Inlet System
- Positive Crankcase Ventilation (PCV) System
- Emission Maintenance Reminder Light
- Exhaust Gas RECIRCULATION (EGR) System
- Self-Diagnostic System
- Miscellaneous Controls
- Engine Controls - Theory & Operation - Gasoline
- Vacuum Diagrams
- Wiring Diagrams
- General Information
- Abbreviations
- Basic Trouble Shooting
- Basic Trouble Shooting - General Information
- Commonly Used Abbreviations - General Information
- Emission Control Abbreviations
- Engine Performance - Trouble Shooting - General Information
- Brakes
- Anti-Lock Brake Safety Precautions - General Information
- Map - Brake Systems
- Brake Systems
- Notes
- Map Standards Of Service
- The Map Process - Overview
- The Map Process - Overview Of Service Requirements And Suggestions
- Accelerometers
- Accumulators
- Anchor Pins
- Anti-Lock Brake Control Assembly(Module)
- Anti-Lock Brake Controller
- Anti-Lock Brake Systems
- Axle Seal
- Backing Plates
- Bleeder Screw
- Brake Abs Active Light (Blue)
- Brake Fluid
- Brake Friction Material
- Brake On - Off Switch
- Brake Pads
- Brake Pedals
- Brake Shoe Hardware
- Brake Shoes
- Brake Stoplight Switches
- Brake Warning Light (Amber)
- Brake Warning Light (Red)
- Bulb Sockets
- Bulbs And LEDS
- Caliper Hardware
- Caliper Mounting Pin
- Caliper Piston
- Caliper Shim
- Caliper Slider Pin (Bolt) Dust Boot
- Caliper Slider Pin (Bolt)
- Calipers
- Combination Valve
- Controllers
- Digital Ratio Axle Controllers And Buffers (Drab And Dram)
- Disable Switches
- Drums
- Electrical Brake Pumps
- Electrical Park Motor
- Electrical Pumps And Motors
- Electro-Magnetic Interference
- Electronic Brake Control Modulator
- Electronic Brake Distribution
- Electronic Brake Traction Control Module
- Electronic Controllers
- Electronic Traction Control
- External Brake Cable
- Flow Control Valve
- Fluid Level Sensor Switches
- Fluid
- Four Wheel Drive Switches
- Friction Material
- G Sensors
- Gaskets
- Gravitational Switches
- Grease Seal
- Height Sensing Proportioning Valve
- High Pressure Accumulator
- Hoses
- Hub
- Hydraulic Control Unit
- Hydraulic Modulators
- Hydro-Boosters
- Hydro-Electric Boosters (POWERMASTER)
- Ignition Disable Switches
- Lamp Driver Relay
- Lateral Acceleration Switches
- LEDS
- Lenses
- Low Pressure Accumulator
- Lug Nut
- Master Cylinder Cover Gasket
- Master Cylinders
- Modulators
- Motor Pack
- Motors
- Pads
- Parking Brake Cable
- Parking Brake Mechanism
- Parking Brake Shoes
- Parking Brake Switches
- Parking Brake Systems
- Pedal Travel Switches
- Pedals
- Power Distribution Center
- POWERMASTER
- Pressure Differential Switches
- Pressure Switches
- Pressure Transducers
- Proportioning Valve
- Pumps
- Relays
- RELUCTOR (Speed) Ring
- Rotors
- Self-Adjusting Systems
- Shoe Hardware
- Shoes
- Sockets
- Speed Sensor (RELUCTOR) Ring
- Speed Sensors (Electronic Wheel And Vehicle)
- Star Wheel
- Steel Brake Lines
- Stoplight Switches
- Stroke Sensor
- Switches
- Tires
- Tone Ring
- Toothed Rings (Tone Wheel)
- Traction Control System (TCS)
- Transfer Tubes
- Vacuum Boosters
- Vacuum Hoses
- Valves
- Wear Indicator
- Wheel Attachment Hardware
- Wheel Bearings, Races And Seals
- Wheel Cylinders
- Wiring Harnesses
- Yaw Rate Sensor
- Brake System CHECKSHEET
- Reason Code Explanation
- Automotive Terminology & Definitions
- Brake Systems
- Map - Routine Inspection Reference Guide
- Routine Inspection Reference Guide
- Notes
- Map Standards Of Service
- The Map Process - Overview
- The Map Process - Overview Of Service Requirements And Suggestions
- Maintenance Overview
- Antifreeze/Coolant
- Visual Inspection
- Radiator Cap Test
- Engine Fan
- Cooling System Power Flush And Refill
- Belts (Except Timing Belts)
- Belt TENSIONER
- Automatic Transmission Fluid
- Automatic Transmission Fluid Exchange & Filter Replacement
- Engine Oil
- Air Filters
- Cabin Air Filter
- Brake Fluid
- Battery
- Battery Cables
- Power Steering
- Power Steering Fluid
- Wiper Blades
- Routine Inspection CHECKSHEET
- Routine Inspection - UICS
- Brake Systems
- Drivetrain And Transmission
- Notes
- Automatic Transmission Fluid
- Clutch Master Cylinders
- Cooler Lines
- Coolers
- Differential Fluid
- Drain Plugs And Gaskets
- Filters And Screens
- Fluids And Lubricants
- Hoses, Lines, And Tubes
- Hydraulic Fluid
- Lubricants
- Manual Transmission Fluid
- Mounts (Engine, Transaxle And Transmission)
- Transfer Case Fluid
- Vacuum Hoses
- Electrical Systems
- Engine Performance And Maintenance
- Notes
- Accessory Belts
- Air Filter Elements
- Air Filter Gaskets
- Air Filter Housings And Gaskets
- Air Pump Belts
- Batteries
- Battery Connectors
- Belt Idler Assemblies (Accessory And Cam Belts)
- Belt TENSIONERS (Accessory And Cam Belt)
- Chemical Engine DECARBONIZATION
- Combustion Chamber Cleaning
- Coolant Recovery Tanks
- Coolant
- Distributor Caps
- Distributor Rotors
- Engine Cooling Systems
- Engine DECARBONIZATION
- Engine Oil Drain Plugs And Gaskets
- Engine Oil Filters And Canisters
- Engine Oil
- Fuel Filters
- Fuel Injector Cleaning
- Fuel Injectors
- Fuel System Cleaning Service
- Hose Clamps
- Hose Connectors
- Hose Couplers
- Hoses And Tubes (Fuel Lines, Radiator, Vacuum, By-Pass, Heater, Recovery Tank And Oil Coolers)
- Ignition Wires (Secondary)
- Intake Cleaning
- O2 Sensors
- PCV Breather Elements
- PCV Valves
- Radiator Caps And Pressurized Expansion Tank Caps
- Spark Plugs
- Thermostats And Housings
- Throttle Body Cleaning
- Timing Belts
- Vacuum Hoses, Tubes And Connections (Non-Metallic)
- Exhaust Systems
- Heating, Ventilation And Air Conditioning Systems
- Steering And Suspension, Wheel Alignment, Wheels And Tires
- Wheel & Tire Supplement
- Reason Code Explanation
- Automotive Terminology & Definitions
- Routine Inspection Reference Guide
- Check Lists
- Computer Relearn Procedures
- Driveline/Axles
- Drive Axle Noise Diagnosis - General Information
- Gear Tooth Contact Patterns - General Information
- Map - Drive Train & Transmission
- Drive Train & Transmission Systems
- Drivetrain And Transmission
- Notes
- Actuators (Electrical)
- Actuators (Vacuum)
- Automatic Transmission / Transaxle Assemblies/CVTS
- Automatic Transmission Fluid
- Axles
- Bearings And Races
- Bell Cranks
- Bell Housings
- Bushings (External)
- Cables (Speedometer)
- Cables (TV, Detent And Shift)
- Carrier Bearings
- Clutch Cables And Cable Housings
- Clutch Discs (Manual Transmissions)
- Clutch Forks
- Clutch Linkages (Mechanical)
- Clutch Master Cylinders
- Clutch Pedals
- Clutch Pivots
- Clutch Pressure Plates
- Clutch Release Bearings
- Clutch Slave Cylinders (Concentric)
- Clutch Slave Cylinders (Conventional Or External)
- Companion Flanges
- Connectors
- Cooler Bypass Valves
- Cooler Lines
- Coolers
- CV Joints
- Differential And Final Drive Assemblies
- Differential Fluid
- Dip Stick Tubes
- Dip Sticks (Fluid Level Indicators)
- Dowel Pins, Guides And Pilot Holes
- Drain Plugs And Gaskets
- Drive Shaft Flanges
- Drive Shafts And Half Shafts
- Dust Boots
- Engine Mounts
- Exciter Rings
- Filler Tubes
- Filters And Screens
- Flanges
- Flex Plates
- Fluid Level Indicators
- Fluids And Lubricants
- Flywheels
- Force Motors
- Gaskets
- Guides
- Half Shafts
- Hoses, Lines, And Tubes
- Housings (Bell, Case, Tail(Extension) And Auxiliary)
- Hydraulic Fluid
- Intermediate Shaft Support Bearings
- Key Interlock Systems
- Limited Slips
- Lines
- Linkages (External)
- Locking Hub Assemblies
- Locking Hub Control Knobs
- Lubricants
- Manual Transmission Fluid
- Manual Transmission/Transaxle Assemblies
- Metal Clad Seals
- METALASTIC Joints
- Modulator Pins
- Modulators
- Mounts (Engine, Transaxle And Transmission)
- Odometer Drives (Mechanical)
- Odometer Heads (Mechanical)
- Oil Pans
- Pans
- Pilot Holes
- Pressure Plates
- Pressure Switches
- Races
- Rubber Joints (METALASTIC)
- Screens
- Seals (Metal Clad)
- Seals
- Selector Interlock Systems
- Sensors
- Servos
- Shift Interlock Systems (Selector And Key Interlock Systems)
- Side Covers
- Slip Yokes
- Solenoids
- Speed Sensors (Electronic Wheel And Vehicle)
- Speedometer- Driven Gear Housing
- Speedometer/Odometer Drives (Mechanical)
- Speedometer/Odometer Heads (Mechanical)
- Speedometers/Odometers (Electronic)
- Switches
- Tone Wheels
- Toothed Rings (Tone Wheel)
- Torque Converters
- Transaxle Mounts
- Transducers (Transmission)
- Transfer Case Assemblies
- Transfer Case Fluid
- Transmission Coolers
- Transmission Mounts
- Transmission Pans
- Transmission Range Indicators (PRNDL)
- Tubes
- Universal Joints (CARDAN Or Cross Type)
- Vacuum Controls
- Vacuum Hoses
- Vacuum Motors
- Vacuum-Operated Switches
- Vehicle Speed Sensors
- Vents
- Vibration Dampers
- Wheel Attachment Hardware
- Wheel Speed Sensors
- Wiring Harnesses And Connectors
- Yokes And Slip Yokes
- Reason Code Explanation
- Automotive Terminology & Definitions
- Trouble Shooting - Clutches - General Information
- Electrical
- Map - Electrical Systems
- Electrical Systems
- Notes
- Map Standards Of Service
- The Map Process - Overview
- The Map Process - Overview Of Service Requirements And Suggestions
- Actuator Motors (Electric)
- Actuator Motors (Vacuum)
- Air Bags
- Alternators And Generators
- Amplifiers
- Antennas
- Batteries
- Battery Cables, Wires And Connectors
- Battery Cables
- Battery Trays And Hold Down Hardware
- Battery Wires
- Belts
- Bulb Sockets
- Bulbs, Sealed Beams And LEDS
- Cd Players
- Cigarette Lighter Assemblies
- Circuit Breakers
- Clutch Switches
- Connectors
- Control Modules
- Cruise Control Brake Switches
- Cruise Control Cables
- Cruise Control Clutch Switches
- Cruise Control Linkages And Cables
- Cruise Control Reservoirs
- Cruise Control Tubes
- Cruise Control Vacuum Dump Release Valves
- Cruise Control Vacuum Hoses, Tubes And
- Cruise Control Vehicle Speed Sensors
- Defoggers
- Defrosters
- Delays
- Dimmers
- Electric Heaters
- Equalizers
- Fuse Blocks
- Fuse Boxes And Blocks
- Fuses, Fusible Links And Circuit Breakers
- Fusible Links
- Gauges
- Generators
- Ground Cables And Straps
- Ground Straps
- Headlight Adjusters
- Heating Elements (Defrosters, Defoggers, Electric Heaters And Seats)
- Horns And Sirens
- Ignition Switches
- Indicator Lights
- Keyless Entry Keypads And Transmitters
- Keyless Entry Transmitters
- LEDS
- Lenses
- Microphones
- Mirrors (ELECTROCHROMATIC And Heated)
- Motors
- Neutral Safety Switches
- Odometers, Speedometers And Tachometers (Cable Driven)
- Odometers
- Power Distribution Center
- Pulleys
- Receivers, Amplifiers, Equalizers And Sub-Woofer Volume Controls
- Relay Boxes
- Relays
- Sealed Beams
- Seat Heaters
- Security Alarm Sensors
- Sirens
- Solenoids
- Speakers And Microphones
- Speedometer And Tachometer Linkages And Cables
- Speedometer Cables
- Speedometers
- Starters
- Sub-Woofer Volume Control
- Switches
- Tachometer Cables
- Tachometers
- Tape Players And Cd Players
- TENSIONERS
- Timers
- Transceivers
- Transducers
- Vacuum Accumulators (Reservoirs)
- Voltage Regulators
- Washer Fluid Level Senders
- Washer Pumps
- Wiper Arms And Blades
- Wiper Blades
- Wiper Hoses And Nozzles
- Wiper Linkages
- Wiper Nozzles
- Wiper Pump Reservoirs
- Wiring Harnesses And Connectors
- Battery, Starting & Charging System CHECKSHEET
- Reason Code Explanation
- Automotive Terminology & Definitions
- Electrical Systems
- Using lemon2025'S System Wiring Diagrams
- Map - Electrical Systems
- Engine
- Engine Overhaul Procedures - General Information
- * Please Read This First *
- Description
- Engine Identification
- Inspection Procedures
- Cleaning Procedures
- Component Cleaning
- Cylinder Head Replacement
- Cylinder Head Overhaul
- Pistons, Connecting Rods & Bearings
- Crankshaft & Main Bearings
- Camshaft
- Timing Chains & Belts
- Timing Gears
- Oil Pump
- Break-In Procedure
- General Cooling System Service - General Information
- Engine Overhaul Procedures - General Information
- Engine Performance
- Electrostatic Discharge Warning - General Information
- Engine Performance Diagnostic Routine Outline - General Information
- Engine Performance Safety Precautions
- Map - Engine Performance & Maintenance
- Engine Performance And Maintenance (Including Exhaust Systems)
- Engine Performance & Maintenance CHECKSHEET
- Engine Performance And Maintenance
- Notes
- Accelerator Pedal Position Sensor
- Accessory Belts
- Accessory Pulleys
- Air Conditioning Cycling Switches
- Air Conditioning Pressure Sensors
- Air Ducts And Tubes
- Air Filter Elements
- Air Filter Gaskets
- Air Filter Housings And Gaskets
- Air Fuel Ratio Sensors
- Air Injection Control Solenoids
- Air Plenums
- Air Pump Belts
- Air Pumps (Electric Driven)
- Air Tubes
- Aspirator, Check And DECEL Valves
- Baffles
- Ballast Primary Supply Resistor Wires
- Ballast Resistors And Primary Supply Resistors
- Barometric Pressure Sensors
- Batteries
- Battery Cables, Wires And Connectors
- Battery Connectors
- Battery Trays And Hold Down Hardware
- Battery Wires
- Belt Idler Assemblies (Accessory And Cam Belts)
- Belt TENSIONERS (Accessory And Cam Belt)
- Belt-Driven Air Pumps
- Boost Control Mechanism
- Camshaft Position Sensors
- Carburetors And Chokes
- Casting Core Plugs And Expansion Plugs
- Charge Air Coolers ""INTERCOOLERS"" (CAC)
- Check Valves
- Chemical Engine DECARBONIZATION
- Chokes
- Clutch Pedal Position Switches
- Cold Start Injectors
- Combustion Chamber Cleaning
- Connectors
- Coolant Recovery Tanks
- Coolant
- Cooling Fan Motor Modules
- Cooling Fan Motor Relays And Modules
- Cooling Fan Motor Resistors
- Cooling Fan Motor Sensors And Switches
- Cooling Fan Motor Switches
- Cooling Fan Motors
- Crankshaft Position Sensors
- Cylinder Deactivation Solenoid
- Cylinder Head Assemblies
- DECEL Valves
- Deflectors
- Dip Stick Tubes
- Dip Sticks And Tubes
- Distributor Advances And Retarders (Mechanical And Vacuum)
- Distributor Boots And Shields
- Distributor Caps
- Distributor Retarders (Mechanical And Vacuum)
- Distributor Rotors
- Distributor Shields
- Distributors
- Early Fuel Evaporation Valves (Heat Riser Assemblies)
- EGR Coolers
- EGR Exhaust Manifold Passages
- EGR Intake And Exhaust Manifold Passages
- EGR Plates And Coolers
- Electronic Spark Control Modules
- Electronic Transmission Control Devices
- Electronic Transmission Feedback Devices
- Engine Coolant Temperature Sensors
- Engine Cooling Systems
- Engine Covers (Oil Pan, Valve Cover, Timing Cover)
- Engine DECARBONIZATION
- Engine Oil Canisters
- Engine Oil Coolers (External)
- Engine Oil Drain Plugs And Gaskets
- Engine Oil Filters And Canisters
- Engine Oil Gaskets
- Engine Oil Pressure Gauges (Mechanical)
- Engine Oil
- Evaporative Emissions (EVAP) Canister Filters
- Evaporative Emissions (EVAP) Canister Purge Devices
- Evaporative Emissions (EVAP) Canisters
- Evaporative Emissions (EVAP) Feedback Devices
- Exhaust Gas RECIRCULATION Devices
- Exhaust Gas RECIRCULATION Feedback Devices
- Expansion Plugs
- Fan Control Sensor
- Fuel Accumulators And Dampers
- Fuel And Cold Start Injectors
- Fuel Caps
- Fuel Dampers
- Fuel Delivery Check Valves
- Fuel Distributors (BOSCH Cis)
- Fuel Filler Necks And RESTRICTORS
- Fuel Filters
- Fuel Injector Cleaning
- Fuel Injectors
- Fuel Level Senders
- Fuel Pressure Regulators
- Fuel Pumps (In-Tank, External, Electrical Or Mechanical)
- Fuel Rails
- Fuel RESTRICTORS
- Fuel System Cleaning Service
- Fuel Tanks
- Fuel
- Gaskets
- Grommets (Valve Cover)
- Harmonic Dampers
- Heater Control Valves
- Heater Cores
- Hose Clamps
- Hose Connectors
- Hose Couplers
- Hoses And Tube Couplers, Connectors And Clamps
- Hoses And Tubes (Fuel Lines, Radiator, Vacuum, By-Pass, Heater, Recovery Tank And Oil Coolers)
- Housings
- Idle Air Controls
- Idle Speed Control Actuators
- Ignition Boots
- Ignition Coil Towers
- Ignition Coils
- Ignition Control Modules (ICM)
- Ignition Switches
- Ignition Terminals
- Ignition Wires (Secondary)
- Inertia Fuel Shut-Off Switches
- Intake Air Temperature Sensors
- Intake Cleaning
- Intake Manifolds
- In-Tank Fuel Strainers
- INTERCOOLERS
- Knock Sensors
- Liquid Vapor Separators
- Long Block Assemblies
- Manifold Absolute Pressure (Map) Sensors
- Mass Air Flow (MAF) Sensors
- Metal Air Manifolds And Pipes
- Metal Air Pipes
- Mix Control Solenoids
- Motor Mounts
- O2 Sensors
- Oil Pans
- Oil Pressure Sending Units
- Oil Pump Pick-Up Screens
- Oil Pumps
- O-Rings, Gaskets, Seals And Spring Locks
- Park Neutral Position Switches
- PCV Breather Elements
- PCV Orifices
- PCV Valves
- Pick-Up Assemblies (Includes Magnetic, Hall Effect And Optical)
- Power Steering Pressure Sensors
- Powertrain Control Modules (Pcm) And Prom
- Powertrain Control Prom
- Pressurized Expansion Tank Caps
- Radiator / Cooling Fan Blades
- Radiator / Cooling Fan Clutches
- Radiator Caps And Pressurized Expansion Tank Caps
- Radiators
- Roll Over Valves
- Sealing Compounds
- Seals
- Secondary Air Injection System Management Devices
- Sensors
- Short Block Assemblies
- Shrouds, Baffles And Deflectors
- Spark Plugs
- Spring Locks
- Super Chargers
- Switches
- Thermal Vacuum Valves
- Thermostatic Air Door Assemblies
- Thermostats And Housings
- Throttle Bodies
- Throttle Body Cleaning
- Throttle Cables
- Throttle Linkages And Cables
- Throttle Position Sensors
- Throttle Position Switches
- Timing Belt Sprockets
- Timing Belts
- Timing Covers
- Torque Struts
- Transmission Range Switches
- Tube Clamps
- Tube Connectors
- Tube Couplers
- Tubes
- Turbo Chargers
- Vacuum Connections
- Vacuum Hoses, Tubes And Connections (Non-Metallic)
- Vacuum Regulator Solenoids
- Vacuum Tubes
- Valve Covers
- Vehicle Speed Senors
- Volume Air Flow Sensors
- Waste Gate And Boost Control Mechanisms
- Waste Gate Control Solenoids
- Water Pumps (Electric)
- Water Pumps (Non-Electric)
- Wiring Harnesses And Connectors
- Reason Code Explanation
- Automotive Terminology & Definitions
- Parasitic Load Explanation & Test Procedures - General Information
- State Emission Standards - Diesel
- State Emission Standards - Gas
- ALASKA
- ARIZONA
- CALIFORNIA
- Colorado
- CONNECTICUT
- DELAWARE
- District Of COLUMBIA
- GEORGIA
- IDAHO
- ILLINOIS
- INDIANA
- KENTUCKY
- MARYLAND
- MASSACHUSETTS
- MISSOURI
- NEVADA
- New Jersey
- New MEXICO
- New YORK
- North CAROLINA
- OHIO
- OREGON
- PENNSYLVANIA
- RHODE Island
- TENNESSEE
- TEXAS
- UTAH
- VIRGINIA
- WASHINGTON
- WISCONSIN
- U. S. EPA ASM2525 & ASM5015 Start-Up Emission Standards
- U. S. EPA Revised Final ASM Emission Standards (ASM5015 & ASM2525)
- U.S. EPA Im240 Emission Standards
- Waveforms - Injector Pattern Tutorial - General Information
- * Please Read This First *
- Purpose Of This Article
- Is A Lab Scope Necessary?
- The Two Types Of Injector Drivers
- The Two Ways Injector Circuits Are Wired
- Interpreting Injector Waveforms
- Current Waveform Samples
- Notes
- Example #1 - Voltage Controlled Driver
- Example #2 - Voltage Controlled Driver
- Example #3 - Voltage Controlled Driver
- Example #4 - Current Controlled Driver
- Example #5 - Current Controlled Driver
- Example #6 - Current Controlled Driver
- Example #7 - Current Controlled Driver
- Example #8 - Current Controlled Driver
- Voltage Waveform Samples
- Notes
- Example #1 - Voltage Controlled Driver
- Example #2 - Voltage Controlled Driver
- Example #3 - Voltage Controlled Driver
- Example #4 - Current Controlled Driver
- Example #5 - Current Controlled Driver
- Example #6 - Current Controlled Driver
- Example #7 - Current Controlled Driver
- Example #8 - Current Controlled Driver
- Map - Exhaust Systems
- Exhaust Systems
- Notes
- Map Standards Of Service
- The Map Process - Overview
- The Map Process - Overview Of Service Requirements And Suggestions
- Catalytic Converters
- Exhaust And Tail Pipes
- Exhaust Connections
- Hangers
- Heat Risers (Mechanical EFE Devices)
- Heat Shields
- Manifolds (Cast And Tube Type)
- Mechanical EFE Devices
- Muffler Valve
- Mufflers And Resonators
- Reason Code Explanation
- Exhaust Systems
- Heating, Ventilation & A/C (HVAC)
- Map - Heating, Ventilation, & Air Conditioning
- Heating, Ventilation & Air Conditioning Systems
- Notes
- Map Standards Of Service
- The Map Process - Overview
- The Map Process - Overview Of Service Requirements And Suggestions
- Accumulators
- Actuators (Electrical)
- Actuators (Vacuum)
- Air Conditioning Fittings
- Air Conditioning Hoses
- Air Conditioning Metal Lines
- Air Control Doors
- Air Dams (External)
- Air Distribution System
- Belts
- Blend Doors
- Blower Fans (Blower Wheel Or Squirrel Cage)
- Blower Motors
- Blower Resistors
- Blower Switches
- Cabin Air Filters
- Circuit Breakers
- Compressor Clutch Assemblies
- Compressors
- Condenser Air Seals
- Condenser Fan Motors
- Condensers
- Connectors
- Control Cables
- Control Heads (Function Selectors)
- Control Linkages
- Control Modules
- Coolant
- Cooling Fan Blades
- Cooling Fan Clutches
- Cooling Fan Motors
- Evaporator Drain Tubes
- Evaporator Filters
- Evaporator Pressure Regulators (EPRS)
- Evaporators
- Expansion Valves
- Function Selectors
- Fuses, Fusible Links And Circuit Breakers
- Fusible Links
- Gaskets
- Heater Cases
- Heater Control Valves
- Heater Cores
- Heater Hoses
- High Pressure Relief Valves (HPRV)
- Idlers
- In-Line Filters
- Metal Fittings
- Metal Lines
- Mix And Air Control Doors (Blend Doors)
- ORIFACE Tubes
- O-Rings
- Pilot-Operated Absolutes (POAS)
- Plenums
- Pressure Control Valves
- Pressure Sensors
- Pulleys
- Radiators
- Receiver-DRIERS
- Refrigerant Oil
- Refrigerant
- Relays
- Seals
- Service Ports
- Spring Lock Couplings
- Suction Throttling Valves (STVS)
- Switches (Electrical)
- TENSIONERS
- Thermistors And Pressure Sensors
- Thermostats And Housings
- Vacuum Hoses And Tubes
- Vacuum Reservoirs
- Vacuum Tubes
- Valves In Receiver (VIRS)
- Water Pumps (Electric Auxiliary)
- Wiring Harnesses And Connectors
- Heating, Ventilation & Air Conditioning System CHECKSHEET
- Reason Code Explanation
- Automotive Terminology & Definitions
- Heating, Ventilation & Air Conditioning Systems
- Map - Heating, Ventilation, & Air Conditioning
- Identification
- Metric Conversions
- OEM General Information
- How To Use The Engine Performance Section
- Maintenance Reminder Light (Reset Procedures)
- Emissions Maintenance Reminder (EGR)
- Emissions Maintenance Reminder (EMR Mileage)
- Emissions Maintenance Reminder (MAINT REQD Or Check EGR)
- Emissions Maintenance Reminder (Sri)
- Engine Oil Replacement Reminder
- Maintenance Service Reminder (ASSYST Maintenance Computer)
- Maintenance Service Reminder (Perform Service)
- Maintenance Service Reminder (Service Reminder Indicator)
- Maintenance Service Reminder (Service Reminder Message)
- Tire Pressure Monitor System Reminder
- Air Bag Restraints & SRS Components - Inspection & Replacement Tables
- Steering
- Map - Steering, Suspension, Wheel Alignment, Wheels & Tires
- Steering & Suspension Systems
- Wheel And Tire
- Steering & Suspension CHECKSHEET
- Wheels & Tires CHECKSHEET
- Steering And Suspension, Wheel Alignment, Wheels And Tires
- Notes
- Active Handling
- Active Suspension Control Modules
- Active Variable Ratio Steering
- Active Yaw Control
- Adaptive Cruise Control
- Advance TRAC
- Air Bags
- Air Ride Control Modules
- Air Ride Suspension Torsion Springs (Counter Balancing)
- Air Ride Suspension
- Air Ride Tubes
- Air Shocks And Air Struts
- Air Spring Valves
- Air Springs
- Air Suspension Control Valves
- Air Suspension DRIERS
- Axle Acceleration Sensor
- Ball Joints
- Body Acceleration Sensor
- Bushings
- Center Links
- Compressors
- Continuous Damping Control
- Control Arm Shafts
- Control Arms
- Control Modules
- Distance Regulation Control Module
- Distance Regulation Sensor
- Drag Links
- Dynamic Stability Control
- Dynamic Stability Traction Control
- Electronic Ride Control Shocks And Struts
- Electronic Stability Control
- Electronic Suspension System
- Flex Couplers
- Gaskets
- Height Sensors
- Hydraulic Hoses
- Hydraulic Power Steering Pumps
- Hydraulic Suspension Hoses
- Hydraulic Suspension Pumps
- Idler Arms
- Intermediate Shaft U-Joints
- King Pins
- Modules
- Pitman Arms
- Power Steering Belts
- Power Steering Coolers
- Power Steering Fluid
- Power Steering Hoses
- Power Steering Lines (Steel)
- Power Steering Pumps - Electric
- Power Steering Pumps
- Radar Sensor
- Radius Arms
- Relay Rods
- Relays
- Sensors
- Shock Absorbers, Strut Cartridges And Strut Assemblies
- Spindles
- Springs, Coil, Leaf And Torsion Bars
- STABILITRAC
- Stability Management System
- Steering Angle Sensor
- Steering Arms
- Steering Couplers
- Steering Dampers
- Steering Gears (Except Rack And Pinion)
- Steering Gears, Rack And Pinion
- Steering Knuckles
- Strike Out Bumpers
- Strut Bearing Plate Assemblies
- Strut Rods
- Suspension Pumps (Hydraulic)
- Sway Bar Links
- Sway Bar Mounting Bushings
- Sway Bars
- Switches
- Tie Rod Ends (Inner And Outer)
- Tire Pressure Monitoring System
- Tire Pressure Sensors
- Tires
- Torque Sensor
- Torsion Springs
- Track Bar Bushings
- Track Bars
- Trailing Arm Bushings
- Trailing Arms
- Valve Stems
- Vehicle Dynamics Control
- Vehicle Speed Sensor
- Vehicle Stability Assist
- Vehicle Stability/Skid Control
- Warning Lamps
- Wheel Alignment
- Wheel Attachment Hardware
- Wheel Bearings, Races And Seals
- Wheels (Rims)
- Wiring Harnesses And Connectors
- Reason Code Explanation
- Automotive Terminology & Definitions
- Wheel Alignment Theory & Operation - General Information
- Map - Steering, Suspension, Wheel Alignment, Wheels & Tires
- Trouble Shooting - Manual Transmission - General Information
- Heating, Ventilation & A/C (HVAC)
- General Servicing
- A/C Compressor Oil Checking
- Isolating Compressor
- Refrigerant Oil
- Servicing Precautions
- CHRYSLER C-171 & C-171/A590 Compressor Oil Checking
- C-171 & C-171/A590 Refrigerant Oil Capacities
- NIPPONDENSO 6C-17 Compressor Oil Checking
- NIPPONDENSO 6C-17 Refrigerant Oil Capacities
- NIPPONDENSO 6E-171 & 6P-148 Compressor Oil Checking
- NIPPONDENSO 10PA17 Compressor Oil Checking (Laser & Talon)
- 10PA17 Refrigerant Oil Capacities (Laser & Talon)
- 10PA17 Compressor Oil Checking (Except Laser & Talon)
- 10PA17 Refrigerant Oil Capacities (Except Laser & Talon)
- SANDEN Tr-105 6-CYL Compressor Oil Checking
- SANDEN SD-709 7-CYL Compressor Oil Checking
- SANDEN SD-709 Compressor Oil Capacities
- A/C Compressor Overhaul
- CHRYSLER C-171 & C-171/A590 Clutch Assembly R & I
- CHRYSLER C-171 & C-171/A590 Shaft Seal R & I
- NIPPONDENSO 6C-17 Clutch Assembly R & I
- NIPPONDENSO 6C-17 Shaft Seal R & I
- NIPPONDENSO 10PA17 & 10PA17A Clutch Assembly R & I
- NIPPONDENSO 10PA17 & 10PA17A Shaft Seal R & I
- SANDEN FX-105 Vs Clutch Assembly R & I
- SANDEN FX-105 Vs Shaft Seal R & I
- SANDEN SD-709 Clutch Assembly R & I
- SANDEN SD-709 Shaft Seal R & I
- SANDEN Tr-105 Clutch Assembly R & I
- SANDEN Tr-105 Shaft Seal R & I
- A/C System General Servicing
- Using R-12 Refrigerant - Safety Precautions
- Using Individual R-12 Cans
- Multi-Can Dispensing Valves
- Can Tap Installation
- Sight Glass Indicators
- 1990 Service Valve Location Table
- 1991 System Service Valve Locations
- Stem-Type Valve Operation
- SCHRADER-Type Valve Operation
- Manifold Gauge Set
- Connecting Gauge Set
- Purging Test Hoses
- Stabilizing A/C System
- Pressure Gauge Indications
- Excessive Moisture Gauge Readings
- Defective Thermostatic Switch Gauge Readings
- MISADJUSTED Thermostatic Switch Gauge Readings
- Defective Clutch Cycling Switch Pressure Gauge Readings
- Low R-12 Charge Gauge Readings
- Very Low R-12 Charge Gauge Readings
- Orifice Tube Plugged Gauge Readings
- Expansion Or "H" Valve Stuck Closed
- Expansion Or "H" Valve Stuck Open Gauge Readings
- Compressor Malfunction Gauge Readings
- Condenser Malfunction Or R-12 Overcharge Gauge Readings
- Orifice Tube R & I - 1990 MONACO
- Orifice Tube R & I - 1991 MONACO
- Refrigerant Recovery
- Discharging A/C System
- Flushing A/C System
- Evacuating A/C System
- Charging A/C System - MONACO
- Charging A/C System All Others
- Leak Testing All Manufacturers
- A/C System Precautions
- Before Opening The System
- Discharging A/C System
- Disconnecting Lines & Fittings
- Component Replacement
- Using R-12 Refrigerant - Safety Precautions
- Using Individual R-12 Cans
- Multi-Can Dispensing Valves
- Can Tap Installation Flat Type Seal Cans
- Screw Type Seal Cans
- Connecting Lines & Fittings
- Placing System In Operation
- Compressor Removal Information - Isolation Method
- Compressor Removal Information - Discharge Method
- A/C System Specifications
- A/C Compressor Oil Checking
- HVAC Control Systems
- A/C-Heater System - Manual
- *Please Read This First*
- A/C System Specifications
- Description
- Operation
- A/C Button Operation
- Blower Switch Operation
- Temperature Lever Operation
- Ambient Switch Operation (3.0L/3.3L)
- Condenser Fan Control Switch Operation (3.0L/3.3L)
- Electronic Cycling Clutch Switch Operation (2.5L)
- High Pressure Cut-Out Switch Operation (3.0L/3.3L)
- Low Pressure Cut-Off Switch Operation
- High Pressure Relief Valve Operation
- Servicing Precautions
- Air Bag Deactivation
- Adjustments
- Troubleshooting
- Testing
- A/C Compressor Clutch Test
- A/C Clutch Coil Test
- Ambient Switch Test (3.0L/3.3L)
- Condenser Fan Control Switch Test (3.0L/3.3L)
- Electronic Cycling Clutch Switch (ECCS) 2.5L
- Expansion Valve Testing (2.5L)
- Expansion Valve Testing (3.0/3.3L)
- High Pressure Cut-Out Switch Test (3.0L/3.3L)
- Low Pressure Cut-Off Switch Test (2.5L)
- Low Pressure Cut-Off Switch Test (3.0/3.3L)
- Removal & Installation
- Notes
- A/C Compressor R & I
- Air Distribution Duct R & I
- Ambient Switch R & I (3.0L/3.3L)
- Blower Motor R & I
- Blower Motor Switch R & I
- Blower Motor Resistor R & I
- Condenser R & I
- Condenser Fan Control Switch R & I
- Condenser Fan Control Switch R & I (3.0L/3.3L)
- Defroster Duct R & I
- Electronic Cycling Clutch Switch (ECCS) R & I (2.5L)
- Evaporator Core & Heater Core R & I
- Evaporator/Heater Unit R & I
- Expansion Valve R & I
- Heater & A/C Control Panel R & I
- Heater (Water) Control Valve R & I
- High Pressure Cut-Off Switch R & I (3.0L/3.3L)
- High Pressure Relief Valve R & I (2.5L)
- High Pressure Relief Valve R & I (3.0L/3.3L)
- Instrument Panel R & I
- Low Pressure Cut-Off Switch R & I
- Receiver-Drier R & I
- Temperature Control Cable R & I
- Vacuum Actuators R & I
- Wiring Diagrams
- A/C-Heater System - Manual (Rear)
- *Please Read This First*
- Description
- Air Bag Deactivation
- System Controls Operation
- A/C-Heat Control Switch Operation
- Blower Motor Switch Operation
- Servicing Precautions
- Air Bag Deactivation - Disabling System
- Air Bag System Functional Check
- Blower Motor Diagnosis
- Testing
- Removal & Installation
- Wiring Diagrams
- A/C-Heater System Trouble Shooting - Manual
- Vacuum Control 1-Way Check Valve Diagnosis - Cars & Fwd Vans
- Vacuum Controls Diagnosis - Cars & Fwd Vans
- Vacuum Controls Diagnosis - RWD Trucks & Vans
- Blower Motor & Control System Diagnostic Charts
- Compressor & Compressor Clutch Diagnostic Charts
- C171/A590/10PA17 & 6C17 Compressor Diagnostic Charts
- A/C Diagnostic Chart - DAKOTA, RAMCHARGER, B/D/W Series
- Heater System
- Description
- Operation
- Air Bag Precautions
- Air Bag Deactivation
- Adjustments
- Trouble Shooting
- Removal & Installation
- Vacuum Hose Diagram(S)
- Wiring Diagrams
- A/C-Heater System - Manual
- General Servicing
- Maintenance
- Procedures
- Interference Verification Check For OHC Engine
- Maintenance Information
- Model Identification
- Maintenance Service Information
- Service Point Locations
- All Wheel Drive Service Information
- Service Labor Times
- Wheel & Tire Specifications
- Battery Specifications
- Cautions & Warnings
- Supplemental Restraint System (SRS) Air Bag System
- Anti-Lock Brake System (Abs)
- Battery Warning
- Replacing Blown Fuses
- Brake Pad Wear Indicator
- Catalytic Converter
- Coolant (Propylene-Glycol Formulations)
- Electrostatic Discharge Sensitive (ESD) Parts
- Engine Oil
- Fuel System Service
- Halogen Bulbs
- Radiator Cap
- Radiator Fan
- Warranty Information
- Notes
- Basic New Car Limited Warranty (1990-94)
- Powertrain Warranty
- Owner's Choice Coverage
- Air Bag Limited Warranty
- Customer One Care Warranty (1995)
- Basic New Car Limited Warranty (1995)
- Corrosion Coverage
- Emission System "Defect" & "Performance" Warranties (Except CALIFORNIA)
- Emission "Performance" Warranty (CALIFORNIA)
- Emission "Defect" Warranty (CALIFORNIA)
- Roadside Assistance (1995)
- Fuses & Circuit Breakers
- Maintenance Reminder Light (Reset Procedures)
- Emissions Maintenance Reminder (EGR)
- Emissions Maintenance Reminder (EMR Mileage)
- Emissions Maintenance Reminder (MAINT REQD Or Check EGR)
- Emissions Maintenance Reminder (Sri)
- Engine Oil Replacement Reminder
- Maintenance Service Reminder (ASSYST Maintenance Computer)
- Maintenance Service Reminder (Perform Service)
- Maintenance Service Reminder (Service Reminder Indicator)
- Maintenance Service Reminder (Service Reminder Message)
- Tire Pressure Monitor System Reminder
- Service Indicator & Warning Lights
- Procedures
- Restraints
- Air Bag, SRS
- Air Bag Restraint System
- Description & Operation
- Servicing
- System Operation Check
- Post-Collision Inspection
- Service Precautions
- Disabling & Activating Air Bag System
- Adjustments
- Disposal Procedures
- Removal & Installation
- Diagnosis & Testing
- Diagnostic Charts
- Notes
- Air Bag System Function Test
- Test 2A - No Response Message
- Test 3A - Air Bag Module Codes
- Test 4A - ASDM Module Repair Procedure
- Tests 5A & 5B - Front Sensor Open
- Tests 6A & 7A - Initiator Open
- Test 8A - SAFING Sensor - Repair Procedures For Short
- Tests 9A & 9B Front Sensor Shorted
- Tests 11A & 11B - Low Stored Energy
- Tests 12A & 12B - Ignition 2 Low
- Test 13A - Warning Light Circuit Open
- Test 14A - Warning Light Circuit Shorted
- Tests 15A & 15B - Ignition 1 Low
- Verification Test
- Wire Repair
- Torque Specifications
- Air Bag Restraint System - Post-Collision Air Bag Safety Inspection
- Air Bag Restraint System
- Air Bag, SRS
- Steering
- Manual Steering
- Power Steering General Servicing
- Steering System - Power
- Power Steering
- Power Steering General Servicing
- Steering System - Power
- Steering Column
- Manual Steering
- Suspension
- Front Suspension
- Rear Suspension
- Wheel Alignment
- Transmission
- Automatic Trans
- Diagnosis - A-604/41TE
- Diagnosis - CHRYSLER
- Application
- Identification
- Description & Operation
- Troubleshooting
- Torque Converter Clutch Lock-Up
- Notes
- No Torque Converter Clutch Lock-Up
- Torque Converter Clutch Will Not Unlock
- Torque Converter Clutch Stays Locked-Up When Low Speed In Drive
- Torque Converter Lock-Up Clutch Locks Up Or Drags In Low Or 2nd Gear
- Engine Stalls Or Is Sluggish In Reverse
- Loud Chatter During Torque Converter Clutch Lock-Up When Cold
- Vibration Or Shudder During Torque Converter Clutch Lock-Up
- Vibration Or Shudder After Torque Converter Clutch Lock-Up
- Overdrive Unit
- Delayed 3-4 Upshift
- No Reverse Or Slips In Reverse
- No 1-2 Or 2-3 Upshift (Has Low & Reverse)
- No 3-4 Upshift
- No 4-3 Downshift
- No 4-3 Downshift With Overdrive Switch Off
- Noisy Operation In 4th Gear Only
- Slips In 4th Gear
- Torque Converter Locks Up In 2nd And/Or 3rd Gear
- 3-4 Upshift Occurs Before Completing 2-3 Upshift
- Torque Converter Clutch Lock-Up
- Self-Diagnostic System
- Diagnostic Tests
- Notes
- Diagnostic Tests (1991 Models)
- Test DR-1A (2.2L & 2.5L)
- Test DR-1A (5.9L Diesel)
- Test DR-1A (3.9L, 5.2L & 5.9L Gasoline)
- Test 7A (5.9L Diesel)
- Test 8A (5.9L Diesel)
- Test DR-26A (3.9L, 5.2L & 5.9L)
- Test DR-26B (3.9L, 5.2L & 5.9L)
- Test DR-28A (2.2L & 2.5L)
- Test DR-28A (3.9L, 5.2L & 5.9L)
- Test DR-29A (3.9L, 5.2L & 5.9L)
- Test DR-42A (2.2L & 2.5L)
- Test DR-46A (3.9L, 5.2L & 5.9L)
- Test VER-1 (5.9L DIESEL)
- Test VER-2 (2.2L & 2.5L)
- Test VER-2 (3.9L, 5.2L & 5.9L)
- Test VER-3 (2.2L & 2.5L)
- Test VER-3 (3.9L, 5.2L & 5.9L)
- Diagnostic Tests (1992 Models)
- Test DR-1A (2.2L, 2.5L, 2.5L Turbo & 3.0L)
- Test DR-1A (3.9L & 5.2L)
- Test DR-1A (5.9L Gasoline)
- Test DR-1A (5.9L Diesel)
- Test DR-10A (5.9L Diesel)
- Test DR-16A (5.9L Diesel)
- Test DR-24A (5.9L Gasoline)
- Test DR-24B (5.9L Gasoline)
- Test DR-25A (5.9L Gasoline)
- Test DR-26A (2.2L, 2.5L, 2.5L Turbo & 3.0L)
- Test DR-26A (5.9L Gasoline)
- Test DR-30A (3.9L & 5.2L)
- Test DR-30B (3.9L & 5.2L)
- Test DR-31A (3.9L & 5.2L)
- Test DR-32A (3.9L & 5.2L)
- Test DR-32B (3.9L & 5.2L)
- Test DR-33A (5.9L Gasoline)
- Test DR-34A (2.2L, 2.5L, 2.5L Turbo & 3.0L)
- Test NF-2A (5.9L Diesel)
- Test NF-2B (5.9L Diesel)
- Test VER-1 (5.9L Diesel)
- Test VER-2 (2.2L, 2.5L, 2.5L Turbo & 3.0L)
- Test VER-2 (3.9L & 5.2L)
- Test VER-2 (5.9L Gasoline)
- Test VER-3 (2.2L, 2.5L, 2.5L Turbo & 3.0L)
- Test VER-3 (3.9L & 5.2L)
- Test VER-3 (5.9L Gasoline)
- Wiring Diagrams
- Overhaul - A-413 & A-470
- Application
- Identification
- Description
- Lubrication & Adjustments
- On-Vehicle Service
- Trouble Shooting
- Testing
- Removal & Installation
- Torque Converter
- Transaxle Disassembly
- Component Disassembly & Reassembly
- Transaxle Reassembly & Adjustment
- Torque Specifications
- Overhaul - A-413/30TH & A-670/31TH
- Application
- Identification
- Description
- Lubrication & Adjustments
- On-Vehicle Service
- Trouble Shooting
- Overview
- Transaxle
- Buzzing Noise
- Delayed Engagement From Neutral To Drive
- Delayed Engagement From Neutral To Reverse
- Delayed Upshift
- Drags Or Links
- Grating, Scraping Or growling Noise
- Hard To Fill, Oil Blows Out Filler Hole
- Harsh Engagement From Neutral To Drive
- Harsh Engagement From Neutral To Reverse
- Harsh Upshift
- No Drive In Any Position
- No Kickdown Or Normal Downshift
- No Lock-Up
- No Upshift
- Runaway Upshift
- Shifts Erratic
- Slips In All Positions
- Slips In Drive Positions
- Slips In Reverse Only
- Transaxle Overheats
- Vehicle Moves In Neutral
- Vehicle Will Not Move In All Forward Positions
- Vehicle Will Not Move In Reverse
- 3-2 Kickdown Runaway
- Electronic Testing
- Testing
- Hydraulic Pressure Adjustments
- Removal & Installation
- Torque Converter
- Transaxle Disassembly
- Component Disassembly & Reassembly
- Bearing Adjustments
- Transaxle Reassembly
- Torque Specifications
- Transaxle Specifications
- Overhaul - A-604/41TE & 41AE
- Application
- Identification
- Description
- Operation
- Shift Quality Quick-Learn Procedure
- Pinion Factor Procedure
- Lubrication & Adjustments
- On-Vehicle Service
- Trouble Shooting
- Notes
- Buzzing Noise
- Buzzing Noise During Transaxle Shifts
- Delayed Engagement From Neutral To Drive
- Delayed Engagement From Neutral To Reverse
- Grating, Scraping Or Growling Noise
- Hard To Fill With Fluid Or Fluid Blows Out Filler Tube
- Harsh Downshifts
- Harsh Engagement From Neutral To Drive
- Harsh Engagement From Neutral To Reverse
- Harsh Torque Converter Lock-Up
- Harsh Upshift
- High Shift Efforts
- No Torque Converter Lock-Up
- No Upshift Into Overdrive
- Poor Shift Quality
- Shifts Erratically
- Transaxle Overheats
- Vehicle Drags Or Locks
- Vehicle Moves In Neutral
- Testing - Non-Electronic
- Removal & Installation
- Torque Converter
- Transaxle Disassembly
- Component Disassembly & Reassembly
- Bearing Adjustments
- Transaxle Reassembly
- Torque Specifications
- Transaxle Specifications
- Wiring Diagrams
- Removal & Installation - A/T
- Servicing - A/T
- Identification
- Lubrication Service Intervals
- Checking Fluid Level
- Recommended Fluid
- Fluid Capacities
- Draining & Refilling
- KICKDOWN (Front) Band Adjustments
- Low-Reverse (Rear) Band Adjustments
- Throttle Pressure Cable Adjustments
- Throttle Pressure Linkage Rod Adjustments
- Gearshift Linkage Adjustments
- Neutral Safety Switch Adjustments
- Torque Specifications
- Transmission Oil Pan Gasket Id
- Hydraulic Diagrams - A604
- Automatic Trans
- External Pages
